line interactive uninterruptible power supply USER MANUAL MODEL 168120/168175 MAN-168120/168175-UM-0606-06
Thank you for purchasing the MANHATTAN ® Line Interactive Uninterruptible Power Supply, Model 168120 or 168175. This uninterruptible power supply (UPS) is designed to keep computers and peripheral devices operating after a utility power failure that could result in component damage or loss of data. Whenever the UPS is plugged in, it maintains a full charge on its battery and serves to protect your equipment from utility-generated surges and noise.
safety instructions Prior to its operation, inspect this product for damage. If any damage is found, notify your dealer. Keep the carton and packing foam in the event the product must be returned to the factory for service (damage sustained in transit when shipped from the user is not covered under warranty). • Place the device indoors in an area that has adequate airflow and is free from excessive dust. Do not allow the UPS to be exposed to moisture, rain, excessive heat or direct sunlight.
Conditions Do not operate the UPS in an environment where the ambient temperature is outside the limits given in the Specifications section of this manual. Connection to the Utility Power Plug the UPS into an electrical outlet. Do not plug it into an outlet that already uses a heavy electric load (e.g., an air conditioner, refrigerator or laser printer).
Initial Battery Charging The UPS is shipped from the factory with its internal battery fully charged. However, the battery may lose some charge during shipping and storage. The battery should be recharged before conducting the following test for proper operation and to ensure the UPS will provide expected run time. The UPS automatically charges the battery whenever the UPS is plugged in (the On/Off/Test switch doesn’t have to be turned on).
source of power that is limited in duration. Restore power to the UPS by plugging in the line cord. Repeat this test four or five times to ensure proper operation. Another way to test the operation of the UPS is to simply press and hold the On/Off/Test button for two seconds or more, and then release it to run a self-test routine. The UPS will immediately transfer your equipment to power derived from its internal battery and run a self-test. See the next section if abnormal operation is encountered.
controls & indicators 5 4 3 2 1. On/Off/Test Button: This button controls power to the UPS and its output receptacles. Press and hold the button one to four seconds to switch on the UPS. Press and hold the button two to three seconds when the utility power is normal, and the UPS will simulate a utility outage and perform its self-test function. It provides a convenient means of testing the UPS’s battery.
6. AC Power Cord: Complete the necessary power connections. For Model 168120 (120 V), use an existing NEMA-type PC power cord to connect the PC to the UPS. Use the included NEMA-type power cord to connect the UPS to the power source. For 220 V models, use the included IEC-type power cord to connect the PC to the UPS. Use one of the existing PC power cords to connect the UPS to the power source. 9 7. Surge Protection (Bypass) Outlets: These protect against 6 surges and spikes. 10 11 10 11 8 7 6 8.
10. Communications Port: This connects the UPS to your computer via an RS-232 serial cable. (UPS monitor software is included.) NOTE: The UPS can work independently without an RS-232 connection. 11. Telephone/Network Surge Suppression: The RJ-11/45 module connectors are used for single-line telephone and 10 Base-T surge protection. NOTE: This connection is not needed to use the UPS. indicator table The UPS has both visible (LED) and audible (alarm) status indicators.
troubleshooting Symptom Possible Cause Action to Take The UPS will not turn UPS is not plugged into an AC Plug the UPS in and turn it on. If power is still not on. outlet and/or is not turned on. present, make sure the circuit breaker on your building is not accidentally turned off. Output short overload shutdown. Reduce the load and reset the circuit breaker (or replace the blown fuse if so designed).
Specifications Available in 120 V (NEMA) and 220 V (IEC) models Model 168120 • Outlets: 3 NEMA (120 V), 3 backup + surge only; 2 IEC (220 V), 2 back-up + surge • Times: - Backup: 3 minutes at full load; 10 minutes at 50% load; 30 minutes at varying loads (typical with PC and 15” LCD monitor at 85 W) - Recharge: 8 hours typical (12 hours maximum) - Transfer: 4 ms typical (10 ms maximum) • Communications port: RS232 (120 V); RS232 (220 V) • Telephone/fax/network ports: RJ-11/RJ-45 (1 in / 1 out), surge pr
• Operation relative humidity: 0 to 95% (non-condensing) • LED indicators: Online, Overload, On Battery and Bad Battery • Audible alarms: Overload, On Battery, Low Battery Package Contents • • • • Line Interactive UPS, 500 VA / 300 W Power Management Software CD (Windows 98/SE/Me/2000/XP compatible) Cables: RS232, 6 ft. (1.8 m); telephone (RJ-11), 6 ft. (1.8 m); power cord, 6 ft. (1.
• Voltage regulation: output, +/– 5% (battery mode) • Frequency regulation: output, 50/60 Hz +/– 1% • Automatic voltage regulation (AVR): 120 V and 220 V models • Waveform: simulated sine wave • Overload protection: 110% warning and UPS shutoff after 10 seconds; 120% UPS turnoff at once • Battery: capacity, 12 V / 5 Ah x 2; type, sealed and maintenance-free (lead acid) • Temperatures (°C): operation, 0 to 40; storage, -20 to 60 • Operation relative humidity: 0 to 95% (non-condensing) • LED indicators: Onlin
WARRANTY INFORMATION Coverage For the original purchaser of this MANHATTAN Uninterruptible Power Supply residing in the United States or Canada, the device itself features a lifetime warranty covering material and workmanship (with a three-year warranty on the battery). Should the UPS fail, it will either be repaired or replaced (manufacturer’s option).
a purpose, end when the original purchaser no longer owns the product and three years from the date of purchase for the battery. Note: Some states do not allow time limitations on implied warranties, which means the above limitations may not apply.
MANHATTAN offers a complete line of PC Components, Peripherals, Cables and Accessories. Ask your local computer dealer for more information or visit us online at ® www.manhattan-products.com Copyright © MANHATTAN All products mentioned are trademarks or registered trademarks of their respective owners.
