maxxx cold manual:Layout 1 5/16/11 11:11 AM Page 2 Pizza Prep Tables Megatop Sandwich/Salad Units Undercounter Refrigerators and Freezers Worktop Refrigerators and Freezers INSTRUCTION MANUAL MXCRMAN 0411 REV A English PLEASE READ THESE INSTRUCTIONS CAREFULLY BEFORE USE
maxxx cold manual:Layout 1 5/16/11 11:11 AM Page 4 SERIAL NUMBER INFORMATION The serial number of all self-contained refrigerators and freezers is located inside the unit on the left hand side near the top on the wall. Always have the serial number of your unit available when calling for parts or service. This manual covers standard units only. If you have a custom unit, consult the customer service department at the number listed on the last page.
maxxx cold manual:Layout 1 5/16/11 11:11 AM Page 5 SPECIFICATIONS PIZZA PREP TABLES MXCPP50 MXCPP70 MXCPP92 SANDWICH / SALAD UNITS MXCR29S MXCR48S MXCR60S MEGATOP SANDWICH / SALAD UNITS MXCR29M MXCR48M MXCR60M UNDERCOUNTER & WORKTOP REFRIGERATORS MXCR27U MXCR48U MXCR60U UNDERCOUNTER & WORKTOP FREEZERS MXF27U MXF48U MXF60U 3
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 6 INSTALLATION Location: Units represented in this manual are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. A fully loaded unit can weigh as much as 1500 pounds. Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 7 INSTALLATION Electrical connection: Refer to the amperage data on page 3, the serial tag, your local code or the National Electrical Code to be sure the unit is connected to the proper power source. A protected circuit of the correct voltage and amperage must be run for connection of the line cord, or permanent connection to the unit.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 8 SOLID-STATE THERMOSTAT DESCRIPTIION 1. FRONT PANEL COMMANDS SET: To display target set point; in programming mode it is used to select a parameter or confirm an operation (DEF) To start a manual defrost (UP):To see the last temperature alarm; in programming mode it browses the parameter codes or increases the displayed value (DOWN)To see the last temperature alarm; in programming mode it browses the parameter codes or decreases the displayed value.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 9 MAINTENANCE The power switch must be turned to OFF and the unit disconnected from the power source whenever performing service, maintenance functions or cleaning the refrigerated area. Refrigerators and Freezers The interior and exterior can be cleaned using soap and warm water. If this isn't sufficient, try ammonia and water or a nonabrasive liquid cleaner.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 10 MAINTANANCE Stainless Steel Care and Cleaning To prevent discoloration or rust on stainless steel, several important steps need to be taken. Stainless steel contains 70-80% iron which will rust. It also contains 12-30% chromium which forms an invisible passive film over the steel’s surface which acts as a shield against corrosion. As long as the protective layer is intact, the metal is still stainless.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 11 MAINTENANCE Doors/Hinges Over time and with heavy use doors the hinges may become loose. If the door is beginning to sag, it may become necessary to tighten the screws that mount the hinge brackets to the frame of the unit. If the doors are loose or sagging this can cause the hinge to pull out of the frame which may damage both the doors and the door hinges. In some cases this can require qualified service agents or maintenance personnel.
maxxx cold manual:Layout 1 5/16/11 11:12 AM Page 12 MAINTENANCE Open the bottom shroud Loosen and remove the screw from the two holes in front of the bottom shroud, then the bottom shroud can be move out.
MXCPP50/70/90 TPP-44,TPP-67,TPP-93 MXCR29S/48S/60S TSSU-29,TSSU-48,TSSU-60 MXCR29M/48M/60M TUC-27,TUC-48,TUC-60 MXCR27U/48U/60U TUC-27W,TUC-48W,TUC-60W MXCF27U/48U/60U TUC-27F,TUC-48F,TUC-60F TUC-27FW,TUC-48FW,TUC-60FW WIRING DIAGRAMS 12
maxxx cold manual:Layout 1 5/16/11 11:11 AM Page 1 www.maxxcoldfoodservice.