Owner`s manual

Page 2
H-Series DL Gas Fireplace
Part No. XG0140 - 092210
▪ Section 3-3-2: Venting Components .............................. 16
▪ Section 3-3-3: Heat Shields ......................................... 17
▪ Installing a RHS8 Wall Mounted Heat Shield ......... 17
▪
Installing a RHS101 Wall Mounted Heat Shield ......17
Section 4: Wiring ................................................................... 18
▪ Honeywell gas control and pilot .......................... 18
▪
SIT - IPI gas control and pilot ............................... 18
▪ Installing HFK Fan Kit ......................................... 18
Section 5: Installing the Gas Line .......................................... 19
Section 5-1: Fuel Conversion ........................................ 19
Section 5-2:
Gas Pressure ............................................ 19
Section 5-3: Gas Connection......................................... 19
Section 6: Finishing ............................................................... 20
Section 7: Installing and Removing the Door ........................ 21
Section 8: Installing the Accessories ..............................22 - 24
▪
Installing the H34DL Log Set ................................... 22
▪ Installing the H38DL & H42DL Log Set ...............23 - 34
▪
Installing the Top / Bottom Horizontal Louvers ........... 24
Section 9: Operation .......................................................25 - 27
▪
Start-up Sequence with Continuous Pilot .................. 25
▪
Start-up Sequence with Honeywell Electronic Ignition 26
▪
Start-up Sequence SIT-IPI Gas valve ....................... 27
Maintenance ...................................................................28 - 30
▪
General ................................................................. 28
▪
Cleaning ................................................................ 28
▪
Hi-Lo Burner Adjustment ......................................... 28
▪
Pilot Burner Adjustment ........................................... 28
▪ Troubleshooting ....................................................... 29
SIT- Nova 820 Gas Control Valve ......................... 29
SIT- IPI Electronic Gas Control Valve .................... 29
Honeywell Gas Control Valve ............................... 29
▪
Parts List ............................................................... 30
Appendix
A. Termination Locations .......................................... 31
B. Warranty ............................................................ 32
C. State of Massachusetts. ...................................... 33
D. Mobile Home. ..................................................... 34
Safety Alert Key
Introduction ............................................................................... 3
Models............................................................................ 3
Installation
Before you Start ............................................................. 4
Installation Checklist ...................................................... 4
Section 1: Installation Overview and Product Dimensions ...... 5
Section 2: Framing the Fireplace ............................................. 6
Clearances ..........................................................
Installing the Standoffs ........................................
Section 3: The Direct Vent System ...................................7 - 16
Section 3-1: Converting from Top Vent to Rear Vent .... 7
Section 3-2: Installing a Roof mounted Termination 8 - 9
▪ Section 3-2-1: Venting Layout ...................................... 8
▪ Roof mounted Terminations
Standard Top Vent (no elbows or offsets)............. 8
Top Vent (two elbows one offset) ......................... 8
Top Vent (multi-elbows and offsets) ..................... 8
Standard Roof Vent (one elbows no offsets) ....... 9
▪ Section 3-2-2: Venting Components ............................. 9
Section 3-3: Installing a Wall mounted Termination .... 10
▪ Standard PTO Installation .................................... 10
▪ Pre-installed MSR Frame .................................... 10
▪ Pre-installed BSR Frame ..................................... 10
▪ Installing MOSR Frame ....................................... 10
▪ Installing VSS Termination Shield ......................... 10
▪ Installing PTKOG Heat Guard .............................. 10
▪ Section 3-3-1: Venting Layout ................................... 11
▪ Top Vent, Wall mounted Graph, H34DL ................. 11
▪ Top Vent, Wall mounted Graph, H38DL ................. 11
▪ Top Vent, Wall mounted Graph, H42DL ................. 12
▪
Top Vent, Wall mounted termination (one elbow) .... 12
▪ Top Vent, Wall mounted termination (multi elbow) ... 12
▪ Rear Vent, Wall mounted Graph, H34DL ............... 13
▪ Rear Vent, Wall mounted Graph, H38DL ............... 13
▪ Rear Vent, Wall mounted Graph, H42DL ............... 14
▪
Standard Rear Vent, (no elbows or offsets) ........... 14
▪
Rear Vent, Wall mounted termination (two elbows) . 14
▪ Rear Vent, Wall mounted termination (45° corner) .. 15
▪ Rear Vent, Wall mounted termination (-45° corner) . 15
Read this manual before installing, operating or trou-
bleshooting this appliance. Please retain this owner's
manual for future reference.
Table of Contents
Warning: