Installation Guide

ManualsBrandsMiller ManualsHeating, Ventilation, and Air Conditioning45,000 BTU 95% AFUE Natural/Liquid Propane Gas Mobile Home Forced Hot Air Up-flow Furnace

CMF95 Series 95.1 AFUE

Downﬂow, Single Stage Condensing Gas Furnace

USER’S MANUAL

DO NOT DESTROY THIS MANUAL. KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.

FIRE OR EXPLOSION HAZARD

•Failure to follow safety warnings exactly

could result in serious injury or property

damage.

•Installationandservicemustbeperformed

byaqualiedinstaller,serviceagencyorthe

gassupplier.

•Do not store or use gasoline or other

ammablevaporsandliquidsinthevicinity

ofthisoranyotherappliance.

WHAT TO DO IF YOU SMELL GAS

•Donottrytolightanyappliance.

•Donottouchanyelectricalswitch;donot

useanyphoneinyourbuilding.

•Leavethebuildingimmediately.

•Immediatelycall yourgassupplierfroma

neighbor’sphone.Followthegassupplier’s

instructions.

•Ifyoucannotreachyourgassupplier,call

theredepartment.

WARNING:

RISQUE D’INCENDIE OU D’ EXPLOSION

•Le non-respect des avertissements de

sécurité pourrait entraîner des blessures

graves,lamortoudesdommagesmatériels.

•L’installation et l’entretien doivent être

effectués par un installateur qualié, un

organismedeserviceoulefournisseur de

gazstaller,serviceagencyorthegassupplier.

•Nepasentreposerniutiliserdel’essenceni

d’autres vapeurs ou liquides inammables

danslevoisinagedecetappareil,nidetout

autreappareil.

QUE FAIRE S’IL Y A UNE ODEUR DE GAZ

•Nepastenterd’allumeraucunappareil.

•Netoucheràaucuninterrupteurélectrique;

n’utiliseraucuntéléphonedanslebâtiment.

•Évacuerl’immeubleimmédiatement.

•Appeler immédiatement le fournisseur de

gazenemployantletéléphoned’unvoisin.

Respecter à la lettre les instructions du

fournisseurdegaz.

•Sipersonnenerépond,appelerleservicedes

incendies.

AVERTISSEMENT

IMPORTANT! Please read all information in this manual thoroughly

and become familiar with the capabilities and use of your appliance

before attempting to operate or maintain this unit. Pay attention

to all safety warnings and any other special notes highlighted in

the manual. Safety markings are used frequently throughout this

manual to designate a degree or level of seriousness and should

not be ignored.

WARNING indicates a potentially hazardous situation that if not

avoided, could result in personal injury or death.

CAUTION indicates a potentially hazardous situation that if not

avoided, may result in minor or moderate injury or property damage.

Keep this literature where you have easy access to it in the future. If a

problem occurs, check the instructions and follow recommendations

given. If these suggestions don’t eliminate your problem, call your

servicing contractor. Do not attempt to service this unit yourself!

Under no circumstances should the appliance owner attempt to

install and/or service this equipment. Some local codes require

licensed installation / service personnel for this type of equipment.

Improper service, adjustment, or maintenance may cause explosion,

ﬁre, electrical shock or other hazardous conditions which may result

in personal injury or property damage.

Summary of content (8 pages)

PAGE 1
CMF95 Series 95.1 AFUE USER’S MANUAL Downflow, Single Stage Condensing Gas Furnace IMPORTANT! Please read all information in this manual thoroughly and become familiar with the capabilities and use of your appliance before attempting to operate or maintain this unit. Pay attention to all safety warnings and any other special notes highlighted in the manual. Safety markings are used frequently throughout this manual to designate a degree or level of seriousness and should not be ignored.
PAGE 2
For Furnaces Installed in: • Manufactured Homes • Recreational Vehicles, Park Models, & Manufactured Buildings • Modular Homes/Buildings TABLE OF CONTENTS Important SAFETY INFORMATION......... 3 Gas Supply & Piping................................... 3 Combustion Air & Venting System............... 4 Clearances to Combustibles....................... 4 Shutting Down the Furnace......................... 4 GENERAL INFORMATION............................ 5 About the Furnace......................................
PAGE 3
IMPORTANT SAFETY INFORMATION WARNING: To avoid possible equipment damage, fire, or personal injury, the following instructions must be observed regarding unit maintenance and operational procedures. WARNING: PROPOSITION 65 WARNING: This product contains chemicals known to the state of California to cause cancer, birth defects or other reproductive harm. • To achieve optimum performance and minimize equipment failure, it is recommended that periodic maintenance be performed on this unit.
PAGE 4
IMPORTANT SAFETY INFORMATION IMPORTANT NOTE: Should the gas supply fail to shut off or if overheating occurs, shut off the gas valve to the furnace before shutting off the electrical supply! COMBUSTION Air & VENTING SYSTEM For proper and safe operation, this furnace requires unrestricted airflow for combustion and ventilation. Do not block or obstruct air openings on the furnace, air openings around the furnace area or the spacings around the furnace.
PAGE 5
GENERAL INFORMATION About the Furnace • This furnace has been tested for capacity and efficiency in accordance with A.H.R.I. Standards and will provide many years of safe and dependable comfort, providing it is properly installed and maintained. With regular maintenance, this unit will operate satisfactorily year after year. Abuse, improper use, and/or improper maintenance can shorten the life of the appliance and create unsafe hazards.
PAGE 6
Maintenance Information Proper maintenance is important to achieve optimum performance from the furnace. This equipment should be inspected annually by a licensed HVAC technician. Table 1 (page 7) contains suggested inspections and frequency of maintenance. Routine maintenance should include the following: BLOWER & FILTER • Never operate the furnace without a filter in place. Dust and lint can build up on internal components, resulting in loss of efficiency, equipment damage, and possible fire.
PAGE 7
FREQUENCY OF MAINTENANCE MAINTENANCE ITEM BEGINNING OF EACH HEATING SEASON Verify furnace area is free of combustible materials. Verify combustion and ventilation air is not restricted. X X END OF EACH MONTHLY HEATING SEASON X X X X X Verify no signs of physical deterioration of the furnace. X X Verify no obstructions or restrictions in vent or chimney. X X Verify no holes or cracks in vent pipe. X X Verify no corrosion in vent pipe.
PAGE 8
furnace components The furnace components shown in Figure 3 will help identify and locate various parts of the furnace. The component you need to familiarize yourself with is the gas valve. You will use this to turn the furnace on and off. There are no user serviceable parts. All repairs must be done by a licensed HVAC technician.