Gas Grills Owner's Manual

ManualsBrandsMaster Chef ManualsGrilloutdoor Stovetop

WARRANTY

STOP

Do not return the product to the store.

IF YOU NEED HELP OR PARTS, CALL THE MASTER CHEF HOTLINE

1-877-707-5463

HOURS: 8AM-7PM EST Mon-Fri, Close Saturday and Sunday

GET HELP FOR:

MISSING/DAMAG E D PAR TS • ASSEMBLY • TROUBLESHOOTING • WAR R A N T Y ASSISTANCE

• PRODUCT INFORMATION

TIP: AS S E M B L E YOUR GRILL IMMEDIATELY. MISSING OR DA MAGED PA R TS MUST BE

CLAIMED WITHIN 30 DAYS, OF PURCHASE.

GRILL SAFETY CHECK

For your family’s safety, please check the following:

READ and UNDERSTAND the owner’s manual

PERFORM LEAK TEST on all connections as specied in this user manual. Leak Checks should be performed

on all new BBQ’s even if assembled by an assembler or gas technician. Leak checks should be performed

frequently thereafter.

INSPECT and CLEAN burner tubes to avoid ash res caused by spider webs and other blockages. Inspect gas

jets to ensure they are correctly installed in burner tubes. Never leave a lit grill unattended.

BEFORE OPENING THE GAS SUPPLY, ensure the lid is open, control knobs are in OFF position, gas is turned o,

and the regulator is attached to tank correctly. Then follow the PROPER LIGHTING PROCEDURE as shown in the

manual. If above steps are not followed, you may experience low ames, or other performance issues.

CHECK that the regulator nipple is centered into the LP tank valve. Do NOT cross thread this connection. Cross

threading may result in a re, or explosion at the tank connection.

AVOID dangerous grease res by performing regular cleaning and maintenance of interior casting, the grease

collection system, ame tamers and cooking grates.

SAFETY & CARE MANUAL

DANGER

1. If you smell Gas:

a. Shut o gas to the appliance

b. Extinguish any open ame

c. Open lid

d. If odor continues, keep away from

the appliance and immediately

call your gas supplier or your

re department

2. Do not store or use gasoline or other

ammable liquids or vapours in the

vicinity of this or any other appliance.

3. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any

other appliance.

WARNING

Failure to follow all of the Manufacturer’s

instructions could result in hazardous res,

explosions, property damage, or serious

personal injury or even death.

Follow all leak check procedures carefully

prior to operation of barbecue, even if grill

was dealer assembled. Do not try to light

this barbecue without reading the Lighting

Instructions section of this manual.

THIS MANUAL MUST REMAIN WITH THE PRODUCT AT ALL TIMES

To ORDER non-warranty replacement parts or accessories, or to register your warranty,

please visit us on the web at

www.masterchefbbqs.com.

CAUTION

Read and follow all safety statements,

assembly instructions, and use and care

directions before attempting to assemble

and cook.

THIS BARBECUE IS FOR OUTDOOR USE ONLY

INSTALLER OR ASSEMBLER/CONSUMER

This manual should be kept with the BBQ at

all times.

Manual Revision #: 13102009 PD

Summary of content (11 pages)

PAGE 1
WARRANTY S TOP Do n ot re turn the pro duc t to the sto re. IF YOU NEED HELP OR PARTS, CALL THE MASTER CHEF HOTLINE 1-877-707-5463 HOURS: 8AM-7PM EST Mon-Fri, Close Saturday and Sunday GET HELP FOR: MISSING/DAMAGED PAR TS • ASSEMBLY • TROUBLESHOOTING • WARR ANT Y ASSISTANCE • PRODUC T INFORMATION TIP: ASSEMBLE YOUR GRILL IMMEDIATELY. MISSING OR DAMAGED PAR TS MUST BE CL AIMED WITHIN 30 DAYS, OF PURCHASE.
PAGE 2
INSTALLATION CAUTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. For residential use ONLY. Do not use for commercial cooking. ADDITIONAL WARNINGS WARNING Do not attempt to repair or alter the hose and regulator or valve assembly for any assumed defect or for any type of retro fit or conversion. Any modifications to this assembly will void your warranty and create the risk of a gas leak and fire.
PAGE 3
GAS HOOK-UP’S AND WARNINGS (LP) LIQUID PETROLEUM GAS LP GAS WARNINGS: • LP gas is nontoxic, odorless and colorless when produced. For Your Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. • Always turn cylinder valve off when the barbecue is not in use. • LP gas is highly flammable and may ignite unexpectedly when mixed with air. • Never connect an unregulated LP gas cylinder to the barbecue • Always handle the tank valve with the utmost care.
PAGE 4
LEAK TESTING THE VALVE, HOSE AND REGULATOR ASSEMBLY LP Cylinder Leak Test For Your Safety 1. Turn all grill control knobs to OFF. ATTENTION: Leak Test must be repeated each time the LP cylinder is exchanged or refilled. 2. Ensure that the regulator is tightly connected to LP cylinder. 3. Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a leak at the connection. Correct before proceeding.
PAGE 5
NATURAL GAS HOOK-UPS AND WARNINGS NEW Natural Gas Barbecue Match-Lighting Main Burners If you are experiencing poor natural gas barbecue performance, including but not limited to low flame, low heat or poor heat distribution, please review the following information: 1. Open lid. Turn off all control knobs. Ensure LP cylinder is closed. • Always consult the Rating Label on the back of the barbecue to confirm that it has already been configured to burn natural gas. 2.
PAGE 6
COOKING AND PERFORMANCE ATTENTION Always preheat barbecue before starting to cook. Light all burners and adjust them to the HIGH position for 5 to 10 minutes with the lid closed. Following preheat; adjust the controls to medium setting for most cooking requirements. ! ! ! • CAUTION! Turning Grill Off • AVOID BURNS! 1. Turn all knobs to OFF position. • DO NOT TOUCH WHEN BBQ IS IN USE! 2. Turn LP cylinder off by turning hand-wheel clockwise to a full stop or turn off natural gas supply valve.
PAGE 7
FLASH FIRES Characteristics of a Flash Fire • This gas barbecue has a 12,000 BTU infrared rear burner. The rear burner is designed to be used in conjunction with the Centro Rotisserie Kit. See the Rotisserie Kit for usage and assembly instructions. • Place the prepared spit rod across the hangers inside the grill. • A fire burning outside of the burner box • Usually visible behind or under the control panel • Install motor.
PAGE 8
PROBLEM CAUSE CORRECTIVE ACTION Igniter does not spark – Burner lights with match but not with the igniter Electrode Fouled Wipe the electrode with a soft, clean cloth. If electrode has any build up of grease or corrosion, lightly sand electrode tip and clean with alcohol. Electrode or burner is wet Wipe both parts dry before trying to re-light.
PAGE 9
Resolving BURNER Performance Issues • Remove and clean heat plates every other time you BBQ or more frequently if cooking for a large group of people. PROBLEM IDENTIFYING THE CAUSE: Low or incomplete flame (assuming burners and Venturi tubes are free and clear of blockages) • Proper start up and shut down procedure not followed. Flow limiting device has been activated and requires resetting • Positive connection not made between tank and manifold.
PAGE 10
WARRANTY AND SERVICE How to season Porcelain Cast iron cooking grates BEFORE YOU CALL FOR SERVICE have the following information available: 1. Remove cooking grates from BBQ and brush away all loose, or chipping porcelain and grease build-up, using a BBQ brush 2. Wash cooking grates with soap and water. 3. Rinse and dry thoroughly with paper towels. Important: Never soak or let soapy water sit on the grates for any length of time. 4.
PAGE 11
WARRANTY LIMITATION AND EXCLUSIONS Trileaf Distributions® has the following limitations to its warranty: 1. This limited warranty is non-transferable and becomes void if used for commercial or rental purposes. 2. This warranty applies only when barbecue is used in Canada 3. Warranty is in lieu of all warranties, expressed or implied, and all other obligations or liabilities related to the sale or use of its grill products. 4.