SDS

ManualsBrandsMilwaukee ManualsImpact WrenchesM18 18-Volt Lithium-Ion Cordless 1/2 in. Impact Wrench W/Pin Detent Kit W/(2) 3.0Ah Batteries, Hard Case

58-97-0500 rev. 4A

January 1, 2009

SECTION 1: PRODUCT AND COMPANY IDENTIFICATION

Milwaukee Electric Tool Corporation

Company Phone Number: 1-262-781-3600 or

13135 West Lisbon Road

1-800-729-3878 (Sawdust)

Brookfield, Wisconsin USA 53005-2550

Emergency Contact Number: 1-800-424-9300

For International: 1-703-527-3887

SECTION 2: HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW

Appearance/Odor: Solid article, odorless

WARNING: No exposure during routine handling of product. Hydrofluoric Acid Exposure During Fire

Fighting: This information is given for the use of professional fire fighters responding to a warehouse fire where

fire from other materials may incinerate batteries. This section is provided solely in case of exposure, during

fire fighting, to the combustion by-products.

Flammable: Organic components will burn if cell is incinerated. Combustion of cell contents may cause

evolution of Hydrogen Fluoride.

Potential Health Effects: Fluoride interferes with nerve impulse conduction causing severe pain or absence

of sensations

Likely Routes of Exposure: Eye contact, skin contact, skin absorption, inhalation. Hydrofluoric acid is

extremely corrosive. Contact with hydrogen fluoride fumes is to be avoided. Permissible exposure limit is

3ppm. In case of contact with hydrogen fluoride fumes, immediately leave the area and seek first aid and

emergency medical attention. Symptoms may have delayed onset. Fluoride ions penetrate skin readily causing

destruction of deep tissue layers even bone. Fluoride interferes with nerve impulse conduction causing severe

pain or absence of sensations. Immediately flush eyes or skin with water for at least 20 minutes to neutralize the

acidity and remove some fluoride. Remove and destroy all contaminated clothing and permeable personal

possessions. Before re-use, impermeable possessions should be soaked in benzalkonium chloride after washing.

Following flushing of the affected areas, an iced aqueous solution of benzalkonium chloride or 2.5% calcium

Product Name:

Lithium-ion batteries, Rechargeable

Cat. #48-11-0490; #V4B: rated 4-volts, 0.9g ELC, 11 Watt-hours (Wh) maximum

Cat. #48-11-1815; #C18B; #M18B: rated 18-volts, 2.3g ELC, 27 Wh maximum

Cat. #48-11-1828; #C18B; #M18BX: rated 18-volts, 4.5g ELC, 54 Wh maximum

Cat. #48-11-1830; #V18B: rated 18-volts, 4.5g ELC, 57 Wh maximum

Cat. #48-11-2401; #C12B; #M12B: rated 12-volts, 1.4g ELC, 16 Wh maximum

Cat. #48-11-2402; #C12BX; M12BX: rated 12-volts, 2.7g ELC, 32 Wh maximum

Cat. #48-11-2830; #V28B; #M28BX: rated 28-volts, 6.3g ELC, 80 Wh maximum

Drawing Number: 58-97-0500 Rev. 4A

Issue Date: January 1, 2009; Product information (above) updated December 7, 2010.

Material Safety Data Sheet

May be used to comply with

OSHA’s Hazard Communication Standard 29 CFR 1910.1200.

This standard must be consulted for specific requirements.

Summary of content (7 pages)

PAGE 1
Material Safety Data Sheet May be used to comply with OSHA’s Hazard Communication Standard 29 CFR 1910.1200. This standard must be consulted for specific requirements. SECTION 1: PRODUCT AND COMPANY IDENTIFICATION Company Phone Number: 1-262-781-3600 or 1-800-729-3878 (Sawdust) Emergency Contact Number: 1-800-424-9300 For International: 1-703-527-3887 Milwaukee Electric Tool Corporation 13135 West Lisbon Road Brookfield, Wisconsin USA 53005-2550 Product Name: Lithium-ion batteries, Rechargeable Cat.
PAGE 2
gluconate gel should be applied to react with the fluoride ion. Compresses and wraps may be used for areas where immersion is not practical. Medicated dressing should be changed every 2 minutes. Exposure to hydrofluoric acid fumes sufficient to cause pain requires immediate hospitalization for monitoring for pulmonary edema. SECTION 3: COMPOSITION /INFORMATION OF INGREDIENTS Ingredient % by Weight 0.1 - 10 0.1 - 0.3 0.1 - 10 0 - 17 10 - 30 10 - 50 0-5 0.
PAGE 3
SECTION 6: ACCIDENTAL RELEASE MEASURES Personal Precautions: Use standard industrial clothing in normal use. If handling large containers of cells wear steel-toed footwear. Environmental Precautions: No special precautions necessary. Methods for Containment: Transport container outdoors. Hold burned cells and fire cleanup solids for disposal as potential hazardous waste. Unburned cells are not hazardous waste. A fire with over 100 kg of cells burnt will likely require reporting to environmental officials.
PAGE 4
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES Color: Odor: Odor Threshold: Physical State: pH: Freezing Point: Boiling Point: Flash Point: Evaporation Rate: Flammability (solid,gas) Upper Flammability Limit: Lower Flammability Limit: Vapor Pressure: Vapor Density: Specific Gravity: Solubilibty (water): Partition Coefficient (noctanol/water): Auto-ignition Temperature: Percent Volatile, wt. %: Volatile Organic Compound (VOC) content, wt. %: 58-97-0500 rev.
PAGE 5
SECTION 10: STABILITY AND REACTIVITY Stability: Conditions to Avoid: Incompatible Materials: Hazardous Decomposition: Possibility of Hazardous Reactions: Stable Do not crush, puncture, incinerate, immerse in water or heat over 212°F (100°C). Steel casing slowly dissolves in strong mineral acids.
PAGE 6
SECTION 14: TRANSPORTATION INFORMATION U.S. DOT HMR (re: ground transport) Proper Shipping Description: UN3090 Lithium batteries/UN3091 Lithium batteries packed with or contained in equipment; Class 9; PG II. Milwaukee rechargeable Lithium-ion type batteries are “excepted” from full hazardous material regulation based on ELC content or Wh, and compliant packaging per 49 CFR 172.102, Special Provision 188.
PAGE 7
SECTION 15: REGULATORY INFORMATION Global Inventories TSCA: United States DSL: Canada ECL: Korea PICCS: Philippines ENCS: Japan AICS: Australia IECS: China EINECS: European Union See Sec. 14. Compliant with, relevant transportation test requirements as described in the UN Manual of Tests & Criteria, Part III, Sub-section 38.3. See Sec. 14. Compliant with, relevant transportation test requirements as described in the UN Manual of Tests & Criteria, Part III, Sub-section 38.3.