Owner`s manual

ManualsBrandsMHSC ManualsHome building and DecorWR1000L02

DUTCHWEST

5128

WR1000

COVER











Read this entire manual before you install and

use your appliance.

If not properly installed, a house fire may result.

To reduce the risk of fire, follow the installation

instructions.

Failure to follow instructions may result in prop-

erty damage, bodily injury or even death.

Contact local building, fire officials or authori-

ties having jurisdiction about permits, restric-

tions and installation inspection requirements in

your area.

This stove is listed by OMNI-Test Laboratories of Port-

land, Oregon to meet UL1482 for the US and ULC-627

for Canada





30005128 1/11 Rev. 3













This manual describes the installation and operation of the WR1000L02, WR1500L02

and WR2000L02 non-catalytic, wood heaters. This heater meets US Environmental

Protection Agency emission limits for wood heaters.

Summary of content (13 pages)

PAGE 1
Windsor EPA Certified High Efficiency Wood Stove ST Owner’s Manual For Residential Installation Models: WR1000L02 WR1500L02 WR2000L02 5128 WR1000 COVER This manual describes the installation and operation of the WR1000L02, WR1500L02 and WR2000L02 non-catalytic, wood heaters. This heater meets US Environmental Protection Agency emission limits for wood heaters. Safety Notice Read this entire manual before you install and use your appliance. If not properly installed, a house fire may result.
PAGE 2
Windsor High Efficiency Wood Stove CAUTION After reading these instructions, if you have any doubt about your ability to complete your installation in a professional like manner you should obtain the services of an installer versed in all aspects as to the correct and safe installation. Do not use temporary makeshift compromises during installation. Before Installation of Your Appliance 1. Check with the building inspector’s office for compliance with local codes; a permit may be required. 2.
PAGE 3
Windsor High Efficiency Wood Stove G A Figure 1 Stove Dimensions B 1056O” (267 mm) F C E D Model WR1000L02 WR1500L02 WR2000L02 A 29” 737 mm 30” 762 mm 31” 787 mm B 26C\v” 679 mm 27C\v” 705 mm 28C\v” 730 mm C D E F 17Z\x” 20Z\x” 24C\,” 10C\v” 445 mm 619 mm 273 mm 5128 521 mm WR1000 1500 17C\v” 22Z\v”dims 28C\v” 10C\v” 450 mm 565 mm 730 mm 273 mm 21M\,” 27” 26Z\x” 10C\v” 556 mm 686 mm 673 mm 273 mm G 23C\v” 603 mm 28Z\v” 718 mm 26Z\x” 667 mm Proposition 65 Warning: Fuels used in
PAGE 4
Windsor High Efficiency Wood Stove Installation Contact your local building inspector prior to installation. A permit may be required in your area. This Homeowner’s Manual describes the installation and operation of the models: WR1000L02, WR1500L02, WR2000L02 non-catalytic wood heater. This heater meets US Environmental Protection Agency’s emission limts for wood heaters.
PAGE 5
Windsor High Efficiency Wood Stove 2 Full Bricks (Be sure to install two (2) full bricks in baffle as shown) 2 2 1 3 1 3 3 1 3 1 1 1 6 1 1 Baffle Assembly 1 4 WR1000 Series Figure 3 Fire Brick Installation WR1000 and WR1500 Series 2 2 1 3 3 3 3 1 1 1 8 1 1 ST1034 1 1 1 1 1 5 1 1 4 WR1500 Series Item 1. 2. 3. 4. 5. 6. 7. 8. 6 Installation on a Concrete Floor An appliance mounted on a concrete floor does not require floor protection.
PAGE 6
Windsor High Efficiency Wood Stove 2“ (51 mm) Stove Pipe 2“ (51 mm) Wall Line Chimney Connector 8” (203 mm) Floor Protector 8” (203 mm) 8” (203 mm) *16” (406 mm) **18” (457 mm) Door Side of Appliance ST1036 Figure 4 Floor Protector Attach Handle Holder ST1036 floor protection Insert screw through10/08 handle holder and into lower left side of stove (when facing the front). (Fig. ) Chimney Figure 5 Handle Holder CONTACT YOUR LOCAL BUILDING AUTHORITY FOR APPROVED METHODS OF INSTALLATION.
PAGE 7
Windsor High Efficiency Wood Stove DO NOT BURN: 2’ (610 mm) Higher than Nearest Point of Roof within 10’ (3 m) 3’ (1 m) Min. from Roof Penetration 15’ (5 m) Minimum verall Height from Floor Figure 6 Chimney height ST1037 CAUTION: DO NOT open fire-door to a point where it would be in contact with the combustible sidewall. Optional Fan - An optional heat exchange blower is available for this wood burning appliance. To order please see the local dealer where you purchased your 34 appliance.
PAGE 8
Windsor High Efficiency Wood Stove 4. Ignite the paper and close door. If fire dies down substantially, open door slightly. 5. Add larger pieces of wood as the fire progresses being careful not to overload. Do not fill firebox beyond firebrick area. An ideal coal bed of 1” to 2” should be established to achieve optimum performance. 6. This unit is designed to function most effectively when air is allowed to circulate to all areas of the firebox.
PAGE 9
Windsor High Efficiency Wood Stove Creosote When wood is burned slowly, it produces tar and other organic vapors. These combine with moisture to form creosote. Creosote vapors condense in the relatively cool chimney flue of a slow-burning fire. As a result, creosote residue accumulates on the flue lining. When ignited, this creosote makes an extremely hot fire. The chimney should be inspected regularly during the heating season to determine if a creosote build-up has accumulated.
PAGE 10
Windsor High Efficiency Wood Stove 2. What type of wood is best to use as firewood? Dry seasoned hardwood should be used. Avoid green unseasoned wood. Green wood, besides burning at only 60 percent of the fuel value of dry seasoned wood, will deposit creosote on the inside of your stove and along the inside of your chimney. 3.
PAGE 11
Windsor High Efficiency Wood Stove 13 8 6 1 7 9 14 5 10 3 4 2 20 11 19 15 12 18 17 16 MHSC reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. WR1000 Series, WR1500 Series, WR2000 Series Wood Stoves 19 Item 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 30005128 Description Qty.
PAGE 12
Windsor High Efficiency Wood Stove WR1000 Series, WR1500 Series, WR2000 Series Wood Stoves (continued) Item 15. 16. 17. 18. 19. 20. Description 1/4” Spring Handle Ash Drawer Leg Casting Ashfender Airmate Removable Rear Heat Shield Qty. 1 1 2 1 1 1 WR1000 90000070 S31333 S25076 S25077 S25088 90000037 WR1500 90000070 S31333 S25080 S25082 S25092 90000038 WR2000 90000070 S31336 S25084 S25082 S25093 S29265 NOTE: Refer to Page 6 for fire brick replacement.
PAGE 13
Windsor High Efficiency Wood Stove Limited Lifetime Warranty Limited Three Year Warranty MHSC (hereafter referred to as the “company”) warrants that your new Windsor brand wood burning plate steel stove or masonry wood insert is free from manufacturing and material defects for a period of three years from the date of sale, subject to the following conditions and limitations. Limited One Year Warranty Electrical components such as blowers and speed controls are covered for one year only.