Micro Device User’s guide.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it This document contains proprietary intellectual information exclusively owned by Micro Device S.r.l. All information contained herein is the exclusive property of microdevice YACHT CONTOLLER IS A WIRELESS DEVICE USED TO CONTROL THE MANEUVERING OF A BOAT WHEN DOCKING, ANCHORING OR MOORING.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it Summary SUMMARY .........................................................................................................................................................3 1. INTRODUCTION ............................................................................................................................................4 1.1. GENERAL TRANSMITTER FEATURES .........
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 1. Introduction Yacht Controller, developed by Micro Device S.r.l., is an electronic remote control wireless, able to control a boat the basic manuvering and mororing fuctions. The first prototype, was developed in 1998, and since then “Yacht Controller” has undergone a continuous evolution.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it Electronics is housed in a grey ABS container which combines functionality with an IP65 protection degree which is water resistant but not waterproof. The contol is composed of two parts which snap together. A lower cover is removable to change the batteries.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 1.2. General receiver features The receiver is housed in a grey polycarbonate container with a transparent cover, placed inside and out of view of the chosen command station. The receiver is turned on by a separte switch installed normally nearby the contol station.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 2. Yacht Controller operation The commands on the receiver are activated by the respective switches placed on the transmitter. The transmitter cyclically transfers the state of the switches to the receiver. The command will remain active as long as the corresponding switch is pressed.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it WARNING: • The communication between the transmitter and the receiver can be disturbed by mobile telephones or radio-frequency transmission devices in operation nearby.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 2.2. Activation procedure In order to activate Yacht Controller, follow the step by step the procedure described in this paragraph. • • Start the main engines in accordance with the usual procedure. Enable the boat command electronics control station to which the Yacht Controller receiver is connected .
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it To deactivate Yacht Controller, follow the procedure described in this paragraph: • Turn the transmitter OFF by pressing the proper button for more than three seconds (security time to prevent accidental turnoff).
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 3. How to use Yacht Controller Yacht Controller is a radio control system that allows you to operate certain functions the boat in in a simple and safe way for easier docking, anchoring and mooring..
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 3.2. Anchoring and hooking to mooring buoys 3.2.1 Dropping the anchor Once you have selected the optimal position for the anchorage, put the control levers in neutral position, and properly activate the Yacht Controller as previously described.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it • In presence of low water, submerged rocks or other obstacles, you will be able to control the boat from bow, sides or stern, thereby helping you to avoid unpleasant stranding damage to propellers, shafts and other underwater gear.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 4. Maintenance 4.1. Replacement of batteries When the battery discharge LED flashes, it is necessary to replace within a short time both batteries of the transmitter. It’s a good rule to keep always on board two first quality alkaline batteries of 1,5V type AAA (LR06) (Duracell or similar). DANGER: Before working on the transmitter, make sure that the receiver is OFF.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it WARNING: • This device contains batteries. Attention: batteries must be discarded in accordance with local and federal regulations. • Always change the batteries in the radio control transmitter before they lose their power and discard the old ones according to the regulations in force.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 4.3. Problems and malfunctions This paragraph describes a series of problems and malfunctions which could happen in using the Yacht Controller system; the possible cause, and possible solutions to the problem For further assistance please contact your installer or Micro Device S.r.l.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it Problem The acoustic signal of the receiver emits intermittent signals. Possible causes The wireless transmission is interfered by radio-frequency sources near the , (mobile telephones or other radiofrequency equipment) The distance between the receiver and the transmitter has exceeded the signal.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 5. Technical specifications Power: 2 alkaline 1,5 batteries AAA (LR03) type Cover: IABS with protection degree IP65. Number of channels: 4, 6, or 8 according to the models.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 6. Warranty Each Yacht Controller system is warranted for 24 months, as from the date of sale to the first user by the maufacturer against defects of material and workmanship. The warranty on the equipment is effective for all the possible faults of manufacture, material and for breakdowns not caused by the customer.
Micro Device s.r.l Via Bellini, 31/33 20095 Cusano Milanino (MI) Italy Tel. +39 02 6131001 r.a. Fax. +39 02 66400086 E-mail mdevice@tin.it 7. FCC - CE Mark 0682 YACHT CONTROLLER IS A SYSTEM IN COMPLIANCE WITH CE DIRECTIVES FOR TRANSMITTERS IN NAUTICAL ENVIRONMENTS AND THE DIRICTIVES FOR ELECTOMAGNETIC COMPATIBILITYAND IMMUNITY TO ELECTOMAGNETIC DISCHARGES Conformity Declaration The manufacturer: Micro Device S.r.l.