Specifications
2005 MASTERCRAFT OWNERS MANUAL–PA G E 8-1
SAFETY
CHECKS
SERVICES
AND
> > >
DO NOT launch or operate the boat if
any problem is found during the Safety
Check. A problem could lead to an
accident during the outing, resulting
in serious injury or death. Any and all
problems should receive attention im-
mediately. See your MasterCraft dealer
for assistance.
The following checks and services are essential to safe boating and must be performed. Get in the habit of performing these
checks in the same order each outing so that it becomes routine.
BEFORE EACH OPERATION
These tasks are best accomplished before the boat is launched.
Check the weather report, wind and water conditions.
Check for recommended on-board tools and parts.
Check that all drain plugs are installed properly, including bilge and rear drain.
Check the propeller and shaft for damage.
Check the cooling water intake pick-up and transmission cooler for blockage.
(Additional details on this will follow in the Scheduled Maintenance
Checks and Service Section.)
Check the raw water impeller if the boat showed signs of over-heating
during the last usage.
Check the engine oil level.
Check that there is an adequate supply of fuel.
Check that the steering system operated properly.
Check that required safety equipment is on-board.
Check that the mandatory personal flotation device for each passenger is on-board.
Check that fire extinguisher is fully charged.
Check that no fuel, oil or water is leaking or has leaked into the bilge component.
Check all hoses and connections for leakage or damage.
Check that the alternator belt is in good condition.
Check the engine drain plugs.
Check that all required Scheduled Maintenance Checks and Services
(see following sections) were performed.
DURING OPERATION
Check gauges frequently for operating conditions.
Check that controls operate smoothly.
Check for excessive vibration.
AFTER OPERATION
Check for fluid leaks.
Check the fins, propeller, rudder and shaft for damage after removing the boat from the water.
In boats equipped with a ballast system, drain water from the ballast before towing.