Installation Instructions If you have questions, call 800-GE-CARES or visit our website at: www.monogram.com 30" Convection Built-In Ovens Models: ZET1038 ZET1058 Monogram. ® We bring good things to life.
Installation Instructions BEFORE YOU BEGIN CAUTION: Read these instructions completely and carefully. Due to the weight and size of these wall ovens and to reduce the risk of personal injury or damage to the product, TWO PEOPLE ARE REQUIRED FOR PROPER INSTALLATION. IMPORTANT – Save these instructions for local inspector’s use. IMPORTANT PRUDENCE – Observe all governing codes and ordinances. Note to Installer – Be sure to leave these instructions with the Consumer.
Installation Instructions CONTENTS Installation Preparation Electrical Requirements ................................................... 7 Tools and Materials ......................................................... 7 Provide Oven Supports..................................................... 8 Step 1, Remove Packaging ............................................. 8 Installation Instructions Step 2, Install Junction Box ............................................ 9 Step 3, 208V Electrical Supply ..........
Cabinetry Framed Cabinet, Double Oven Framed Cabinet, Single oven 23-1/2" 30" 28" Min. 28-3/8" Max. 23" Max. 23-1/2" Inside 28" Min. 28-3/8" Max. 47-5/8" Min. 47-3/4" Max. 34" 12" 30" Order a 30" oven cabinet with the cutout sized to fit the double oven. • These ovens require 3/4" overlap on both sides. Allow 1" Min. for top overlap and clearance to upper doors. Allow 1/4" clearance at the bottom.
Cabinetry Installation Over a Monogram Warming Drawer Single Oven Double Oven 23-1/2" Min. Inside 2x2 or 2x4 Anti-Tip Block Against Rear Wall, 9" From Floor to Bottom of Block 23" Max. 23-1/2" Min. Inside 2x2 or 2x4 Anti-Tip Block Against Rear Wall, 9" From Floor to Bottom of Block 47-5/8" Min. 47-3/4" Max. 2" Min. 9" 2" Min. 9-1/4" 28-1/2" Allow 5/8" Overlap on All Sides 1" Min.
Cabinetry Installation Below a Monogram Advantium Oven Installation Between a Monogram Advantium Oven and a Warming Drawer 23-1/2" Min. Inside 23-1/2" Min. Inside 21" 21" 2" Min. 2" Min. 23" 45-1/4" 28-1/2" Note: Install the oven only with specific models listed on the label located on top of the oven. 23" 45-1/4" 2" Min. 28-1/2" 9-1/4" 1" Min. Above Toekick NOTE: Additional clearances may be required.
Installation Preparation ELECTRICAL REQUIREMENTS TOOLS and MATERIALS YOU WILL NEED These Monogram built-in ovens require a separate properly grounded 3-wire 120/208 or 120/240 volt, 60 Hz power supply, protected by a time delay fuse or circuit breaker. • Double ovens are rated at 6.5 KW at 240 volt and 6.5 KW at 208 volt. • Single ovens are rated at 3.3 KW at 240 volt and 2.8 KW at 208 volt. • Ovens are supplied with a flexible power cable which must be attached to a junction box.
Installation Preparation PROVIDE OVEN SUPPORTS STEP 1 REMOVE PACKAGING Ovens may be supported by either a solid bottom or by 2 x 4 runners. • The support must be level and rigidly mounted, flush with the bottom edge of the cutout. • Remove the carton, plastic coverings and styrofoam side/corner posts. • To prevent damage to the floor, do not remove the styrofoam base until the oven is ready to be installed. • Remove oven contents, shelves and packaging.
Installation Preparation WARNING • If a cold water pipe is interrupted by plastic, nonmetallic gaskets, union connections or other insulating materials, DO NOT use for grounding. • DO NOT ground to a gas pipe. • DO NOT have a fuse in the NEUTRAL or GROUNDING circuit. A fuse in the NEUTRAL or GROUNDING circuit could result in an electrical shock. • Check with a qualified electrician if you are in doubt as to whether the appliance is properly grounded.
Installation Instructions SKIP THIS STEP IF YOU ARE CONNECTING TO 240 VOLT POWER SUPPLY. STEP 3 208V ELECTRICAL SUPPLY WARNING If connecting to a 208 volt, 60 HZ supply, a jumper must be used across two terminals. • For double ovens, there are two jumpers, one for the upper oven, one for the lower oven. • For single ovens there is one jumper. These ovens are pre-wired for connection to 240 volt, 60 HZ, supply. If connecting to a 208 volt supply, modifications must be made.
Installation Instructions STEP 4 REMOVE OVEN DOOR(S) STEP 5 ROUTE CABLE THROUGH CUTOUT • Open the door fully. • Push hinge latches up to lock hinges in open position. CAUTION Oven(s) are very heavy. 2 people are required to lift oven(s) into the opening. Ovens have side handles. Grasp side handle with one hand and put other hand into the oven opening. Carefully, lift the oven to the cabinet opening. Hinge Latch Normal Position PRUDENCE Le four est lourd.
Installation Instructions STEP 6 SECURE OVEN TO CABINET STEP 7 REPLACE OVEN DOOR • Grasp door firmly on both sides. • Slide the hinge slots in the bottom of the door over the hinges. • Push the door all the way in, against the oven. • Slide oven into cabinet opening. • Drill 3/32" pilot holes through the oven front frame and into the cabinet frame. Locked Hinge Latch Secure Oven to Cabinet with Screws Provided • Secure oven to cabinet with screws provided. Single ovens use 2 screws, one on each side.
Installation Instructions STEP 8 CONNECT ELECTRICAL AVERTISSEMENT WARNING RISQUE DE CHOC ÉLECTRIQUE • Cet appareil doit être mis à la terre. • NE PAS brancher l’alimentation électrique si l’appareil n’est pas ELECTRICAL SHOCK HAZARD • Electrical ground is required on this appliance. • DO NOT connect to the electrical supply until appliance is permanently grounded. • Disconnect power to the junction box before making the electrical connection.
Installation Instructions INSTALLATION CHECKLIST 1. Turn all knobs to OFF or Normal. 2. Turn on power at the circuit breaker. 3. Set the clock for current time of day. Refer to the Owner’s Manual for instructions. 4. Check oven door for full opening and closing. Oven lights should be on when the door is opened and off when the door is closed.
Notes 15
Note: While performing installations described in this book, safety glasses or goggles should be worn. For Monogram® local service in your area, call 1-800-444-1845. Note: Product improvement is a continuing endeavor at General Electric. Therefore, materials, appearance and specifications are subject to change without notice. Monogram. ® We bring good things to life. GE Consumer Products General Electric Company Louisville, KY 40225 © 2003 General Electric Company Pub. No. 49-80188 Dwg. No.