GE Monogram® Installation Instructions Professional Gas Cooktops 48" Natural Gas Models ZGU48N4G ZGU48N6R ZGU48N6D 48" LP Gas Models ZGU48L4G ZGU48L6R ZGU48L6D 36" Natural Gas Models ZGU36N6 ZGU36N4R ZGU36N4D 36" LP Gas Models ZGU36L6 ZGU36L4R ZGU36L4D
Before you begin—Read these instructions completely and carefully. IMPORTANT: Save these instructions for local inspector’s use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES. NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer. NOTE TO CONSUMER: Keep these instructions with your Owner’s Manual for future reference. CAUTION WARNING This appliance must be properly grounded. See “Electrical Supply”, page 6. For Monogram local service in your area, 1-800-444-1845.
Design Information Professional Gas Cooktops Models Available Accessory Requirements These cooktops are factory set for either natural gas or liquid propane gas. Order the model for your installation situation.
Design Information Professional Gas Cooktops Product Dimensions & Clearances 47-7/8" 26-5/8" 48" Wide Hood 8-7/16" REAR FRONT REAR HEATING FRONT 13" Max. REAR gram Mono Refer to Hood Installation Instructions FRONT 18" Min. 2" 48" Wide Models 12" Min. to Combustible Material Each Side 17" 46-1/8" 7/8" 36" Min. to Combustible Material From Cooking Surface 22-3/4" Min.
Installation Preparation Professional Gas Cooktops Installation Options These cooktops can be installed in standard 24" or deeper 25" cabinets. • In 24" deep cabinets, the front of the cooktop will project approximately 1-7/8" beyond the front of the countertop. • In 25" deep cabinets, the cooktop will be flush with the front of the countertop. • The stainless surface of the cooktop will be 1/2" higher than adjacent countertop. • Cooktop fits flush to rear of cutout, no additional support is required.
Installation Preparation Professional Gas Cooktops Tools & Materials Required: • Saw • Measuring tape • Carpenter’s square • Pipe and fittings as required. • Manual gas line shut-off valve. • Gas pressure regulator (supplied) • Large flat-blade screwdriver • Pipe wrench Power Supply Locations Gas Supply: • The natural gas models are designed to operate at 6" to 14" water column pressure. • The liquid propane models are designed to operate at 11" to 14" water column pressure.
Installation Professional Gas Cooktops 1 Step Remove Packaging 2 Use a hand-truck to move this cooktop. Before moving the cooktop indoors: • Remove outer carton and packing. • Remove the straps holding the cooktop to the skid. • Remove the grates and drawers below the knobs. • Remove grill and/or griddle covers. DO NOT ATTEMPT TO REMOVE A GRILL OR GRIDDLE ASSEMBLY.
Installation Professional Gas Cooktops 3 Step Install the Cooktop 4 Step Connect Cooktop to Gas 5 Step Install the Cooktop Backguard 8 • Lower the cooktop into the opening. Make sure the cooktop is evenly seated and supported. A side frame gasket will seal the cooktop to the countertop. • “L” brackets with screws are provided to secure the cooktop to the countertop or to adjacent cabinetry.
Installation Professional Gas Cooktops Step 6 Plug power cord into properly grounded receptacle. 7 • Replace the burner bowls and burner caps. • Adjustments should not be required, unless vibration during transit or variations in local gas supply make minor adjustments necessary. Connect Electrical Step Assemble Burners, Check Ignition CAUTION: Burner adjustments must be made by a qualified technician at the time of installation.
Installation Professional Gas Cooktops 7 Step Assemble Burners, Check Ignition (continued) Finalize Installation Adjustable low setting The open top burners and grill valves have an adjustable low setting. Each valve is individually tested and adjusted before it is shipped. Minor adjustments may be required due to fluctuations in local gas pressure. Adjustments to increase or decrease gas flow may be necessary. • Turn knob counter-clockwise to the LITE position.
Notes Professional Gas Cooktops 11
Note: While performing installations described in this book, safety glasses or goggles should be worn. For Monogram® local service in your area, call 1-800-444-1845. Note: Product improvement is a continuing endeavor at General Electric. Therefore, materials, appearance and specifications are subject to change without notice. Monogram. ® We bring good things to life. Pub. No. 49-8812-6 Dwg. No. 164D3333P056 (N.D. 760) 4/03 10659 - Rev.