Specifications

ModPac II, 9/09-15

Marvair

strongly recommends that the air conditioner be serviced a minimum of twice a year

– once prior to the heating season and once prior to the cooling season. At this time the lters,

evaporator coil, condenser coil, the cabinet, and condensate drains should be serviced as described

below. Also at this time, the air conditioner should be operated in the cooling and heating cycles

as described in Chapter 3, Start-Up. In addition to this seasonal check-out, the ModPac™ A/C

should be maintained as follows:

Air Filter

Replace the air lter whenever it is visibly dirty.

Evaporator

If the evaporator becomes clogged or dirty, it may be cleaned by careful vacuuming or with a

commercial evaporator cleaning spray. DO NOT use a solvent containing bleach, acetone, or

ammable substances. Turn power off before cleaning. Be careful not to wet any of the electrical

components. Be sure the unit has dried before restarting.

Condenser

Periodically inspect the outdoor condenser coil and the cabinet air reliefs for dirt or obstructions.

Remove foreign objects such as leaves, paper, etc.

If the condenser coil is dirty, it may be washed off with a commercial solvent intended for this

purpose. TURN OFF POWER BEFORE CLEANING! Be sure that all electrical components

are thoroughly dry before restoring power.

Cabinet

The cabinet may be cleaned with a sponge and warm, soapy water or a mild detergent. Do not

use bleach, abrasive chemicals or harmful solvents.

Drains

Regularly check the primary and secondary condensate drains. The secondary drain has a stand

pipe. An obstruction will force water to dump into the middle of the unit and drain out the sides

of the ModPac II™ A/C, causing discoloration of the side panels. If discoloration is noted, service

the drains.

If a commercial drain solvent is used, ush out the drain pan and system with plenty of fresh

water to prevent corrosion.

Lubrication

Oiling of the condenser fan motor or the evaporator blower motor is not recommended.

6.1 Scheduled Maintenance

Maintenance