GE Monogram Installation Instructions Professional Gas Cooktops 48" Natural Gas Models ZGU48N4G ZGU48N6R ZGU48N6D 48" LP Gas Models ZGU48L4G ZGU48L6R ZGU48L6D 36"Nanu_lGasModels ZGU3GNG ZGU3GN4R ZGU36N4D 36" LP Gas Models ZGU36L6 ZGU36L 4t? ZGU36L 41) ®
Before you begin--Read these instructions completely and carefully. Save these instructions for local inspector's use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES. NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer. IMPORTANT: NOTE TO CONSUMER: Ir!,w.,l:mh, t_ This appliance must Kee t) these be properly instructions grounded. See "Electrical For Monogram local service in your area, 1-800-444-1845. For Monogram Service in Canada, Call 1-888-880-3030.
Design Information Professional Models Available These cooktops are factory set for either natural gas or liquid propane gas. Order the model for your installation situation.
Design Information Professional Gas Cooktops Product Dimensions Cleai"ances 1M::! 3 ,,M, 18"Min. 48" Wide Instructions / Combustible t Material From Combusiible Cooking Material Surface Models 7/8" /o 36" Min. to Combustible Material From Cooking 36" Wide Models 1/2" /o / _26-5/8_ 2q/2"_u7 / _Hiclh / 21-11/4" Si_elfo I 36"Min. Combustibles 2 _ow___ f 12"Min.to Combustibles WithoutBackguard or O" to NonoCombustible Wall with1/2"Trim 36"Min.
Installation Preparation P1"ofessiollal Installation These 24" Options cooktops can or deeper • In 24" 25" deep cooktop the • In 25" deep flush with the project fi'ont of the approximately fi'ont of the cabinets, the • The stainless surface of tile cooktop will be 1/2" higher than adjacent countertop. • Cooktop fits flush to rear of cutout, no in standard cabinets. cabinets, will beyond be installed 1-7/8" additional suf)port is required. countertop.
Installation Preparation Professional Tools 8,z Materials Required: • Saw • Measuring • Carlaenter's • Pipe and • Manual • Gas • Pipe Po weF Supply Locations square fttings gas as required. line [aressure • Large • Gas-resistant • 5 foot, 5/8" supply line. codes.) tape shut-off regulator flat-blade Gas Cooktops pipe joint sealant AGA-certified flexible (Length must comply metal gas with local If required by local codes, use solid pipe fittings. Note: Purchase new flexible line.
Installation Pl"ofessional Use a hand-truck Remove Packaging to move • Flatten the carton and use a piece as a pad on the bottom and back of the hand-truck. this cooktop. Before moving the cooktop indoors: • Remove outer carton and packing. • Remove the straps holding the cooktop skid. • Remove knobs. the grates and • Remove grill and/or drawers griddle below covers.
Installation P1"ofessiollal 3 • Lower tim cooktop into tim opening. Make sure tim cooktop is evenly seated and sut> ported. A side fl'ame gasket will seal tim cooktop to tim countertop. • "L" brackets with screws are provided to Msta]] secure tim cooktop to the countertop or to adjacent cabinetry. -Alternate screw hole locations on tile sides the Cooktop Alternate Bracket ScrewHoles of tim cooktop allow for varying thicknesses of countertops or side cleats.
Installation Professional Plug power cord into properly receptacle. Gas Cooktops grounded st< 6 Connect Electrical s,, 7 Assemble BlJl_neYs, Check Ignition • Replace the • AdJustments burner should vibration during gas supply make sary. bowls and burner not be required, transit minor or variations adjustments caps. unless in local neces- m J adjustments • Burner are made flames should after .Main Burner Venturi(rear) be blue and stable {D ¢ niteri i installation.
Installation Professional Adjustable The low open adjustable BIJI_HeI_S, Minor and and in local to increase or decrease Ignition • Turn knob valves valve before may fluctuations necessary. grill Each adjusted adjustments Check (conm_ll_t) burners low setting. ally tested Assemble • Grip the shaft with pliers and turn counterclockwise to lower the flame, or clockwise to increase the flame.
Notes Professional Gas Cooktops
Note: While performing installations described in this book, safety glasses or goggles should be worn. Fur MonQqmm ioc+d ,service in your area, call 1-800-444-1845. Note: P1oduct improvement Genelal Electric. Thelefore, specifications are subject to is a continuing endeavor at matelials, appearance and change without notice. O Monogram: Webringgoodthingsto life. GECortsumet PtocJucts _No,49-8812-6 g No, 164D3333P056 / (N.