Service manual

2 Index
2006 LSSV Service Manual Supplement
CTSY Lamps
Diagnosis
CTSY Lamps Operate in Blackout (B/O)
Mode ..........................................................8-105
D
Data Plate
Government Vehicle Data Plate
Replacement....................................................8-69
Shipping Data Plate Replacement ......................8-69
Diagnostic Starting Point – Engine Electrical..........6-16
Disc Brakes
Repair
Rear Brake Caliper Bolt Replacement...............5-5
Rear Brake Caliper Cover Replacement ...........5-5
Specifications
Fastener Tightening Specifications ...................5-3
D-Ring
Repair
Front D-Ring Bracket Replacement.................8-37
Front D-Ring Replacement (LSSV) .................8-35
Rear D-Ring Bracket Replacement
(LSSV)..........................................................8-37
Rear D-Ring Replacement (LSSV)..................8-36
DRL Operate in Blackout (B/O) Mode ..................8-102
DTC E1 ...................................................................3-41
DTC E2 ...................................................................3-41
DTC E3 ...................................................................3-41
DTC E4 ...................................................................3-42
E
ECM
Repair
Engine Control Module (ECM) Description......6-46
Engine Control Module (ECM)
Replacement................................................6-45
Electrical Center Identification Views....................8-147
Engine Controls
Description
Engine Control Module (ECM) Description......6-46
Repair
Engine Control Module (ECM)
Replacement................................................6-45
Engine Controls – 6.6L (LLY)
Specifications
Enhanced Mobility Package EngineControl
Module (ECM) Calibrations..........................6-43
Engine Electrical
Components
Engine Electrical Component Views..................6-9
Engine Electrical Connector End Views ..........6-14
Description
Battery Description (12V and 24V)..................6-40
Charging System Description and
Operation .....................................................6-40
Vehicle Load Disconnect Switch
Opeartion .....................................................6-41
Diagnostics
24V Generator Inoperative.............................. 6-20
24V Generator Noise Diagnosis...................... 6-18
Battery Charging (Optima) .............................. 6-16
Battery Inspection/Test (Optima) .................... 6-16
Diagnostic Starting Point – Engine
Electrical ...................................................... 6-16
Jump Starting in Case of Emergency ............. 6-17
Symptom List................................................... 6-16
Repair
12V Battery Negative Cable Replacement –
Frame Mounted Battery............................... 6-30
12V Battery Positive Cable Replacement –
Battery to Battery......................................... 6-29
24 Volt Battery Hold Down Replacement........ 6-38
24V Generator Replacement .......................... 6-25
Battery and Battery Tray Replacement........... 6-23
Battery Cable Disconnect/Connect
Procedure .................................................... 6-26
Front Winch Harness and Connector
Replacement................................................ 6-31
Rear Winch Harness and Connector
Replacement (LSSV)................................... 6-32
Relay Replacement – 24V Generator............. 6-23
Slave Receptacle Harness Replacement
(LSSV) ......................................................... 6-33
Slave Receptacle Replacement (LSSV) ......... 6-35
Vehicle Load Disconnect Switch – MEGA
Fuse 175 Amp/MIDI Fuse 50 Amp
Replacement................................................ 6-36
Vehicle Load Disconnect Switch
Replacement (LSSV)................................... 6-27
Schematics ........................................................... 6-4
Special Tools and Equipment............................. 6-42
Specifications
Battery Charging Specifications (Optima)......... 6-3
Battery Usage (Optima) .................................... 6-3
Fastener Tightening Specifications................... 6-3
Generator Usage............................................... 6-3
MEGA Fuse/MIDI Fuse Specifications.............. 6-4
Enhanced Mobility Package Jack Mounting
Enhanced Mobility Package Jack Mounting
Bracket Replacement (Crew Cab) .................. 8-76
Enhanced Mobility Package Jack Mounting
Bracket Replacement (Extended Cab) ........... 8-75
Enhanced Mobility Package Jack Mounting
Bracket Replacement (In Vehicle Tire
Carrier) ............................................................ 8-74
Enhanced Mobility Package Jack Mounting
Bracket Replacement (Regular Cab) .............. 8-75
Enhanced Mobility Package Jack Tools
Mounting Bracket Replacement...................... 8-77
Exterior and Interior Colors .................................. 8-121
Exterior Painting
Repair
Exterior Painting (LSSV) ............................... 8-123
Exterior Trim
Description
Exterior Trim Description................................. 8-32
Repair
Guard Mud – Rear (One or Both)
Replacement................................................ 8-31
Spiecifications