Operation Manual

Drainage Pipe Material, Heat-insulating Material
Measure diameter of the hard pipe using cutting method, and adjust the joining angle.
Pull out the flexible hose, do not over deform than illustrated below.
Be sure to bind it with the attached band.
Please place the flexible hose horizontally.
Polyvinyl chloride pipe (f32mm outer diameter)
Foamed polyethylene insulation plate (10mm thickness)
VP30
Support
Bend
Up and Down
Fold
As long as possible about (10mm)
Lean Downward
over 1/100
Flexible Hose
Connection Procedure
Core shift adjustment
o
Bend 45 C(Maximum)
Hose band
Flexible Hose
Indoor Unit
The listed material should be used:
Connect the transparent pipe with the polyvinyl chloride pipe.
Use polyvinyl chloride glue at the connection part of the drainage pipe, be sure no water
leakage.
Paste glue at the front 40mm of the polyvinyl chloride pipe, insert it into the transparent pipe.
It needs 10 minutes for the glue to dry. Do not impose pressure on the connection during the
drying period.
Drainage Pipe
Material
Heat Insulation
Material
20
o
4
5
1.5m~2m
Lean Downward over 1/100
14
Check whether the drain pipe is unhindered before testing.
1) Stow water from sprue to check.
2) Stow 600cc water with pot or hose from sprue slowly , preventing touching the drain pump motor.
3) After the preparation work , disconnect the water level switch ,power 220-240VAC to of terminal
board, and the drain pump start up immediately.
4) After drain pump run 2 min.,reset the water level pin, and the drain pump motor will stop after
running 1 min..
.
L
N
Motor Sound Test
The drainage test is doing during checking the drain pump motor running sound .
Reset the water level switch connection to the original position after the drainage test .
Drainage Upward
Drainage Test
To make sure that the drainage pipe would not be slanted
downward, lead it upward to a height 360mm maximum,
then downward lead it.
Below 360mm
Below 600mm
Below
100mm
Indoor Unit
Ceiling
Heat Insulation
Wrap the flexible hose carefully with the attached heat insulation material from the start to the
end (to indoor part)
Flexible Hose
Hose band
Attached Heat-insulation
Material
Polyvinyl Chloride PipeField-arranged
Heat-insulation
Material
Drain pipe connection
Sprue
15