Service manual

ManualsBrandsMarco ManualsCoffee MakerFILTRO Manual-Fill Jug

Service Manual 1000615 Filtro Jug MF 1000616 Filtro Flask MF 02-05-06 Page 1 of 9

FILTRO

Manual-Fill Jug & Flask Version

- P/N: (Jug) 1000615 ; (Flask) 1000616

SERVICE MANUAL

Marco Beverage Systems Ltd.

63d Heather Road,

Sandyford Industrial Estate,

Dublin 18,

Republic of Ireland

Ireland Tel: (01) 295 2674

Ireland Fax: (01) 295 3715

UK Tel: (0207) 274 4577

UK Fax: (0207) 978 8141

Summary of content (9 pages)

PAGE 1
FILTRO Manual-Fill Jug & Flask Version - P/N: (Jug) 1000615 ; (Flask) 1000616 SERVICE MANUAL Marco Beverage Systems Ltd.
PAGE 2
INTRODUCTION The information provided in this manual is intended to assist in the installation and maintenance and service of the Manual-Fill versions of the Filtro Filter coffee Brewer. Please read the instructions carefully to prevent accidents and ensure an efficient installation. This manual is not a substitute for any safety instructions or technical data affixed to the machine or its packaging.
PAGE 3
TECHNICAL DETAILS Model Supply voltage Frequency Power Dimensions Empty Weight Capacity (per hr) Brew time Brew capacity max Manual-Fill Jug 1000615 230V 50Hz 2300W 220x385x460 [WxDxH] mm 6.1kg 18L 5 min 1.8L Manual-Fill Flask 1000616 230V 50Hz 2100W 220x385x615 [WxDxH] mm 7.1kg 18L 6.5 min 2.2L INSTALLATION ELECTRICAL  Electrical specification: 230Vac. 50Hz.  This machine must be connected to a fused 13A single-phase power supply.
PAGE 4
 The machine is now ready for use.  If the machine is ever fully drained this process must be repeated. BREWING COFFEE    Use fine grain coffee which has been ground for use with filter brewers. Keep the jugs/flasks and basket filter clean Put the correct amount of ground coffee into the filter paper. Your coffee supply company may have pack sizes to suit the brews of your new brewer; if not, as an approximate guide for your first brews: Water Volume Coffee  Glass Jug 1.8L 65-90 grams Flask 2.
PAGE 5
        Wait about 2 minutes. The solution will react with the scale in the heating system. After the 2 minutes switch the machine back on and allow the rest of the solution to run through the system. At the end of the process the ‘Brew Ready’ light will illuminate and the sounder will sound. (2 short pulses). Dispose of the de-scale solution and rinse out the jug/flask.
PAGE 6
TROUBLESHOOTING GUIDE If you have any difficulty with your machine do not hesitate to call us. Some common faults and solutions are highlighted in the table below. Fault Possible Cause Action The machine is not working and the lamp in the switches are not lighting. The fuse in the fuse box has been triggered the units loading the system too heavily Replace/Reset the fuse. Connect the unit to a more suitably rated supply. The "Brewing" LED is on but no water is flowing into the filter basket.
PAGE 7
“Descale Reset” Button Figure 1 Figure 2 Service Manual 1000615 Filtro Jug MF 1000616 Filtro Flask MF 02-05-06 Page 7 of 9
PAGE 8
Figure 3: Wiring diagram for FILTRO Manual-Fill Jug [P/N 1000615] Service Manual 1000615 Filtro Jug MF 1000616 Filtro Flask MF 02-05-06 Page 8 of 9
PAGE 9
Figure 4: Wiring diagram for FILTRO Manual-Fill Flask [P/N 1000616] Service Manual 1000615 Filtro Jug MF 1000616 Filtro Flask MF 02-05-06 Page 9 of 9