Figure 236, Page 1 P324-776 Owner’s Manual Outdoor Gas Fire Pit Manufacturer: XIQIAO INDUSTRIAL ZONE, SHALONG ROAD, JIUJIANG TOWN, FOSHAN CITY, GUANGDONG, 190, 528208 CHINA. IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLY This item is intended for outdoor domestic use only. Not for commercial use. Questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-866-839-2888 8 a.m. - 5 p.m.
SAFETY INFORMATION Figure 236, Page 2 Please read and understand this entire manual before attempting to assemble, operate or install the product. This appliance has been tested to and complies with the ANSI Z21.97-2014, Outdoor Decorative Gas Appliances. When connecting to a fixed piping system, the installation must conform to local codes or in the absence of local codes, to the National Fuel Gas Code. ANSI Z223.1.NFPA 54; National Fuel Gas Code; National Gas and Propane Installation Code, CSA B149.
SAFETY INFORMATION DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Failure to comply with the precautions and instructions provided with this fire pit can result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon monoxide poisoning. Only persons who can understand and follow the instructions should use or service this fire pit.
SAFETY INFORMATION WARNING We cannot foresee every use which may be made of our fire pit. Check with your local fire safety authority if you have questions about fire pit use. Other standards govern the use of fuel gases and heat producing products for specific uses. Your local authorities can advise you about these. If no local codes exist, follow National Fuel Gas Code, ANSI Z223.1. In Canada, installation must conform to local codes.
OPERATION CHECKLIST Figure 236, Page 5 Operation Checklist For a safe and pleasurable heating experience, perform this check before each use. Before Operating: 1. I am familiar with the entire owner’s manual and understand all precautions noted. 2. All components are properly assembled, intact and operable. 3. No alterations have been made. 4. All gas connections are secure and do not leak. 5. Wind velocity is below 16 km/h (10 mph). 6. Unit will operate at reduced efficiency below 4.44°C /40°F 7.
EXPLODED VIEW Figure 236, Page 6 Lava rock (4kg) Top cover Table top Side Back post Back post Battery Side Ignition side Base Door Front right post Front left post Bolt Washer Allen key Washer
ASSEMBLY INSTRUCTIONS FOR LP Step 1 Step 2 Figure 236, Page 7
ASSEMBLY INSTRUCTIONS FOR LP Step 3 Step 4 Figure 236, Page 8
ASSEMBLY INSTRUCTIONS FOR LP Step 5 Step 6 Figure 236, Page 9
ASSEMBLY INSTRUCTIONS FOR LP Step 7 Figure 236, Page10
CONNECTING AND DISCONNECTING LP & NG Figure 236, Page 11 • Connecting LP Gas Tank Before connecting, be sure that there is no debris caught in the head of the LP gas tank, head of the regulator valve or in the head of the burner and burner ports. Connect regulator/hose assembly to tank by turning knob clockwise. LP GAS • Disconnecting LP Gas Tank Before disconnecting make sure the LP gas tank valve is "CLOSED.
LEAK TESTING Figure 236, Page 12 WARNING: Before using this outdoor fire pit, make sure you have read, understand and are following all information provided in the Dangers and Warnings. Failure to follow those instructions can cause death, serious injury or property damage. WARNING • • • • Never use your fire pit without leak testing all gas connections, hoses and propane tank. DANGER To prevent fire or explosion hazard: DO NOT smoke or permit ignition sources in the area while conducting a leak test.
BATTERY INSTALLATION Figure 236, Page 13 1x AAA Battery (included) OFF
LIGHTING INSTRUCTIONS Figure 236, Page 14 Caution: Keep outdoor gas cooking appliance area clear and free from combustible materials, gasoline and other flammable vapours and liquids. Caution: Do not obstruct the flow of combustion and ventilation air. Caution: Check and clean burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill. Caution: Attempting to light the burner with the lid closed may cause an explosion. • Lighting 1.
TROUBLESHOOTING PROBLEM Figure 236, Page 15 POSSIBLE CAUSE CORRECTIVE ACTION Propane cylinder is empty Replace propane cylinder Blockage in orifice Clear blockage Control knob is not in ON position Turn control knob to ON Gas pressure is low Turn cylinder valve OFF and fill the cylinder Outdoor temperature is less than 4.
CARE AND MAINTENANCE Figure 236, Page 16 CAUTION: All cleaning and maintenance should be done when fire pit is cool and with the fuel supply disconnected. 1. DO NOT clean any outdoor fire pit part in a self cleaning oven. The extreme heat will damage the finish. 2. Do not enlarge valve orifices or burner ports when cleaning the valves or burners. Notices 1. This outdoor fire pit should be thoroughly cleaned and inspected on a regular basis. 2. Abrasive cleaners will damage this product. 3.
Figure 236, Page 17 CARE AND MAINTENANCE / ENTRETIEN ET MAINTENANCE / CUIDADO Y MANTENIMIENTO FOR DOMESTIC USE ONLY. POUR USAGE DOMESTIQUE SEULEMENT. WICKER: CLEANING – UV protected synthetic wicker allows colour retention after hours of outdoor use. Hose off outdoors for easy cleaning. Wipe up minor spills with a mild soap and damp cloth. GLASS TABLE TOPS: CLEANING – Use mild soap and water or glass cleansers. Do not use abrasive materials or cleansers.
