HAND CARRY GASOLINE AIR COMPRESSOR OPERATOR'S MANUAL caution RISK OF INJURY! READ ENTIRE MANUAL BEFORE OPERATING! THIS MANUAL IS AN IMPORTANT PART OF THE AIR COMPRESSOR AND MUST REMAIN WITH THIS UNIT WHEN YOU SELL OR RENT IT! ©Copyright 2005, Mi-T-M Corporation® ® Mi-T-M Hand Carry Gasoline Air Compressor Manual Form #37-0706-E/S-082905
table of contents introduction................................................................................................................. 3 important ................................................................................................................... 3 INSPECTION....................................................................................................................... 3 safety warningS........................................................................................
INTRODUCTION Congratulations on the purchase of your new Mi-T-M® Air Compressor! You can be assured your Mi-T-M Air Compressor was constructed with the highest level of precision and accuracy. Each component has been rigorously tested by technicians to ensure the quality, endurance and performance of this air compressor. This operator's manual was compiled for your benefit.
SAFETY WARNINGS WARNING: WHEN USING THIS PRODUCT, BASIC PRECAUTIONS SHOULD ALWAYS BE OBSERVED, INCLUDING THE FOLLOWING. READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF EXPLOSION OR FIRE POTENTIAL CONSEQUENCE Serious injury or death may occur from normal sparks in the engine ignition system or engine exhaust/ muffler. PREVENTION Always operate air compressor in a well ventilated area free of flammable vapors, combustible dust, gases or other combustible materials.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF BURSTING POTENTIAL CONSEQUENCE PREVENTION Serious injury or death may occur from an air tank explosion if air tanks are not properly maintained. Drain air tank daily or after each use to prevent moisture buildup in the air tank. If air tank develops a leak, replace the air tank immediately. Never repair, weld or make modifications to the air tank or its attachments.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR PREVENTION POTENTIAL CONSEQUENCE HAZARD Serious injury could occur Never allow any part of your body RISK from touching exposed metal or other materials to make contact OF BURNS parts. These areas can remain with any exposed metal parts on hot for some time after the air the air compressor. compressor is shutdown. Never allow any part of your body to contact the engine muffler or adjacent areas.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR PREVENTION POTENTIAL CONSEQUENCE HAZARD Risk of injury from negligent use. Never allow children or RISK FROM adolescents to operate this air NEGLIGENCE compressor! Stay alert-watch what you are doing. Do not operate the air compressor when fatigued or under the influence of alcohol or drugs. Know how to stop the air compressor. Be thoroughly familiar with controls. RISK OF AIR COMPRESSOR DAMAGE Risk of major repair.
AC1-HH04-05M-031102-DLG Mi-T-M GASOLINE HAND CARRY AIR COMPRESSOR FEATURES 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21.
EXPLODED VIEW & EXPLANATION OF AIR COMPRESSOR FEATURES SAFETY RELIEF VALVE: This valve is designed to prevent system failures by relieving pressure from the system when the compressed air reaches a predetermined level. The valve is preset by the manufacturer and must not be modified in any way. To verify the valve is working properly, pull on the ring. Air pressure should escape. When the ring is released, it will reseat.
preparation WARNING RISK OF EXPLOSION OR FIRE CAUSING SERIOUS INJURY OR DEATH! Do not allow the engine or muffler to come in contact with flammable vapors, combustible dust, gases or other combustible materials. A spark may cause a fire. When using the air compressor for spray painting, place the air compressor as far away from the work area as possible, using extra air hoses if needed.
START-UP: operation 1. Read safety warnings before performing operation. 2. Flip the toggle on top of the Pilot Valve to the upright position. This provides a loadless start. The air compressor will unload and allow easier engine start-up. 3. Start the engine. (Refer to the Engine Manual accompanying this unit.
TROUBLESHOOTING SYMPTOM PROBABLE CAUSE REMEDY Various engine problems. Refer to the engine manual Engine will not start. accompanying your air compressor. Engine lacks power. Noisy operation. Pressure drop in air tank or rapid pressure loss when air compressor is shut off. Insufficient pressure at air tool or accessory. 12 Filter element plugged. Clean or replace filter element. Bad Fuel. Drain fuel; refuel with fresh gasoline. Various engine problems.
TROUBLESHOOTING SYMPTOM Air leaks from Pressure Relief Valve PROBABLE CAUSE REMEDY Possible defective Pressure Relief Valve. Operate Pressure Relief Valve manually by pulling on ring. If it still leaks, it should be replaced. Excessive air tank pressure. Clean, reset or replace Pilot Valve. Air leaks at pump. Defective gaskets. Torque head bolts: Single Stage = 15 ft./lbs. Air blowing from Air Intake Filter. Defective inlet (reed) valve. Contact Mi-T-M Customer Service.
Mi-T-M PORTABLE GASOLINE AIR COMPRESSOR STATEMENT OF WARRANTY Mi-T-M Corporation warrants all parts, (except those referred to below), of your new air compressor to be free from defects in materials and workmanship during the following periods: For One (1) years from the date of original purchase: Compressor Pump Plumbing Tank Assembly For Six (6) months from date of original purchase: Pressure Switch Regulator Check Valve Copper Line For Ninety (90) days from the date of original pur
NOTES Manual de Compresor gasolina portable de aire Mi-T-M® 15
TABLA DE MATERIAS INTRODUCCION............................................................................................................... 17 importantE ............................................................................................................... 17 INSPeccione.................................................................................................................. 17 ADVERTENCIAS IMPORTANTES DE SEGURIDAD..................................................
INTRODUCCION ¡Felicitaciones por la compra de su nueva compresor de aire gasolina! Puede estar seguro que su compresor de aire gasolina fue construida con el nivel más. Cada componente ha sido probado rigurosamente por técnicos para asegurar la calidad, la resistencia y el rendimiento de esta unidad. Este manual del operador fue compilado para su beneficio.
ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes: LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE.
ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes: LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE. PELIGRO POSIBLE CONSECUENCIA PREVENCIÓN Vaciar el depósito de aire todos Si no se respeta el mantenimiento Riesgo de estallido adecuado el depósito de aire podría los días o al final de cada uso, para evitar que se acumule la estallar y causar lesiones graves o condensación. la muerte.
ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes: LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE. POSIBLE CONSECUENCIA PREVENCIÓN PELIGRO Asegurarase que ninguna parte El tocar partes metálicas Riesgo de quemaduras del cuerpo o de otros materiales expuestas podría causar lesiones entre en contacto con las graves.
ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA: Al usar este producto, deben observarse ciertas precauciones básicas, como las siguientes: LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE. PELIGRO POSIBLE CONSECUENCIA PREVENCIÓN Un uso negligente del compresor No permitir jamás que niños o Riesgo de negligencia puede ocasionar lesiones. adolescentes pongan en marcha el compresor de aire. Prestar mucha atención a la operación que se está cumpliendo.
AC1-HH04-05M-031102-DLG ELEMENTOS DE COMPRESOR DE AIRE GASOLINA 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21.
VISTA EXPLOTADA Y EXPLICACIÓN DE ELEMENTOS DE COMPRESOR DE AIRE VÁLVULA DE ALIVIO DE SEGURIDAD: Esta válvula sea disenado para prevenir falla de la sistema por aliviando alcance un nivel predeterminado. La válvula ha preprogrmado por el fabricante y no puede modificar en ninguna manera. Para verificar que la válvula está trabajando correctamente, tire en el anillo. Presión de aire debe escapar. Cuando el anillo sea liberado, lo volover a cero.
NOTA 24 Manual de Compresor gasolina portable de aire Mi-T-M®
ADVERTENCIA LAS PAGINAS SIGUIENTES CONTIENEN INSTRUCCIONES DE OPERACION Y MANTENIMIENTO NO TRATE DE OPERAR ESTA LAVADORA A PRESION HASTA QUE HAYA LEIDO Y ENTENDIDO TODAS LAS PRECAUCIONES INSTRUCCIONES DE SEGURIDAD LISTADAS EN ESTE MANUAL.
INSTRUCCIONES DE PREPARACIÓN ADVERTENCIA RIESGO DE EXPLOSIÓN O FUEGO QUE PUEDE CAUSAR LESIONES GRAVES Y LA MUERTE! No tener contacto de motor y moefle con vapores flamables, polvos combustiles, o otras materiales combustibles. Una chispa puede causar un fuego. Cuando usando el compresor de aire para pintar, poner el compresor de aire demasiado afuera, de ambiente de trabajar. Usar más tubos de aire si necesitar.
Operación START-UP: 1. Leer atentamente las advertencias de seguridad antes de efectuar esta operación. 2. Colocar muletilla que estar en la arriba de válvula pilota a posición vertical. Este dar una empezada sin descargar. Este compresor de aire puede descargar y tener una empezada de motor más facil. 3. Encender el motor. (Referir a manual de este unito de motor.
LOCALIZACIÓN DE AVERÍAS SÍNTOMA El motor no encender. CAUSA (S) POSIBLE (S) SOLUCIÓN Varías problemos de motor. Referir a manual de motor de su compresor de aire. Motor le falta potenica Elemento de filtro está tapado. Limpie o reemplacar elemento de filtro. Comestible malo. Elimina comestible; rellene con gasolina fresca. Varías problemas de motor. Falta aceite en la bomba. Referir a manual a motor que acompanar su compresor de aire. Reponer la cantidad de aceite necesaria.
LOCALIZACIÓN DE AVERÍAS SÍNTOMA CAUSA (S) POSIBLE (S) SOLUCIÓN Activar la válvula de presión manuEl aire sale de la válvula de La válvula de seguridad probablealmente tirando del anillo. seguridad. mente es defectuosa. La presión de aire en el depósito es excesiva. Si el aire sigue saliendo, debe ser sustituida. Interruptor motor/presión defectuoso. Sustituir. Fugas de aire en la bomba. Juntas defectuosas. Sustituir y apretar los pernos de la culata.
NOTA 30 Manual de Compresor gasolina portable de aire Mi-T-M®
DECLARACIÓN DE GARANTÍA Mi-T-M® garantiza que todas las piezas (excepto aquellas a las que se hace referencia abajo), de su nueva lavadora a presión libres de defectos en materiales y mano de obra durante los periodos siguientes: Por uno (1) año a partir de la fecha original de compra: Bomba de Compresor Asamblea de Tanque Canerías Por seis (6) mes a partir de la fecha original de compra: Interruptor de Presión Regulador Válvula de Revisar Cobre Inoxidable Por noventa (90) días a partir de la fe
Manual de Compresor gasolina portable de aire Mi-T-M®