MSDS

M A T E RI A L S A F E TY D A T A S H E E T
Epoxy Grout Film Remover
02-2009
Osha’s Hazard Communication Standard
U.S. Department Of Labor
29 CFR 1910.1200 OMB No. 1218-0072
Identity No: 06523 Name: Epoxy Grout Film Remover
Section 1
Manufacturers Name: Miracle Sealants Company
Address: 12318 Lower Azusa Road
E
mergency Phone: [phone]
City: Arcadia
State: CA
Phone: [phone]
Date Prepared:
02-2009
Section 2 - Hazardous Ingredient/Identity Information
Hazardous components CAS# OSHA PEL ACGIH TLV
N-Methylpyrolidone 872-50-4 None None
2-Butoxy Ethanol* 111-76-2 25 ppm 25 ppm
Note - *A Sara 313 Chemical
VOC : 100% by weight (non-regulated)
Section 3 - Physical/Chemical Characteristics
Boiling point: >212
0
F Specific gravity: .955
Vapor pressure: Not tested Melting point: Not tested
Vapor density: Not tested Evaporation rate: Not tested
Solubility in water: Miscible
Appearance and odor: Light gold, solvent odor.
Section 4 - Fire And Explosion Hazard Data
Flash point: 190
0
F Flammable limits: Not Available
LEL: Not Available UEL: Not Available
pH: 9.5
NFPA hazard rating (o = Least, 4 = Extreme)
Health: 2 Fire: 1
Reactivity: 0 Other: 0
HMIS Hazard Rating:
Health: 2 Fire: 1
Reactivity: 0
Extinguishing media: CO2, Dry Foam
Special fire fighting procedures: None
Unusual fire and explosion hazards: None
Section 5 - Reactivity Data
Stability: Stable
Conditions to avoid: None
Incompatible materials to avoid: Strong oxidizers
Hazardous decomposition or byproducts: CO, CO2
Hazardous polymerization: Will not occur.
Section 6 - Health Hazard Data
Routes of Entry:
Eyes - Possible
Inhalation - Possible
Skin - Possible
Ingestion - Possible
Health hazards - Same as signs and symptoms of exposure.
Carcinogenicity:
OSHA: None NTP: None
IARC Monographs: None
Signs and Symptoms of Over Exposure:
Eyes: Burning sensation
Skin: Irritation
Ingestion: Irritagtion, nausea
Inhalation: Dizziness, headaches, irritation
Medical conditions generally aggravated by exposure - None known.
Emergency and First Aid Procedures:
Eyes: Flush with water for 15 minutes. If irritation persists, call a physician.
Skin: Wash off with soap and water. If irritation persists, call a physician
Ingestion: Do not induce vomiting. Call physician or Poison Control Center.
Inhalation: Get person to fresh air. If unconscious, call a physician.
Section 7 - Precautions For Safe Handling And Use
Steps to be taken in case material is released or spilled: Soak up with inert,
a
bsorbent material. Scoop up and place in a proper waste disposal contain-
er.
Waste disposal method: Dispose of in accordance with federal, state and
local regulations.
Precautions to be taken in handling and storing: Store in a cool, dry place,
out of direct sunlight. Do not freeze less than or equal to 32
0
F , or heat
above 110
0
F.
Other precautions: KEEP OUT OF REACH OF CHILDREN. Follow directions on
the container for proper use of this product.
Section 8 - Control Measures
Respiratory protection: Ventilate by opening all doors and windows. If
exposure above the TLV or PEL require a NIOSH approved respirator
equipped for the exposure or suitable respiratory protection per
29 CFR 1910.134 is required.
Ventilation:
Local exhaust - If available Special - none
Mechanical - If available Other - none
Protective gloves: Plastic or rubber, chemical resistant.
Eye protection: Tight fitting, splash proof safety glasses or goggles.
Other protective clothing or equipment: Chemical resistant clothing.
Work hygienic practices: Wash hands thoroughly before handling food
stuffs, liquids or tobacco products. Use common sense and care around
chemicals. Never mix this product with other chemicals. Consult your super-
visor for all other hygienic and safety practices. All practices depend on
your specific business. Directions for use normally found on label which will
dictate engineering and control measures.
Section 9 - Shipping & Regulatory Classification
DOT Shipping Name: Please refer to the Bill of Lading receiving/documents
for up-to-date information.
DOT#: Combustible DOT Hazard Class: Not Available
Toxic Substances Control Act (TSCA): This product and/or all the ingredients
contained in this product have been registered under the Toxic Substances
Control Act.
SARA: SARA 313 chemical identified - 2 (Butoxethoxy) Ethanol.
NOTE: Miracle Sealants believes the data set forth are accurate. Miracle
Sealants makes no warranty with respects thereto and disclaims all liability
or reliance thereon. Such data are offered solely for consideration, investi-
gation and verification. Also, the data set forth is for the concentrated fin-
ished product. All lab samples are for experimental purposes only and
used at the customers discretion.
www.miraclesealants.com