INSTALLATION & INSTRUCTION MANUAL
By: Quality Leisure Products 7112 W. Frier Drive Glendale, AZ 85303 866-939-0851 Most service calls can be handled on the phone. Front and bottom panel removal allows easy access to all interior spa plumbing for easy checking or repair. Total jet accessibility in minutes. Top of the line Balboa controls, Waterway/Pentair pumps and top quality jets are standard on all models in the Tuff Spa line. All spare parts are instantly available from the factory, if not already in stock at your dealer.
Quick Reference For Spa Set Up Read and Understand all Instructions Before Using Your Spa 1. Locate Spa on a level surface that will support 3,000 lbs. 2. Fill Spa to cover top jets. 3. Remove front panel, remove the cord. Place through the slot on the access panel. Replace panel. 4. Plug the G.F.I. cord into a 20 amp Dedicated 110 volt circuit receptacle. 5. Avoid using extension cords. 6.
SPA SET UP AND OPERATING GUIDE TS-100, TS-300, TS500 Read and Understand All Instructions before operating your Spa. Selecting the right site for your new Spa It is important that your new Spa be installed on a Solid, Flat, and Level Surface that is engineered to carry a load of 75 pounds per square feet. The proper site of your New Spa is in an area that is Not Accessible to Children. Security or Pool Yard gates should be in place to separate Children from the Spa.
DANGER: RISK OF ELECTRIC SHOCK Do not permit any electric appliance such as a light, telephone, radio, or television within 5 feet of a spa or hot tub. TO REDUCE THE RISK OF INJURY: The water in the spa or hot tub should never exceed 40° C (104° F). Water temperatures between 38° C (100° F) and 40° C (104° F) are considered safe for a healthy adult. Lower water temperatures are recommended for extended use (exceeding 15-20 minutes) and for younger children.
Care and Maintenance Instructions Cleaning the Filter Cartridge 1. 2. 3. 4. 5. 6. Disconnect power Remove the Filter Cover Remove the Filter Cartridge by pulling straight up Rinse Dirt and Debris away thoroughly with a garden hose Replace Filter Cartridge and Cover. Spa Power can then be turned back on Water Chemistry Read and Understand the Spa Chemistry Guidelines supplied by your dealer or chemical supplier. Some general guidelines and tips are listed on next page.
Guide to Spa Water Chemistry Cleaning your hot tub 1. Drain your spa water every 3 to 4 months, depending on use. 2. The filter should be cleaned every month or more frequently for high bather loads. Soak overnight in filter cartridge cleaner and rinse well before replacing in spa. 3. Refill spa with fresh water to the recommended level. The water line should cover all the upper jets in the spa.
IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS WARNING: CHILDREN SHOULD NOT USE SPA OR HOT TUBS WITHOUT ADULT SUPERVISION AVERTISSEMENT: NE PAS LAISSER LES ENFANTS UTILISER UNE CUVE DE RELAXATION SANS SURVEILLANCE WARNING: DO NOT SUE SPAS OR HOT TUBS UNLESS ALL SUCTION GUARDS ARE INSTALLED TO PREVENT BODY AND HAIR ENTRAPMENT AVERTISSEMENT: POUR EVITER QUE LES CHEVEUX OU UNE PARTE DU CORPS PUISSENT ETRE ASPIRES, NE PAS UTILISER UNE CUVE DE RELAXATION SI LES GRILLES DE PRISE D’ASPIRATION NE SO
IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS WARNING: BEFORE ENTERING THE SPA OR HOT TUB MEARSURE THE WATER TEMPERATURE WITH AN ACCURATE THERMOMETER AVERTISSEMENT: AVANT D’UTILISER ONE CUVE DE RELAXATION MESURE LA TEMPERATURE DE L’EAU A L’AIDE D’UN THERMOMETRE PRECIS WARNING: DO NOT USE A SPA OR HOT TUB IMMIDIATELY FOLLOWING STRENUOUS EXERCISE AVERTISSMENT: NE PAS UTILISER ONE CUVE DE RELAXATION IMMDIATEMENT APRES UN EXERCISE FATIGANT WARNING: PROLONGED IMMERSION IN A SPA OR HOT TUB ME BE
TO ALL ORIGINAL PURCHASERS OF THIS PRODUCT LIFETIME WARRANTY Tuff Spas™ warrants the spa shell/skirting against water loss and structural integrity due to defects in the spa for Lifetime. For original purchaser only, warranty is non-transferable. 5- YEAR WARRANTY Tuff Spas™ warrants the interior and exterior surface of the spa against cracking or delaminating for 5 years from date of purchase. For original purchaser only, warranty is non-transferable.