Owner manual

Gamma 1-16 LSC&
Gamma 2-16 LSC&
3 Safety
26
Version 04/2013, Rev. 1.1 of 16/12/2013 • sb
Translation of the original operating manual
Pos: 60 / 200 C hrist /36 0 GT-B A La bor-P ilot (S TA NDA RDMODU LE) /03 0 Sicher heit/ 030 -00 60- 0020 Mechani sch e Sic herhei t @ 5\ mod _12 991364 640 88_ 68.d ocx @ 347 24 @ 3 @ 1

3.6.2 Mechanical safety
In order to ensure the safe operation of the freeze-dryer, please comply
with the following points:
WARNING
• Do not use the freeze-dryer if it was installed incorrectly.
• Do not use the freeze-dryer without panels.
• Do not use the freeze-dryer with accessories that shows signs of
damage.
• Only use the freeze-dryer with accessories that have been approved by
the manufacturer. In case of doubt, contact the manufacturer (see
chapter 7.3 - "Service contact").
• Do not hit or move the freeze-dryer during its operation.
• Do not lean against or rest on the freeze-dryer during its operation.
• Check the freeze-dryer and the accessories before every start-up for
any visible signs of damage.
• Do not dry any substances that could damage the material of the ice
condenser chamber, drying chamber, lid, or accessories in any way,
e.g. highly corrosive substances such as hydrogen chloride (HCl).
• Stop the freeze-dryer immediately in the event of a malfunction.
Eliminate the malfunction (see chapter 7 - "Malfunctions and error
correction") or contact the after-sales service of Firma Martin Christ
Gefriertrocknungsanlagen GmbH (see chapter 7.3 - "Service
contact").
Pos: 61 /010 Unive rsalm odule/ L ee rzeile @ 0\ mod _120211 624450 0_0.docx @ 11 4 @ @ 1
Pos: 62 / 200 Christ /36 0 GT -BA La bor -Pil ot (S TAND ARD MODULE )/03 0 S icher heit/ 030 -00 60-003 0 Br andsc hutz @ 5\ mod_12 991 364 6452 5_6 8.d ocx @ 347 32 @ 3 @ 1

3.6.3 Fire prevention
Fuses protect certain electrical circuits within the freeze-dryer against over-
current conditions.
DANGER
• Always use fuses of the same type and rating.
• Do not dry explosive or inflammable substances.
• Do not use the freeze-dryer within hazardous locations where there is a
risk of explosion.
Pos: 63 /010 Unive rsalm odule/ L ee rzeile @ 0\ mod _120211 624450 0_0.docx @ 11 4 @ @ 1
Pos: 64 / 200 Chris t /36 0 GT-B A La bor -Pi lot (S TA NDA RDMOD ULE) /03 0 S icher heit/ 030 -00 60- 004 0 The rmisc he S iche rhei t @ 5 \mo d_1 299 136 4649 16_ 68. docx @ 347 40 @ 3 @ 1

3.6.4 Thermal safety
During the operation of the freeze-dryer, the ice condenser can reach
surface temperatures of –85°C depending on the power.
DANGER
• Wear suitable protective gloves when installing or removing
accessories. Do not reach into the ice condenser chamber without this
protection – your limbs may freeze onto the chamber walls!
Pos: 65 /010 Unive rsalm odule/ Seit enwec hsel @ 0\m od_120 2116244 312_0. docx @ 105 @ @ 1