AIR-COOLED ROOFTOP PACKAGED AIR CONDITIONERS Series COOLING ONLY HEAT PUMP :PR-5,8,10,15,20 :PRH-5,8,10,15,20 PRH-5,8,10,15,20-L DATA BOOK
CONTENTS SAFETY FOR USE -----------------------------------------------------2 A COMPLETE LINE UP -----------------------------------------------4 FEATURES ---------------------------------------------------------------5 DESCRIPTIONS --------------------------------------------------------6 MECHANICAL SPECIFICATIONS----------------------------------6 TYPICAL INSTALLATION EXAMPLE------------------------------7 SPECIFICATIONS ------------------------------------------------------8 ELECTRICAL DATA -----------
SAFETY FOR USE Before conducting installation work, please read this ''SAFETY FOR USE'' carefully for correct installation. Since the caution items shown here contain important description relative to safety, please observe them without fail. Warning Erroneous handling gives a high possibility to induce serious results such as death or heavy injury. Caution Erroneous handling may induce serious injury depending on the situation.
Caution Refrain from installing the unit in an area where flammable gas can accumulate around the unit. If the flammable gas can accumulate around the unit, an explosion can occur. When the unit is installed at telecommunication centers or hospitals, take a proper provision against noise. The erroneous operation of air conditioner may be induced by inverter equipment, independent power device, medical equipment or communication equipment.
A COMPLETE LINE UP PR-5YC PRH-5YA PRH-5YA-L (PRH ONLY) Cooling capacity Heatling capacity 14,000 kcal/h 13,000 kcal/h 55,600 BTU/h 51,600 BTU/h 16.3 kW 15.1 kW PR-8YC PRH-8YA PRH-8YA-L (PRH ONLY) Cooling capacity Heatling capacity 20,500 kcal/h 19,800 kcal/h 81,300 BTU/h 78,600 BTU/h 23.8 kW 23 kW PR-10YC PRH-10YA PRH-10YA-L PR-15YC PRH-15YA PRH-15YA-L Cooling capacity Heatling capacity 25,500 kcal/h 27,500 kcal/h 101,200 BTU/h 109,100 BTU/h 29.
FEATURES Labor Saving Installation High Sensible Cooling Capacity Because of the single unit configuration, all refrigeration work can be omitted. The unit operation can commence immediately after connection to the power supply, drain piping, ducting and control system. The sensible cooling capacity has been significantly improved through optimized heat exchanger design. Comfort Heating The PRH series are designed to provide effective heating even when the outside temperature is down to 0˚C.
DESCRIPTIONS MITSUBISHI ELECTRIC Rooftop Air Conditioners Series PR,PRH,RPH-L are available in a wide range of sizes and models to enable the designer to select the best model for each application. The complete range has been designed for outdoor installation, and the units are provided with the latest technological features to ensure economical, reliable and comfortable ducted type air conditioning. All series units are completely assembled, wired and strictly tested at the factory.
TYPICAL INSTALLATION EXAMPLE PR PRH PRH-L - 7-
SPECIFICATIONS ITEM TOTAL COOLING CAPACITY (GROSS) SENSIBLE COOLING CAPACITY (GROSS) TOTALHEATING CAPACITY (GROSS) (PRH-YA,PRH-YA-L ONLY) CAPACITY STEPS REFRIGERANT REFRIGERANT CONTROL EXTERNAR FINISH COLOR (MUNSELL NO.
ELECTRICAL DATA Cooling TOTAL INPUT TOTAL RUN CURRENT POWER FACTOR START CURRENT kW A % A PR-5YC PRH-5YA PRH-5YA-L 5.4 10.3 73 62 415V COMPRESSOR INPUT RUN CURRENT I/D FAN INPUT RUN CURRENT O/D FAN INPUT RUN CURRENT kW A kW A kW A 3.92 7.44 1.24 2.26 0.24 0.6 6.46 11.70 1.30 2.90 0.54 1.3 9.22 15.62 1.64 3.28 0.54 1.3 2 X 6.55 2 X 11.74 2.62 4.72 2 X 0.54 2 X 1.3 2 X 9.30 2 X 15.22 3.02 6.06 2 X 0.54 2 X 1.3 TOTAL INPUT TOTAL RUN CURRENT POWER FACTOR START CURRENT kW A % A 5.4 11.2 73 68 8.
- 10 - 21.4 24 19.5 21 20.7 19.0 20 23 21.4 24 20.1 20.7 23 22 20.1 22 19.0 19.5 20 21 20.7 18.5 19 20.1 22 23 19.5 21 18.5 19.0 19 20 19.5 17.9 18 19.0 20 21 18.5 17.4 17 19 16.9 16 17.9 18.5 19 18 17.9 16.9 16 18 16.4 15 17.4 17.4 17 17 16.9 16.4 15 16 Q kW WB ˚C 11.8 12.6 13.7 14.6 15.6 10.1 11.0 11.9 12.9 13.7 14.8 9.1 10.1 10.9 12.0 13.0 14.0 9.2 10.1 11.1 12.2 13.1 14.0 9.4 10.2 11.1 12.2 13.1 9.4 10.3 11.
- 11 - 23.0 23.7 24 21.6 21 23 20.9 20 22.3 23.7 24 22 23.0 23 20.9 20 22.3 20.3 19 22 23.0 23 21.6 22.3 22 21 21.6 20.3 21 19.7 18 19 20.9 14.8 21.6 21 20 9.9 20.9 20 12.6 13.6 14.5 15.3 16.3 10.7 11.7 12.7 13.6 14.6 15.6 9.9 10.9 11.9 12.7 13.8 10.9 12.0 13.0 13.9 20.3 19.1 17 14.8 19.7 18.5 16 10.2 19 20.3 19 11.0 12.0 13.0 13.9 10.1 11.1 12.1 SHCkW 18 19.7 18.5 16 18 18.0 15 19.1 19.1 17 17 18.5 18.
- 12 - 0.70 17.5 15.9 14.6 13.1 20.5 18.8 17.2 15.8 14.3 13.1 21.6 20.1 18.6 17.1 15.7 14.4 22.8 21.6 25.0 25.7 26.5 27.3 25.0 25.7 26.5 27.3 28.1 29.0 25.7 26.5 27.3 28.1 29.0 30.0 26.5 27.3 18 19 20 21 18 19 20 21 22 23 19 20 21 22 23 24 20 21 17.1 0.78 18.9 24.2 17 30.0 0.87 20.4 23.5 16 24 0.52 13.4 25.7 19 18.6 0.59 14.8 25.0 18 29.0 0.67 16.2 24.2 17 23 0.75 17.6 23.5 16 20.0 0.84 19.2 22.8 15 28.1 0.55 13.
- 13 - 32.0 24 29.2 21 31.0 28.3 20 23 32.0 24 30.1 31.0 23 22 30.1 28.3 20 22 27.4 19 29.2 31.0 23 21 30.1 22 27.4 19 29.2 26.5 18 28.3 29.2 21 21 28.3 20 20 27.4 25.8 17 19 25.2 16 26.5 27.4 19 18 26.5 25.2 16 18 24.4 15 25.8 25.8 17 17 25.2 24.4 15 16 Q kW WB ˚C 0.0 17.1 18.7 20.1 21.5 26.6 14.6 16.0 17.2 18.7 20.0 25.1 13.2 14.6 16.1 17.5 18.8 23.4 13.3 14.8 16.2 17.8 19.4 23.3 13.5 15.0 16.4 17.8 20.9 13.
- 14 - 38.0 39.2 24 35.7 21 23 34.6 20 36.8 39.2 24 22 38.0 23 34.6 20 36.8 33.5 19 35.7 38.0 23 22 36.8 21 35.7 33.5 19 22 32.4 18 21 35.7 21 34.6 34.6 20 20 33.5 31.4 17 32.4 30.4 16 19 33.5 18 32.4 19 30.4 16 18 29.4 15 31.4 31.4 17 17 30.4 29.4 15 16 Q kW WB ˚C 22.3 24.3 26.1 28.2 30.1 18.8 20.5 22.4 24.6 26.3 28.1 17.1 18.8 20.7 22.8 24.8 26.9 17.1 19.0 21.1 23.3 25.1 26.8 17.4 19.4 21.4 23.1 24.7 17.6 19.
- 15 - 42.1 43.4 39.4 21 24 38.1 20 23 43.4 24 40.7 42.1 23 22 40.7 38.1 20 22 36.8 19 39.4 42.1 23 21 40.7 22 36.8 19 39.4 35.7 18 21 39.4 21 38.1 38.1 20 20 36.8 34.7 17 19 33.6 16 35.7 36.8 19 18 35.7 33.6 16 18 32.7 15 34.7 34.7 17 17 33.6 32.7 15 16 Q kW WB ˚C 23.9 25.7 27.7 29.6 31.2 20.0 21.9 24.0 26.0 27.8 29.8 18.5 20.4 22.1 24.0 26.1 28.2 18.5 20.6 22.4 24.6 26.4 28.6 18.8 20.7 22.6 24.5 26.5 18.7 20.
- 16 - 59.0 24 53.9 21 57.3 52.1 20 23 59.0 24 55.7 57.3 23 22 55.7 52.1 20 22 50.5 19 53.9 57.3 23 21 55.7 22 50.5 19 53.9 48.9 18 21 53.9 21 52.1 52.1 20 20 50.5 47.2 17 19 45.7 16 48.9 50.5 19 18 48.9 45.7 16 18 44.5 15 47.2 47.2 17 17 45.7 44.5 15 16 Q kW WB ˚C 33.6 37.2 40.7 43.1 45.8 28.3 31.5 34.5 37.2 40.1 43.4 25.8 29.0 31.8 34.4 37.4 40.6 26.4 28.7 31.8 34.7 37.3 40.2 26.3 28.9 31.6 34.7 37.8 26.0 29.
- 17 - 62.4 64.3 24 58.6 21 23 56.7 20 60.3 64.3 24 22 62.4 23 56.7 20 60.3 54.7 19 22 62.4 23 58.6 60.3 22 21 58.6 21 54.7 19 56.7 52.7 18 20 58.6 56.7 21 54.7 20 50.9 17 52.7 49.0 16 19 54.7 19 18 52.7 49.0 16 18 47.6 15 50.9 50.9 17 17 49.0 47.6 15 16 Q kW WB ˚C 36.0 38.7 41.6 44.5 47.6 30.2 33.1 36.2 39.3 42.0 44.9 27.5 30.2 33.4 36.3 38.8 42.2 27.5 30.6 33.4 36.9 39.7 42.1 27.9 30.6 33.6 36.3 39.5 27.0 29.
- 18 - 75.7 78.0 23 24 71.2 21 73.4 69.0 20 22 75.7 78.0 69.0 20 23 24 67.0 19 73.4 75.7 23 22 73.4 22 71.2 71.2 21 69.0 21 65.0 67.0 18 19 20 71.2 69.0 20 21 67.0 19 63.2 17 65.0 67.0 61.3 19 16 18 65.0 61.3 16 18 59.3 15 63.2 63.2 17 17 61.3 16 59.3 Q kW 20.0 44.5 48.4 52.1 56.2 60.0 41.6 37.4 45.5 49.8 53.1 57.0 34.1 38.2 42.0 45.5 54.0 49.6 34.2 38.0 42.2 46.2 50.6 34.8 54.6 39.0 43.0 46.6 50.4 34.8 39.2 42.
- 19 - 85.6 24 77.8 21 83.0 75.3 20 80.4 85.6 24 23 83.0 23 22 80.4 75.3 20 22 72.9 19 77.8 83.0 23 21 80.4 22 72.9 19 77.8 70.6 18 21 77.8 21 75.3 75.3 20 20 72.9 68.4 17 19 66.2 16 70.6 72.9 19 18 70.6 66.2 16 18 64.2 15 68.4 68.4 17 17 66.2 64.2 15 16 Q kW WB ˚C 47.1 51.5 55.5 59.1 62.5 40.2 44.0 47.4 51.3 55.0 59.0 36.5 40.2 44.3 48.2 51.8 55.8 36.6 40.7 44.5 48.7 52.7 56.3 37.2 40.9 45.1 49.0 52.6 37.6 41.
Outdoor temp.(˚CDB) 10 0 -10 40 30 Range for continuous operation 40 30 -10 20 0 10 PRH-YA-L 10 15 15 20 20 Outdoor temp.(˚CWB) Range for continuous operation 24 25 24 25 10 0 -10 Range for continuous operation Use for Low temp.parts 30 Range for continuous operation 40 10 15 20 30 Indoor temp.(˚CWB) - 2020 24 25 50 46 50 46 10 5 30 Range for continuous operation Outdoor temp.
FAN PERFORMANCE Airflow PR-5YC PRH-5YA PRH-5YA-L CMM L/S Operation range External static pressure (Pa) 700 100 Fan speed (rpm) 600 200 500 External static pressure (Pa) 1800 1700 400 300 1600 1.1kW 1500 300 1400 200 1300 100 0.
PR-10YC PRH-10YA PRH-10YA-L CMM L/S FAN SPEED Operation range PULLEYSIZE 100 External static pressure (Pa) 600 External static pressure (Pa) 1800 inch MOTOR kw FAN SPEED rpm PULLEYSIZE mm (MOTOR SIDE) inch 200 PULLEYSIZE mm (FAN SIDE) inch BELT SIZE inch 1600 300 2.2kW 1400 MOTOR kw FAN SPEED rpm PULLEYSIZE mm (MOTOR SIDE) inch 300 200 100 inch BELT SIZE 1700 1500 PULLEYSIZE mm (FAN SIDE) inch BELT SIZE inch 1.
Airflow CMM L/S PR-20YC PRH-20YA PRH-20YA-L FAN SPEED PULLEY SIZE (MOTOR SIDE) 100 Operation range 700 External static pressure (Pa) 600 External static pressure (Pa) 200 Fan speed (rpm) 300 1200 500 1100 400 400 4.0kW 1000 300 900 3.
Pulley outside dimensions are shown below: (Unit : mm) (1) Shape of belt groove e f Sectional plan of V-belt w L0 Shape of Nominal a W V-belt Dia. øP.C ( ˚ ) r3 øP.C K0 a r2 r2 11.0mm r1 L0 K K0 e f r1 r2 r3 V-belt thickness (Reference) 1~2 11 K 16.5mm B 40˚ Over 125 Under 160 Over 160 Under 200 36 16.07 12.5 5.5 Over 200 38 16.29 34 15.86 9.5 19.0 12.5 0.2~0.5 0.5~1.0 B type (2) Shape of motor pulley boss (Unit : mm) C B A MOTOR CAPACITY (kW) A B +0.009 0 0.
NC CURVES PR-5YC PRH-5YA PRH-5YA-L 50Hz CONDITION A scale 63 Hz 125 Hz 250 Hz 500 Hz 1000 Hz 2000 Hz 4000 Hz 8000 Hz COOLING & HEATING 62db 67 63 62 61 57 50 45 43 90 80 NC-70 octave-band lebel db (0db=0.0002ubar) 70 NC-60 60 NC-50 50 NC-40 40 NC-30 30 NC-20 20 10 over all 45 63 90 125 180 250 355 500 710 1000 1400 2000 2800 4000 5600 8000 octave-band frequency [Hz] Note. The measuring point is 1m from the comp. service panel.
PR-10YC PRH-10YA PRH-10YA-L 50Hz CONDITION A scale 63 Hz 125 Hz 250 Hz 500 Hz 1000 Hz 2000 Hz 4000 Hz 8000 Hz COOLING & HEATING 64db 71 69 63 61 59 57 49 44 90 80 NC-70 octave-band lebel db (0db=0.0002ubar) 70 NC-60 60 NC-50 50 NC-40 40 NC-30 30 NC-20 20 10 over all 45 63 90 125 180 250 355 500 710 1000 1400 2000 2800 4000 5600 8000 octave-band frequency [Hz] Note. The measuring point is 1m from the comp. service panel.
PR-20YC PRH-20YA PRH-20YA-L 50Hz CONDITION A scale 63 Hz 125 Hz 250 Hz 500 Hz 1000 Hz 2000 Hz 4000 Hz 8000 Hz COOLING & HEATING 68db 73.5 77 70 65 60 58 51 48 90 80 NC-70 octave-band lebel db (0db=0.0002ubar) 70 NC-60 60 NC-50 50 NC-40 40 NC-30 30 NC-20 20 10 over all 45 63 90 125 180 250 355 500 710 1000 1400 2000 2800 4000 5600 8000 octave-band frequency [Hz] Note. The measuring point is 1m from the comp. service panel. OUTLINE DIMENSIONS 1030 25 16-ø3.
PR-8,10YC PRH-8, 10YA PRH-8, 10YA-L 20-ø3.5 HOLES (1330) 25 35 180 180 180 180 180 180 10 A 742 65 35 1150 25 15 CONDENSER AIR OUTLET 65 25 10 1330 300 20 130 130 20 25 SUPPLY AIR DUCT FLANGE 25 410 180 25 A(DETAIL) 6-15X25 MTG HOLES 25 742 180 RETURN AIR DUCT FLANGE 1200 190 190 190 10 190 190 30 65 25 65 190 10 30 1150 1200 1300 75 50 40 1600 49 20-ø3.5 HOLES 607 944 470 300 42 75 50 40 1000 199 SUPPLY AIR CONTROL BOX 49 22 54.
WIRING DIAGRAMS PR-5, 8, 10YC (STANDARD) Power Supply 3Phase CIRCUIT BREAKER (FIELD SUPPLY) 380~415Volt PR- 5YC ···40A PR- 8YC ···50A PR-10YC ···60A 50Herts TB1 L1 L2 L3 WHITE 51C 52C RED RED WHITE WHITE 51F2 RED WHITE BLUE R1 TB2 S1 BLACK PE T1 52F TB2 RED R2 WHITE S2 BLACK T2 51F1 1 2 3 WHITE TB3 RED WHITE MF2 BLACK RED RED F INTERNAL PROTECTOR BLACK BLACK BLACK N MC RED F (3.
PR-15, 20YC (STANDARD) CIRCUIT BREAKER (FIELD SUPPLY) PR -15YC···100A PR -20YC···125A Power supply 3Phase 380~415Volt 50Hertz TB1 L1 Red MC1 52C1 Red L2 White White L3 Black Black 51C1 INTERNAL PROTECTOR Red Black 51F2 Red N Blue White Black PE 52C2 Red 51C2 Red MC2 Red TB2 R 11 R 12 1 Red White S 11 S 12 2 White Black T 11 T 12 3 Black MF2 INTERNAL PROTECTOR White White Black Black Black 51F3 51F1 52F Red Red White INTERNAL PROTECTOR Red TB3 R 21 R 22 1 Red
PR-5, 8, 10YC (SPECIAL ORDER : K CONTROL) Power supply 3Phase 380~415Volt 50Hertz TB1 L1 Red CIRCUIT BREAKER (FIELD SUPPLY) PR- 5YC ···40A PR- 8YC ···50A PR-10YC ···60A MC 51C 52C Red L2 White White L3 Black Black Red Black 51F2 N Blue PE 52F DSA CN 1 3 Red 51F1 Black R2 1 Red S2 2 White T1 T2 3 Black MF2 Red White Blue TB2 S1 R1 Black MF1 Green/Yellow INTERNAL PROTECTOR F(3.
PR-5, 8, 10YC (SPECIAL ORDER : LOW TEMPERATURE) Power supply 3Phase 380~415Volt 50Hertz TB1 L1 Red CIRCUIT BREAKER (FIELD SUPPLY) PR - 5YC ···40A PR - 8YC ···50A PR -10YC ···60A MC 52C L2 White L3 Black N Red 51C Red White Black Black 51F2 TB2 R1 R1 Blue PE 52F1 Red 51F1 S1 White T1 T1 Black Red Red R2 R2 1 Red S2 S2 2 White T2 T2 3 Black White Black 51F3 MF2 52F3 White Black Black TB2 52F2 Red S1 MF1 Tr1 52F4 INTERNAL PROTECTOR F(3.
PR-15, 20YC (SPECIAL ORDER : LOW TEMPERATURE) CIRCUIT BREAKER (FIELD SUPPLY) PR -15YC···100A PR -20YC···125A Power supply 3Phase 380~415Volt 50Hertz TB1 L1 Red MC1 52C1 Red L2 White White L3 Black Black 51C1 INTERNAL PROTECTOR Red Black 51F2 Red N Blue White Black PE 52C2 Red 51C2 Red MC2 Red Red S 11 S 11 White T 11 T 11 Black INTERNAL PROTECTOR TB2 52F2 Red White 51F4 52F3 Black R 12 R 12 1 Red S 12 S 12 2 White T 12 T 12 3 Black MF2 White White Black Bl
PR-5, 8, 10YC (SPECIAL ORDER : K CONTROL & LOW TEMPERATURE) Power supply 3Phase 380~415Volt 50Hertz CIRCUIT BREAKER (FIELD SUPPLY) PR - 5YC ···40A PR - 8YC ···50A PR -10YC ···60A L1 MC TB1 Red L2 L3 N 52C Red White White Black Black 51C Red Black 51F2 Blue PE 52F1 DSA CN 1 3 Red 51F1 Black R1 Red S1 S1 White T1 T1 Black Red White Blue TB2 R1 TB2 52F2 Red White Black R2 R2 1 Red S2 S2 2 White T2 T2 3 Black MF2 51F3 52F3 MF1 Black Green/Yellow Tr1 52F4 INTE
PRH-5, 8, 10YA PRH-5, 8, 10YA-L (STANDARD) CIRCUIT BREAKER Power Supply 3Phase (FIELD SUPPLY) PRH- 5YA, ···40A PRH- 5YA-L PRH- 8YA, ···50A PRH- 8YA-L PRH-10YA, ···60A PRH-10YA-L 380~415Volt 50Hertz TB1 L1 L3 51C 52C RED RED L2 WHITE BLACK BLACK BLACK N 51F2 RED WHITE BLUE R1 PE TB2 S1 BLACK T1 52F TB2 RED R2 WHITE S2 BLACK T2 51F1 X1 WHITE TB3 1 2 3 RED WHITE F (3.15A) MF1 INTERNAL PROTECTOR BLACK 11 11 TB4 1 SWITCH BOX (FIELD SUPPLY) 15 HZ HZ 13 51F1 F (3.
PRH-15, 20YA PRH-15, 20YA-L (STANDARD) CIRCUIT BREAKER (FIELD SUPPLY) PRH-15YA ···100A PRH-15YA-L PRH-20YA ···125A PRH-20YA-L Power supply 3Phase 380~415Volt 50Herts TB1 L1 Red MC1 52C1 Red L2 White White L3 Black Black 51C1 INTERNAL PROTECTOR Red Black 51F2 Red N Blue White Black 52C2 Red 51C2 Red Black MC2 Red MF2 INTERNAL PROTECTOR White White Black Black Black 51F3 51F1 52F Red Red White INTERNAL PROTECTOR Red TB3 X2 R 21 R 22 1 Red White S 22 2 White Black T
PRH-5, 8, 10YA PRH-5, 8, 10YA-L (SPECIAL ORDER : K CONTROL) CIRCUIT BREAKER (FIELD SUPPLY) PRH- 5YA, ···40A PRH- 5YA-L PRH- 8YA, PRH- 8YA-L···50A PRH-10YA, PRH-10YA-L···60A Power supply 3Phase 380~415Volt 50Herts TB1 L1 Red MC 51C 52C Red L2 White White L3 Black Black Red Black 51F2 N Blue PE 52F DSA CN 1 3 Red 51F1 Black Black TB2 X1 1 Red S1 S2 2 White T1 T2 3 Black R1 R2 MF2 Red White Blue INTERNAL PROTECTOR MF1 Green/Yellow INTERNAL PROTECTOR F(3.
PRH-5, 8, 10YA PRH-5, 8, 10YA-L (SPECIAL ORDER : LOW TEMPERATURE) CIRCUIT BREAKER (FIELD SUPPLY) PRH- 5YA, ···40A PRH- 5YA-L PRH- 8YA, ···50A PRH- 8YA-L PRH-10YA, ···60A PRH-10YA-L Power supply 3Phase 380~415Volt 50Herts TB1 L1 Red MC 52C L2 White L3 Black N 51C Red Red White Black Black 51F2 TB2 R1 R1 Blue PE 52F1 51F1 Red S1 White T1 T1 Black Red R2 R2 1 Red S2 S2 2 White T2 T2 3 Black White Black 51F3 Red X1 TB2 52F2 Red S1 MF2 52F3 White MF1 Black Black T
PRH-15, 20YA PRH-15, 20YA-L (SPECIAL ORDER : LOW TEMPERATURE) CIRCUIT BREAKER (FIELD SUPPLY) PRH-15YA ···100A PRH-15YA-L PRH-20YA ···125A PRH-20YA -L Power supply 3Phase 380~415Volt 50Herts TB1 L1 Red MC1 52C1 Red L2 White White L3 Black Black 51C1 INTERNAL PROTECTOR Red Black 51F2 Red N Blue White Black PE 52C2 Red 51C2 Red MC2 Red Red S 11 S 11 White T 11 T 11 Black INTERNAL PROTECTOR TB2 52F2 Red White 51F4 52F3 Black R 12 S 12 T 12 R 12 X1 1 Red 2 White S 12 3 Black T
PRH-5, 8, 10YA PRH-5, 8, 10YA-L (SPECIAL ORDER : K CONTROL & LOW TEMPERATURE) CIRCUIT BREAKER (FIELD SUPPLY) PRH- 5YA, ···40A PRH- 5YA-L PRH- 8YA, ···50A PRH- 8YA-L PRH- 10YA ···60A PRH-10YA-L Power supply 3Phase 380~415Volt 50Hertz L1 MC TB1 Red L2 L3 N 52C 51C Red White White Black Black Red Black 51F2 Blue PE 52F1 DSA CN 1 3 51F1 Red TB2 R1 R1 Red S1 S1 White T1 T1 Black Red White Blue INTERNAL PROTECTOR TB2 52F2 Red White Black X1 R2 R2 1 Red S2 S2 2 White T2 T
ELECTRICAL OPERATION FLOW CHARTS PR-5, 8, 10YC START POWER ON CH ON GL ON 30CZ ON (SELF HOLD) SW2 NO ON? YES FZ0,1 ON (SELF HOLD) 52F ON MF1 OPERATE YES NO 23WA ON? YES CZ ON TM ON PASS THE 3 MIN.
PRH-5, 8, 10YA PRH-5, 8, 10YA-L START POWER ON CH ON GL ON 30CZ ON (SELF HOLD) SW3 ON? NO YES FZ0,1 ON (SELF HOLD) 52F ON MF1 OPERATE SW1 COOL? NO HZ ON YES 23WA ON? 21S4 ON NO NO 23WA ON? YES CZ ON YES CZ ON TM ON TM ON PASS THE 3 MIN.? NO NO PASS THE 3 MIN.? YES YES 52C ON MC OPERATE MF2 OPERATE 52C ON MC OPERATE MF2 OPERATE CH OFF CH OFF SAFETY DEVICE OFF? NO NO YES 30CZ OFF CONDENSING TEMP.
PR-15, 20YC START POWER ON CH1, 2 ON GL ON 30CZ1, 30CZ2 ON (SELF HOLD) NO SW2 ON? YES FZ0, FZ1 ON (SELF HOLD) 52F ON MF1 OPERATE YES NO 23WA No.1 ON? YES CZ1 ON TM1 ON NO PASS THE 3 MIN.? YES 52C1 ON MC1 OPERATE MF2 OPERATE CH1 OFF NO 23WA No.2 ON? YES CZ2 ON TM2 ON NO PASS THE 2 SEC.? YES 52C2 ON MC2 OPERATE MF3 OPERATE CH2 OFF No.2 SAFETY DEVICE OFF? No.
PRH-15, 20YA PRH-15, 20YA-L START HZ ON POWER ON 21S41, 2 ON CH1, 2 ON NO 23WA No.2 ON? GL ON YES CZ1 ON 30CZ1, 30CZ2 ON (SELF HOLD) SW3 ON? TM1 ON NO NO YES FZ0, FZ1 ON (SELF HOLD) PASS THE 3 MIN.? YES 52F ON MF1 OPERATE SW1 COOL? TM2 ON NO NO PASS THE 2 SEC.? YES YES 23WA No.1 ON? 52C2 ON MC2 OPERATE MF3 OPERATE NO YES CH2 OFF CZ1 ON TM1 ON PASS THE 3 MIN.? NO 23WA No.
REFRIGERANT SCHEMATICS PR-5YC Condenser Evaporator ø19.05 High pressure switch Check joint ø19.05 Check joint Pressure gauge ø12.7 Check joint ø22.2 Check joint Compressor Capillary Tube ø12.7 ø12.7 Strainer Dryer : OPTION Notes: This schematics shows one refrigerant cycle. PR-15,20YC or PRH-15,20YA or PRH-15,20YA-L is composed of two refrigerant cycles. PR-8, 10, 15, 20YC Condenser Evaporator ø19.05 High pressure switch Check joint ø19.05 Check joint ø12.
PRH-5YA Condenser Evaporator ø19.05 High pressure switch Check joint 4-Way valve Check joint ø19.05 Pressure gauge ø12.7 Check joint ø22.2 Check joint Compressor Capillary Tube Capillary Tube ø12.7 ø12.7 Strainer Check valve Strainer Dryer : OPTION PRH-8, 10, 15, 20YA Notes: This schematics shows one refrigerant cycle. PR-15,20YC or PRH-15,20YA or PRH-15,20YA-L is composed of two refrigerant cycles. Condenser Evaporator 8, 15YA: ø22.0 10, 20YA: ø25.
PRH-5YA-L Condenser Evaporator ø19.05 High pressure switch Check joint 4-Way valve Check joint ø19.05 Pressure gauge ø12.7 Check joint ø22.2 Check joint Compressor Capillary Tube ø12.7 Accumulator Capillary Tube ø12.7 Strainer Check valve Strainer Dryer : OPTION PRH-8, 10,15,20YA-L Notes: This schematics shows one refrigerant cycle. PR-15,20YC or PRH-15,20YA or PRH-15,20YA-L is composed of two refrigerant cycles. Condenser Evaporator 8,15YA-L: ø22.0 10,20YA-L: ø25.
SAFETY & CONTROL DEVICES ITEM NO. COMPRESSOR OVER CURRENT RELAY COMPRESSOR INTERNAL THERMOSTAT HIGH PRESSURE SWITCH FREEZE PROTECTOR FROST PROTECTOR (ONLY PRH-YA,PRH-YA-L) INDOOR FAN MOTOR OVER CURRENT RELAY OUTDOOR FAN MOTOR OVER CURRENT RELAY OUTDOOR FAN MOTOR INTERNAL THERMOSTAT FUSE (CONTROL CIRCUIT) FUSE (OPERATION CIRCUIT) 51C 63H 26L 26D1,2 51F1 51F2 F F OUTDOOR FAN MOTOR OVER CURRENT RELAY (USE THE OPTIONAL PARTS : LOW AMBIENT PARTS) PR-8YC PRH-8YA PRH-8YA-L 26.0A 110˚C OFF 27.
PHYSICAL DATA [PRODUCT] Product type Product number : Cooling type Product number : Heat pump Product number : Heat pump Capacity kw Cooling capacity (AS1861) kW Sensible Cooling capacity (AS1861) kW Cooling power consumption (Input) kW ByPass Factor Heating capacity (AS1861) (Only PRH-YA,PRH-YA-L) kW Heating power consumption (Only PRH-YA,PRH-YA-L) kW ROOFTOP AIR-COOLED HEATPUMP PACKAGED AIR CONDITIONERS PR,PRH,PRH-L SERIES PR-5YC PR-8YC PR-10YC PR-15YC PR-20YC PRH-5YA PRH-8YA PRH-10YA PRH-15Y
[PRODUCT] ROOFTOP PACKAGE AIR COOLED HEATPUMP AND COOLING ONLY UNITS PRH SERIES PRH-5YA PRH-8YA PRH-10YA PRH-15YA PRH-20YA Product type Product number : Heat pump [INDOOR AIR CIRCUIT] Diameter of blowers mm 1 2 253 Width of blowers mm 182 Number of blowers 2 Normal fan motor run current Air quantity kW A L/s External static pressure 282 Beltdrive 1.5 3.28 1,660 mm ✕mm Return air dimensions (h ✕ w) [CONDENSER] mm ✕mm Quantity sq.
INSTALLATION All series of air conditioners are designed for outdoor installations and are to be placed on a slab or rooftop, however if the air conditioner is to be installed in a plant room application, please contact your equipment supplier prior to installation. Access for both service and installation must be provided to the compressors, control wiring and fans as shown below. 1.Clearances (1) Care must be taken to prevent recirculation of the condenser air.
3.Duct Work (1) All series units are equipped with horizontal supply and return air openings. Duct connection to the unit should be made with duct flanges and secured directly to the air openings with flexible duct connectors to avoid normal noise transmission. PRH unit Vertical air plenum Plenum divider Insulation (2) For vertical air supply, a field supply plenum should be used. The figure below shows the recommended method for duct connection.
5.Electrical Wiring Remove the panel on the right side (PR,PRH-5 10) or the rear side (PR,PRH-15,20) of the unit and connect the units power supply wiring to the proper terminals in the control box, as shown below. MODEL INDOOR FAN MOTOR OUTPUT 2 POWER SUPPLY WIRING 2 EARTH MAIN SWITCH PR-5YC PRH-5YA PRH-5YA-L 0.75 1.1 PR-8YC PRH-8YA PRH-8YA-L 1.1 1.5 PR-10YC PRH-10YA PRH-10YA-L 1.5 2.2 PR-15YC PRH-15YA PRH-15YA-L 2.2 3.0 5.5 5.5 5.5 5.
INSTRUCTIONS FOR USE 1.CHECK POINTS FOR OPERATION Check the following points before you operate your air conditioner. (1) Check that there is nothing blocking the flow of air from the air outlet into the air inlet. Indoor Unit Outlet grille Inlet grille Ceiling Ceiling Obstacle blocking air inlet Obstacle blocking air inlet Outdoor Unit Obstacle blocking air inlet (2) Make sure the air conditioner is properly grounded by checking the ground terminal .
2.CAUTION FOR USE Keep the following points in mind to safeguard against failures and breakdowns. (1) This air conditioner does not restart within 3min. after shut down. (These models have a crankcase heater in the compressor. If the air conditioner is shut down for a short time, please do not turn the power switch to OFF, but turn the operation switch to OFF.) (2) If the air conditioner is shut down by a power failure, set the operation switch to OFF.
4. PREPARING FOR OPERATION AFTER PROLONGED SHUTDOWN When the usage season starts, proceed with the following before starting operation: (1)Clean the air filter. (2)Do not use the unit immediately. Turn the main power switch on for a period of 3 hours before restarting cooling / heating operation. This allows the compressors to come up to the correct operation temperatures. Failure to do this, could cause compressor failure. 5.
SPECIFICATION GUIDELINES Please supply and install a one piece, air to air reverse cycle air conditioning system. The system shall be completely assembled, tested and have a complete refrigeration charge ready for installation and operation from the factory. The system shall operate at outdoor ambient temperatures as high as 46˚C.
MEMO - 58 -
DATA BOOK PR,PRH MITSUBISHI ELECTRIC CORPORATION HEAD OFFICE DENKI BLDG., MARUNOUCHI,TOKYO 100,TELEX J24532 CABLE MELCO TOKYO Issuued in January. 1999 MEE98K036 Printed in Japan. New publication effective Jan. 1999. Specifications subject to change without notice.