Installation guide
Page 2
Part No. XG0509
DFSP Rio Pedestal Stove
Quality Gas Products by Montigo
Introduction
About the Rio Pedestal Stove:
Thank you for purchasing the
Rio Pedestal Stove, and choosing a
Delray Gas Product. This Rio Stove features a Double Burner with a
hi-lo adjustable control.
This Rio Stove is certified for use with Montigo Direct Vent Compo-
nents, and for use with standard 4" B-Vent when using our optional
conversion kit (part number FSTK03). The Rio Pedestal Stove is
certified as a heating appliance by CGA and AGA tothe Vented Gas
Fireplace Heater standard (ANSI Z21.88-2005 · CGA 2.33-2005)
and is rated for:
Natural Gas 25,000 BTU/H Maximum Input
18,500 BTU/H Minimum Input
Propane 22,000 BTU/H Maximum Input
17,000 BTU/H Minimum Input
How to use this manual:
This manual covers installation, operation and maintenance. Light-
ing, operation and care of this fireplace can be easily performed by
the homeowner. However, all installation and service work should be
performed by a qualified or licensed installer, plumber, or gasfitter
who is qualified or licensed by the state, province, region, or govern-
ing body in which the appliance is being installed.
Warranty and Installation Information:
The Montigo warranty will be voided by, and Montigo disclaims any
responsibility for, the following actions:
Modification of the fireplace and/or components including Direct-
Vent assembly or glass doors.
Use of any component part not manufactured or approved by
Montigo in combination with this Delray fireplace system.
Installation other than as instructed in this manual.
Consult your local Gas Inspection Branch on installation require-
ments for factory-built gas fireplaces. Installation & repairs should be
done by a qualified contractor.
Installations in Canada must conform to the current CAN/CGA
B-149.1 and .2 Gas Installation Code and local regulations. If the
optional air-circulating fan kit is installed, it must be electrically
grounded in accordance with CSA C22.1 Canadian Electrical Code
Part 1 and/or Local Codes.
Installations in the USA must conform to local codes, or in
the absense of local codes to the National Fuel Gas Code, ANSI
Z223.1-1988. If the optional air-circulating fan is installed, it must be
grounded in accordance with local codes or, in the absence of local
codes, with the National Electrical Code, ANSI/NFPA 70-1987.
See Appendix C for replace installations within the State of
Massachusetts.
Table Of Contents
Introduction ............................................................................. 2
Installation
Choosing a Location ...................................................... 3
Installing the Gasline ......................................................
4
Direct Vent Installation ................................................... 4
General Requirements ...................................... 4
Terminations ...................................................... 4
Rear Vent Installations ....................................5-6
Top Vent Through-the-Wall Installations ............ 7
Top Vent Through-the-Roof Installations ........... 8
B-Vent Installation ........................................................ 10
Removing and Installing the Door ................................ 11
Installing the Logset ..................................................... 11
Wiring ......................................................................... 12
Operation ..........................................................................13-15
Maintenance .....................................................................15-16
Warranty ................................................................................. 17
Appendix
A. Accessories and Vent Components ..................18 - 19
B. Termination Locations .............................................. 20
CAUTIONS
Due to its high operating temperatures, the appliance
should be located out of traffic & away from furniture and
draperies.
Children and adults should be alerted to the hazards
of the high surface temperature, which could cause
burns or clothing ignition.
Young children should be carefully supervised when
they are in the same room as the appliance.
Clothing or other flammable materials should not be
placed on or near the appliance.