PICTURE INDICATES APPROPRIATE DECAL APPLICATION LOCATION MM-E1000 ELECTRIC MINI BIKE OWNER’S MANUAL THIS OWNER’S MANUAL CONTAINS IMPORTANT INFORMATION. READ THOROUGHLY BEFORE RIDING FOR THE FIRST TIME.
ELECTRIC MINI BIKE MM-E1 0 0 0 OWNER’S MANUAL Mo n s t e r Mo t o 620 Monster Moto Trail Ruston, LA 71270 855-833-6483 www.monstermoto.com support@monstermoto.com IF Y OU H AV E PROBLEMS, DO NOT RETURN TO STORE! CONTACT MONSTER MOTO AT 855-833-6483 OR SUPPORT@MONSTERMOTO.COM! F a ilu r e to fo llo w th e in s tr u c tio n s in th is m a n u a l c o u ld r e s u lt in s e r io u s in ju r y o r d e a th .
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT TABLE OF CONTENTS INTRODUCTION 3 LAW S & REG ULATIONS 4 MAINTENANCE REQ UIREMENTS 4 SAF ETY 5 G ETTING STARTED 7 BASIC OPERATION 9 MAINTENANCE PROCEDURES 1 2 BRAKES 12 TIRES 13 DRIVE CHAIN 14 APPEARANCE & CARE 15 W ARRANTY 1 6 SPECIF ICATIONS 1 8 REG ISTRATION 1 9 2
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! INTRODUCTION Congratulations on the purchase of your new Monster Moto electric mini bike! We hope that your new mini bike provides years of fun experiences and epic moments. Monster Moto is dedicated to providing you with an exceptional experience. If you are not happy with your mini bike, don’t return it! Instead, contact Monster Moto customer service at 855-833-6483 or support@monstermoto.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT LAW S & REG ULATIONS It is the responsibility of any rider of this vehicle to be familiar with and fully comply with all laws, rules, and regulations governing the operation of this vehicle. Laws vary by jurisdiction. Monster Moto has no responsibility or liability for the costs to comply with all applicable laws and regulations or for mini bike damage or human injury resulting from an owner or operator’s failure to follow all relevant laws and regulations.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! SAF ETY Th e MM-E1 0 0 0 m i n i b i k e h a s t h e p o t e n t i a l t o c a u s e s e r i o u s i n j u r y o r d e a t h . Although the risks associated with riding a mini bike can never be eliminated completely, following all of the instructions contained in this manual will reduce the risk of harm to the operator and others. Any rider of the mini bike must always review and follow the instructions outlined in this manual.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT W ARNING : Ne v e r r i d e t h e m i n i b i k e o n h a r d s u r f a c e s . The mini bike’s tires are designed for operation in dirt, gravel, or similar materials and are not stable on any hard surfaces including, but not limited to, concrete or asphalt. W ARNING : Ne v e r r i d e t h e m i n i b i k e a t n i g h t . The mini bike is not equipped with lights. W ARNING : Ne v e r r i d e t h e m i n i b i k e a l o n e .
55-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! G ETTING STARTED: ASSEMBLING CH ARG ING TH E E-MINI BIK E & After you remove the mini bike from its packaging, there are several steps you need to take in order to prepare your mini bike for its first use. ATTACH ING TH E F RONT PLATE F RONT PLATE 1. Park your mini bike on a firm, level surface. F RONT PLATE BRACK ETS 2. Locate the front plate, which was included in the mini bike parts bag. (EACH HOLDS ONE SCREW AND ONE WASHER) 3.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT APPLY ING TH E DECALS - MM-E1 0 0 0 ELECTRIC MINI BIK E Your mini bike comes without decals applied and are included in the box.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT CH ARG ING Y OUR MINI BIK E 1. Make sure the on/off switch located on the right throttle handle is in the off position, red button out, all LED lights on indicator are off. 2. Locate the charger and find the battery charging port on the front of the battery/engine cover. 3. Insert the charger plug into the charging port, it is designed to fit in one way. 4. Plug the other end of the charger into a standard 110-volt household outlet. 5.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! STARTING Y OUR MINI BIK E 1. If your mini bike is charging, unplug the e-mini bike’s charger from the charging port. Unplug the charger from the wall outlet and store in a safe place until next use before attempting to ride the bike. 2. Turn on the mini bike by pressing the power button on the right handlebar throttle assembly, the red button is in and the LED lights are on. 3.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT BRAK ES ADJ USTING NUT BRAK E MECH ANISM ADJ USTING TH E BRAK ES If you cannot stop your mini bike properly, you will most likely need to adjust its rear disc brake. You will also need to adjust the brake as part of your regular maintenance routine, as regular use of the mini bike will cause the brake to loosen over time. Follow the steps below to complete a brake adjustment: 1.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! TIRES INSPECTING Y OUR TIRES Regularly perform an in-depth inspection of your tires as part of your maintenance routine. Park the mini bike on a firm, level surface and turn the engine stop switch to the “off” position. Look for bumps or bulges in the sidewall of the tire and inside of the treads. Look closely for cuts, slits or cracks. Check for signs of excessive wear. Check for rocks, screws, nails or other objects embedded in the tires or tread.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT DRIV E CH AIN DRIV E CH AIN F RONT SPROCK ET REAR SPROCK ET ( DRIV E CH AIN AND SPROCK ETS ARE COV ERED BY TH E CH AIN G UARD) ADJ USTING CH AIN G UARD CH AIN TENSIONER AX LE NUT CH AIN TENSIONER TH E DRIV E CH AIN CH AIN TENSIONER ADJ USTMENT NUT The drive chain needs to have a small amount of slack to operate properly. No slack or excessive slack in a drive chain can cause damage to the bike.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! LUBRICATING TH E DRIV E CH AIN The drive chain needs to be properly lubricated in order for the mini bike to operate properly. Normal use of the mini bike will cause the chain to dry and rust over time, therefore it is necessary to lubricate the chain as part of routine maintenance. Follow the steps below to lubricate the drive chain: 1. Park the mini bike on a firm, level surface and turn the engine stop switch to the “off” position. 2.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT W ARRANTY W H AT IS COV ERED Monster Moto warrants only to the original retail purchaser of this product that this product is free from defects in material and/or workmanship for a period of ninety (90) days from the date of purchase. At Monster Moto’s sole discretion, Monster Moto agrees to either repair, provide replacement parts for, or replace without charge, any product or component having a material defect, except as limited below.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! OW NER’ S RESPONSIBILITIES As the mini bike owner, you are responsible for ensuring all required maintenance is performed on your product. You are also responsible for maintaining a record of and all receipts for maintenance performed on your product. Your warranty claim may be denied solely due to your failure to ensure the completion of all scheduled maintenance or keep the maintenance records or receipts.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT SPECIF ICATIONS POW ER: Powerful 1000 W motor with rechargeable and replaceable 14 Ah 36 V battery pack (3 12V batteries) RUN TIME: Continuous 45 min MAX IMUM SPEED: 17 mph STARTER TY PE: Easy on and off switch BRAK E TY PE: Hand operated cable actuated rear disc TIRES & W H EELS: 145/70-6 off-road tubeless pneumatic tires with steel rims W H EELBASE: 35.5” SEAT H EIG H T: 23” ASSEMBLED DIMENSIONS: 110 lb / 50.0” L x 26.0” W x 33.
855-833-6483 OR EMAIL US AT SUPPORT@MONSTERMOTO.COM! ELECTRIC MINI BIKE MM-E1 0 0 0 PRODUCT REGISTRATION Mo n s t e r Mo t o 620 Monster Moto Trail Ruston, LA 71270 855-833-6483 support@monstermoto.com www.monstermoto.com Please help us serve you better by registering your new mini bike. You may register your product by calling us at 855-833-6483, by emailing us at info@monstermoto.com, or by mailing the registration form below to us at 620 Monster Moto Trail, Ruston, LA 71270.
IF YOU HAVE PROBLEMS, DO NOT RETURN TO STORE! CONTACT MONSTER MOTO AT 855-833-6483 OR SUPPORT@MONSTERMOTO.COM! Monster Moto will handle all service, warranty, and return arrangements. Monster Moto 620 Monster Moto Trail Ruston, LA 71270 855-833-6483 support@monstermoto.com www.monstermoto.