MSDS

M A T E RI A L S A F E TY D A T A S H E E T
Stone Polish
02-2009
Osha’s Hazard Communication Standard
U.S. Department Of Labor
29 CFR 1910.1200 OMB No. 1218-0072
Identity No: Name: Stone Polish
Section 1
Manufacturers Name: Miracle Sealants Company
Address: 12318 Lower Azusa Road
Emergency Phone: [phone]
City: Arcadia
State: CA
P
hone: 626-443-6433
Date Prepared:
02-2009
Section 2 - Hazardous Ingredient/Identity Information
Hazardous Components CAS # OSHA PEL ACGIH TLV
Aliphatic Hydrocarbons 8052-4-3 100 ppm 100 ppm
VOC Content: 80 g/L
Section 3 - Physical/Chemical Characteristics
Boiling point: 360 - 510
0
F Specific gravity: 0.77
Vapor pressure (Mm Hg): 2 Melting point:
Not Available
Vapor density (Air=I): 4.9 Evaporation rate: 0.12
Weight per gallon: 6.4 Lbs Solubility in water: Insoluble
Appearance and odor: Cloudy white liquid - Solvent odor.
Section 4 - Fire And Explosion Hazard Data
Flash Point: 105
0
F ( TCC ) Flammable limits: Lower-1.0/Upper-6.0
Auto ignition temp: 490
0
F
NFPA hazard rating (o = Least, 4 = Extreme)
Health: 1 Fire: 2
Reactivity: 0 Other: 0
HMIS Hazard Rating:
Health: 1 Fire: 2
Reactivity: 0
Extinguishing media: Foam, carbon dioxide, dry chemical.
Special fire fighting procedures: Use self contained breathing apparatus.
Pressure demands MSHA/NIOSH approved (or equivalent) and full protec-
tive gear. Cool fire exposed areas & equipment.
Unusual fire and explosion hazards: Do not use direct stream of water,
material may float and reignite. Vapor fumes can catch fire and ignite.
Section 5 - Reactivity Data
Stability: Stable.
Conditions to avoid: Sparks or open flames, or severe heat.
Incompatible materials to avoid: Strong oxidizers & reducing agents.
Hazardous decomposition: Thermal decomposition products might include
carbon monoxide and carbon dioxide.
Hazardous polymerization: Will not occur
Section 6 - Health Hazard Data
Routes of Entry:
Inhalation - Possible
Skin - Possible
Ingestion - Possible
Eyes - Possible
Health Hazards - Same as signs and symptoms of overexposure.
Carcinogenicity:
OSHA: None NTP: None
IARC Monographs: None
Signs and Symptoms of Overexposure:
Skin: May cause skin irritation on prolonged or repeated contact.
Eyes: Mild Irritation.
Ingestion: Harmful if swallowed.
Inhalation: Avoid inhalation, if affected, remove individual to fresh air.
Medical conditions generally aggravated by exposure: None known.
Chronic effects of over exposure: Prolonged exposure to high concentra-
tions may cause symptoms of central nervous system
Depression such as headache, dizziness, loss of coordination. Affected per-
sons normally experience complete recovery when removed from exposure
area.
Emergency and First Aid Procedures
Ingestion: If swallowed, contact a physician or poison control center imme-
diately. Do not induce vomiting unless directed by physician.
Skin: Remove contaminated clothing and wash affected areas of skin with
soap and water. Contact a physician if irritation persists.
Inhalation: Remove affected person to fresh air. Apply artificial respiration if
indicated.
Eyes: Flush with plenty of water. Contact a physician if irritation persists.
Section 7 - Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled: Eliminate all open
f
lame in vicinity of spill or released vapor. Stop the source of leak or release.
Clean up release as soon as possible observing.
Precautions listed under special protective information. Contain liquid to
prevent further contamination of soil, surface water or ground water. Clean
up small spills using appropriate techniques such as sawdust, earth, etc.
Waste disposal method: Place contaminated materials in disposable con-
tainers and dispose of in a manner consistent with applicable regulations.
Contact local environment or health authorities for approved disposal of
this material.
Precautions to be taken in handling and storing: storing upright at room
temperature. Avoid exposure to extreme temperatures. Do not use or store
near flame, sparks, or hot surfaces. Use only in well ventilated areas.
Containers smaller than one gallon: Store in original container in a cool dry
place inaccessible to children and pets
Keep container closed when not in use. Emptied container still contains
hazardous or explosive vapor or liquid.
Section 8 - Control Measures
Respiratory protection: Ventilate by opening all doors and windows. If
exposure above the TLV or PELrequire a NIOSH approved respirator
equipped for the exposure or suitable respiratory protection per
29 CFR 1910.134 is required.
Ventilation:
Local exhaust - Okay Special - None
Other - None Mechanical - Yes, when in enclosed spaces
Protective gloves: Plastic or rubber, chemical resistant.
Eye protection: Tight fitting splash proof safety glasses.
Other protective clothing or equipment: As necessary to protect against
prolonged or repeated contact.
Work hygienic practices: Wash hands thoroughly before handling food
stuffs, liquids or tobacco products. Use common sense and care around
chemicals. Never mix this product with other chemicals. Consult your super-
visor for all other hygienic and safety practices. All practices depend on
your specific business. Directions for use normally found on label which will
dictate engineering and control measures.
Section 9 - Shipping & Regulatory Classification
DOT Shipping Name: Coating Solution, Liquid. Please refer to the Bill of
Lading receiving/documents for up-to-date informa-
tion.
DOT Hazard Class:
Not Available
Toxic Substances Control Act (TSCA): This product and/or all the ingredients
contained in this product have been registered under the Toxic Substances
Control Act.
SARA: No SARA 313 chemicals identified.
NOTE: Miracle Sealants believes the data set forth are accurate. Miracle
Sealants makes no warranty with respects thereto and disclaims all
liability or reliance thereon. Such data are offered solely for consideration,
investigation and verification. Also, the data set forth is for the concentrated
finished product. All lab samples are for experimental purposes only and
used at the customers discretion.
www.miraclesealants.com