Service manual

14. MGI Service Schedule [SL150c]:

It is the owner’s responsibility to ensure that all periodical checks, necessary adjustments and

services are carried out. If in doubt please contact the MGI service centre on 1300 644 523. Any

work performed on your buggy should be recorded on your service record (see page 9)

regardless of the work.

SL150c Monthly

Six

Monthly

Yearly

Three

Yearly

Wipe down the buggy with warm cloth after each use –

see page 4 point 9

Lubricate rear wheel stub axles – see page 5 point 10 BO

Clean and then lubricate clutches - see page 5 point 11 BO

Check rear wheel clutches function correctly – see

page 5 point 11

Check and tighten all nuts and bolts BO/SC

Check grub screws on bearing collars on axle bearings -

tighten as required

BO/SC

Check and tighten handle pivots BO/SC

Check alignment of buggy - ensure that it runs straight –

see page 5 point 13

BO/SC

Check alignment and operation of gearbox and axle(s) SC

Replace handle grips BO/SC

Replace rear axle support bearing housings SC

Replace rear wheel clutches BO/SC

Replace rear wheel spring latches and drive hubs BO/SC

Replace seat bracket & sand bucket loop plastic inserts BO/SC

Replace fused battery leads BO/SC

Replace speed controller and On / Off switch assembly BO/SC

Replace rear wheel axle SC

Replace rear and front wheels – see page 10 point 5 BO

Replace Upper & Lower Bag Straps – see page 5 point 12 BO

BO = Buggy owner can carry out this work

SC = Charged work to be carried by approved service centre

BO/SC = The six monthly service can be completed by either an authorised service centre or the

owner of the buggy. The tools to tighten all nuts and bolts are provided with your maintenance /

service and instruction manual. As part of MGI’s Preventative Maintenance Program, if the six

monthly services are carried out by an authorised service centre, you will be charged for that

service. Each yearly service should also include the six monthly service.

It is important for your warranty and the life of your buggy that the service record be observed and

maintained. Monthly cleaning and lubrication need not be recorded on the service record.