Installation Guide

1.25" Corrugated

2.5" Corrugated

PANELS

TARP

Pleaseinspectpanelsformoistureaccumulation.Ifmoisturehasformed,thepanelsshouldbeunbundled,wipeddryand

allowedtodrycompletely.Oncedry,carefullyre-stackthepanelsandlooselyrecoverallowingforampleaircirculation.

Bundledsheetsshouldbestoredhighenoughoffofthegroundtoallowforaircirculationandpreventcontactwith

accumulatingwater.Elevateoneendofthebundletoallowanymoisturetorunoffthepanels.MetalSalesrecommends

coveringthebundlewithatarp.Donotusetightttingplastic-typetarpsaspanelbundlecovers.Whiletheymayprovide

protectionfromheavydownpours,theycanalsoretardnecessaryventilationandtrapheatandmoisturethatmayaccelerate

metalcorrosion.Ifpanelsaretobestoredinpossiblebadweather,wesuggesttheybestoredinside.Extendedstorageof

panels in a bundle is not recommended. Under no circumstances should the panels be stored near or come in contact

with salt water, corrosive chemicals, ash, or fumes generated or released inside the building or nearby plants,

foundries, plating works, kilns, fertilizer and wet or green lumber.

STORAGE

GENERAL

ELEVATE END OF BUNDLE

Careofmetalpanelsandashingsmustbeexercisedthroughouterection.Foottrafccancausedistortionofpaneland

damagetonish.Trafcovertheinstalledsystemmustbekepttoanabsoluteminimum.Installersshouldwearrubber

soleshoestokeepfromscufngmaterialwhilewalkingontheroof.

Whenwalkingontheroofpanelsisunavoidable,walkonlyintheatsofthepanel.Walkingontheribscancause

damagetothepanels.

FOOT TRAFFIC

PANEL COVER SHEET

TARP

• Screw Guns

 •MagneticBits

 •MetalNibblerorShear

 •TinSnips(Right,LeftandCenter)

 •TapeMeasure

 •Hammer

 •ChalkLine

 •Drillwithbits

 •PopRivetTool

 •SafetyGoggles

• Gloves

 •HardHat

 •StraightEdge

 •LargeTriangle

 •FallProtection

REQUIRED TOOLS

Standardrequiredtoolsforeldinstallationinclude: