Installation Guide

ManualsBrandsMaytag ManualsDouble Electric Wall OvensMEW9627FZ

INSTALLATION INSTRUCTIONS

27" (68.6 CM) AND 30" (76.2 CM) ELECTRIC

SINGLE AND DOUBLE BUILT-IN OVEN

INSTRUCTIONS D’INSTALLATION

FOUR ÉLECTRIQUE ENCASTRÉ 27" (68,6 CM) ET 30"

(76,2 CM) - SIMPLE ET DOUBLE

Table of Contents/Table des matières

BUILT-IN OVEN SAFETY...............................................................2

INSTALLATION REQUIREMENTS................................................2

Tools and Parts ............................................................................2

Location Requirements................................................................2

Electrical Requirements ...............................................................5

INSTALLATION INSTRUCTIONS..................................................6

Prepare Built-In Oven...................................................................6

Remove Oven Door(s)..................................................................6

Replace Oven Door(s) ..................................................................7

Positioning Oven Feet for Multiple Cabinet

Cutout Heights .............................................................................7

Make Electrical Connection .......................................................11

Install Oven.................................................................................12

Install Warming Drawer Deflector Kit.........................................14

Complete Installation .................................................................14

SÉCURITÉ DU FOUR ENCASTRÉ ..............................................15

EXIGENCES D'INSTALLATION...................................................16

Outillage et pièces......................................................................16

Exigences d'emplacement.........................................................16

Spécifications électriques ..........................................................19

INSTRUCTIONS D'INSTALLATION.............................................20

Préparation du four encastré .....................................................20

Dépose de la/des porte(s) du four .............................................21

Réinstallation de la/des porte(s) du four ....................................21

Positionnement des pieds du four pour des ouvertures

d'encastrement de hauteur différente........................................22

Raccordement électrique...........................................................26

Installation du four......................................................................28

Installation de l'ensemble déflecteur du tiroir-réchaud .............30

Achever l’installation ..................................................................31

IMPORTANT:

Save for local electrical inspector's use.

IMPORTANT :

À conserver pour consultation par l'inspecteur local des installations électriques.

W10674133B

Summary of content (14 pages)

PAGE 1
INSTALLATION INSTRUCTIONS 27" (68.6 CM) AND 30" (76.2 CM) ELECTRIC SINGLE AND DOUBLE BUILT-IN OVEN INSTRUCTIONS D’INSTALLATION FOUR ÉLECTRIQUE ENCASTRÉ 27" (68,6 CM) ET 30" (76,2 CM) - SIMPLE ET DOUBLE Table of Contents/Table des matières BUILT-IN OVEN SAFETY ...............................................................2 INSTALLATION REQUIREMENTS ................................................2 Tools and Parts ............................................................................
PAGE 2
BUILT-IN OVEN SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.
PAGE 3
■ Oven support surface must be solid, level and flush with bottom of cabinet cutout. ■ Floor must be able to support a single oven weight of 129 lbs (59 kg) for 27" (68.6 cm) models or 154 lbs (70 kg) for 30" (76.2 cm) models. ■ Floor must be able to support a double oven weight of 251 lbs (114 kg) for 27" (68.6 cm) models or 288 lbs (131 kg) for 30" (76.2 cm) models.
PAGE 4
Product Dimensions - Double Ovens Cabinet Dimensions - Double Ovens Double Ovens Installed in Cabinet B A G F B D A C F G E C E 27" (68.6 cm) models A. 51³⁄₁₆" (130.0 cm) max. overall height B. 25⁷⁄₁₆" (64.6 cm) max. recessed width C. 48¹³⁄₁₆" (124.0 cm) recessed height D. 23¹⁄₄" (59.1 cm) max. recessed depth E. 27" (68.6 cm) overall width F. 12" (30.5 cm) from back of control panel to start of strain relief G. 66" (167.6 cm) flexible conduit length D 30" (76.2 cm) models A. 51³⁄₁₆" (130.
PAGE 5
Electrical Requirements If codes permit and a separate ground wire is used, it is recommended that a qualified electrical installer determine that the ground path and the wire gauge are in accordance with local codes. Check with a qualified electrical installer if you are not sure the oven is properly grounded. This oven must be connected to a grounded metal, permanent wiring system.
PAGE 6
INSTALLATION INSTRUCTIONS Prepare Built-In Oven 1. Decide on the final location for the oven. Avoid drilling or cutting into house wiring during installation. 3. Locate the oven door hinge locks in both corners of the oven door, and rotate the hinge locks toward the oven door to the unlocked position. If the door hinge lock is not rotated fully (see illustration B), the door will not remove properly. WARNING B A Excessive Weight Hazard Use two or more people to move and install oven.
PAGE 7
Replace Oven Door(s) IMPORTANT: Do not replace the oven door(s) until after the oven has been installed into the cabinet. 1. Using two hands, grasp side edges of door at the midpoint. Face the oven cavity. 2. Locate the slots on each side of the oven cavity for the door hinge locks. 6. Close the oven door. 7. When the hinges are properly installed and the door closed, there should be an even gap between the door and the control panel.
PAGE 8
Cutout Height is between 26¹⁵⁄₁₆" (68.4 cm) and 27¹¹⁄₁₆" (70.3 cm) Cutout Height is between 28¹¹⁄₁₆" (72.8 cm) and 29⁷⁄₁₆" (74.8 cm) 1. Using 2 or more people, place the oven on its back on a covered surface. 1. Using 2 or more people, place the oven on its back on a covered surface. 2. Remove the foot from the right front spacer by removing the #8-18 x ³⁄₈" screw. NOTE: Do not remove the spacer. 2. Remove the foot from the right front spacer by removing the #8-18 x ³⁄₈" screw.
PAGE 9
6. Using 2 or more people, place the oven in its upright position. Cutout Height is between 50¹⁄₂" (128.2 cm) and 51¹⁄₈" (129.9 cm) 1. Using 2 or more people, place the oven on its back on a covered surface. 2. Install a foot on the left rear spacer using a #8-18 x ³⁄₈" screw. NOTE: Position the foot so the long side of the foot is facing toward the top of the oven. 7. Go to the “Make Electrical Connection” section.
PAGE 10
6. Using 2 or more people, place the oven in its upright position. 4. Install a front foot on the left front using a #8-18 x ³⁄₈" screw. NOTE: Position the foot so the long side of the foot is facing toward the top of the oven. A B C 7. Go to the “Make Electrical Connection” section. Cutout Height is between 51³⁄₁₆" (130.0 cm) and 52³⁄₁₆" (132.6 cm) 1. Using 2 or more people, place the oven on its back on a covered surface. A. Front foot B. #8-18 x ³⁄₈" screw C. Spacer 5.
PAGE 11
Make Electrical Connection For Double Ovens For Single Ovens WARNING WARNING Electrical Shock Hazard Electrical Shock Hazard Disconnect power before servicing. Disconnect power before servicing. Use 8 gauge solid copper wire. Use 12 gauge solid copper wire. Electrically ground oven. Electrically ground oven. Failure to follow these instructions can result in death, fire, or electrical shock. Failure to follow these instructions can result in death, fire, or electrical shock.
PAGE 12
3-Wire Cable from Home Power Supply - U.S. Only 2. Push against the seal area of the front frame to push the oven into the cabinet until the back surface of the front frame touches the front wall of the cabinet. IMPORTANT: Use the 3-wire cable from home power supply where local codes permit a 3-wire connection. A B C G H D E I F A. Cable from home power supply B. Junction box C. Black wires D. White wires E. Green (or bare) ground wire (from oven) F. 4-wire flexible conduit from oven G. Red wires H.
PAGE 13
6. For models KEBK171B, KEBK101B, KEBK276B, KEBK206B, KEBS179B, KEBS109B, KEBS277B, KEBS279B, KEBS207B, or KEBS209B, see the following instructions. For all other models, the black front trims can be ordered as an accessory. Please reference the “Assistance or Service” section of the Use and Care Guide or contact the dealer from whom you purchased your built-in oven to order part numbers: W10327368 and W10327369 for double ovens. W10327380 and W10327381 for single ovens. 8.
PAGE 14
Install Warming Drawer Deflector Kit (only for ovens installed above warming drawers) 4. Using one #8-18 x ³⁄₈" screw (E) on each side of the vent tab (B), fasten the vent securely to the oven. On single and double oven models installed above a warming drawer, a warming drawer deflector kit must be installed. See the “Tools and Parts” section for information on ordering. NOTE: Warming drawer deflector is not needed if feet are installed in the tall position and bottom vent trim has been installed.