Instruction manual

GEnERAl InFORMATIOn
Gas installation codes
Barbecues must be used in accordance with
the installation requirements of your gas supply
authority, or the appropriate installation code
issued by Standards Australia AS 5601.
Barbecues for use with bottled gas are labelled
‘propane gas’.
Barbecues for use with natural gas are labelled
‘natural gas’ and must be installed by an
authorised person. Check the gas type sticker
attached to the barbecue.
Clearances
Minimum Clearances from combustible materials
must be:
Rear - 600mm Sides - 600mm Above - 600mm
Hose and regulator safety
The regulator and hose assembly supplied with the
barbecue are suitable for propane gas only.
A gas regulator adjusted to have an outlet
pressure of 2.75kPA is supplied for connection to
the propane gas cylinder. The pressure regulator
and hose assembly supplied with the barbecue
must be used. Replacement pressure regulators
and hose assemblies must be those specified by
the barbecue manufacturer.
When connecting the hose and regulator assembly
to the gas cylinder, take care to avoid unnecessary
twisting of the flexible hose.
IMPORTAnT GAs &
sAFETY InsTRucTIOns
After the assembly has been secured, turn on the
gas and check for leaks by brushing a soap and
water solution over all connections.
If you are unable to correct the leak by tightening
the connections, turn off the gas and contact the
supplier immediately.
Always ensure the barbecue is kept away from
flammable materials and the gas cylinder clear of
any heat source.
When changing over from an empty gas cylinder to
a full one make sure this procedure is carried out in
a flame free atmosphere.
Specifications
Barbecue specifications can be found on the data
label attached to the barbecue body.
Hose connection thread at gas inlet is 5/8”-18UNF.
Gas cylinder use and safety
This is a low pressure barbecue and must only be
used with the hose and regulator supplied. Your
barbecue is designed for use with 4.5Kg or 9Kg
propane gas cylinders certified to AS 2469.
The gas cylinder should be filled by a reputable gas
supplier and visually inspected and re-qualified at
each filling.
Always keep cylinder in an upright position. Always
close the cylinder valve when the barbecue is not
in use.
Do not subject gas cylinder to excessive heat.
Never Store your Gas Cylinder Indoors.
WARnInG:
Failure to comply with these instructions could result in a fire
or explosion which could cause serious bodily injury, death or
property damage.
Accessible parts may be very hot.
Keep young children away.
Any modifications of this barbecue may be dangerous.
Do not move this barbecue during use.
Turn off gas supply at the gas cylinder after use.
Read instructions before using the barbecue.
Parts sealed by the manufacturer or their agent must not be
manipulated by the user. This barbecue is only to be used and
stored outdoors.
Do not test for gas leaks with an open flame.
If this information is not followed exactly a fire causing death or
serious injury may occur. Do not store a spare gas cylinder under
or near this barbecue. Never fill the cylinder beyond 80% full. This
barbecue is only to be used and stored outdoors.
Never operate this barbecue without a regulator.
If you smell gas
1. Shut off gas to the barbecue at its source, if possible.
2. Extinguish any open flame.
3. Open hood.
4. If odour continues immediately call your gas supplier or fire
department.
Do not connect your barbecue to a gas cylinder exceeding 9Kg
capacity.
Never connect an unregulated gas cylinder to your barbecue.
Read carefully before assembling and operating your barbecue.