Installation guide

ManualsBrandsMontigo ManualsLawn and GardenH34BF

Gas Fireplace

H-Series BF

Installation

Operation &

Maintenance

H34BF

H38BF

H42BF

■ Check local codes and

read all instructions prior to

installation.

■ Leave this manual with the

owner.

Warning:

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage. Refer to

this manual. For assistance or additional

information consult a qualied installer,

service agency or the gas supplier.

What To Do If You Smell Gas:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor's phone. Follow the gas

supplier's instructions.

• If you cannot reach your gas supplier, call the re department.

For Your Safety:

Do not store or use gasoline

or other ammable vapors

and liquids in the vicinity

of this or any other

appliance.

Safety Notice:

Glass doors on gas replaces are

extremely hot while the replaces is on

and remain hot even after the replace

has been turned off. Safety screens

are available and can reduce the risks

of severe burns. Please keep children

away from the replace at all times.

C US

Summary of content (18 pages)

PAGE 1
Installation Operation & Maintenance H-Series BF Gas Fireplace H34BF H38BF H42BF Safety Notice: Glass doors on gas fireplaces are extremely hot while the fireplaces is on and remain hot even after the fireplace has been turned off. Safety screens are available and can reduce the risks of severe burns. Please keep children away from the fireplace at all times. Warning: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual.
PAGE 2
H-Series BF Gas Fireplace Table Of Contents Introduction Introduction .............................................................................. 2 Thank You for choosing a Montigo Gas Fireplace. Installation About this Fireplace: Installing and Framing the Fireplace............................... 3 Installing the Gasline....................................................... 4 The H-Series BF is a fireplace with a pan-style burner and glowing embers. This fireplace is available in two models.
PAGE 3
H-Series BF RGas Fireplace Installation Framing The fireplace may be installed in any location that maintains proper clearances to air conditioning ducts, electrical wiring and plumbing. Safety, as well as efficiency of operation, must be considered when selecting the fireplace location. Try to select a location that does not interfere with room traffic, has adequate ventilation, and offers an accessible pathway for Direct Vent installation. Refer to page 4 - Vent Installation for more information.
PAGE 4
H-Series BF Gas Fireplace Installation Installing The Gas Line Vent Installation The gas line must be installed before finishing the H-Series BF Fireplace. Natural Gas requires a minimum inlet gas supply pressure of 5.5" W.C. & a manifold pressure of 3.5" W.C. Propane Gas requires a minimum inlet gas supply pressure of 11" W.C. & a manifold pressure of 10" W.C. Provision must also be made for a 1/8" N.P.T.
PAGE 5
H-Series BF Gas Fireplace Installation Installing The Remote Switch The H-Series BF's gas valve, located behind the lower trim, may be connected to a wall switch. The valve generates its own power on a millivolt circuit. Use only low voltage wire, and DO NOT connect any external power to it. Refer to Figure 30 for wiring requirements. Note: The switch location must not exceed 30' from the fireplace.
PAGE 6
H-Series BF Gas Fireplace Installation Wiring Gas Control and Pilot Wiring H-Series BF-I Honeywell (Q3450) Pilot Assembly Pilot Electrical Harness Connector Honeywell Gas Control (SV9501M) Gas Control Connector Junction Box Cover Fuse Junction Box Fan Plug Receptacle Black 115VAC White Green 24VAC Grnd Screw 40 VA Transformer Limit Switch Wall Switch Figure 9. Wiring for the H-Series BF-I with Honeywell gas control and pilot.
PAGE 7
H-Series BF Gas Fireplace Installation Wiring for the optional Fan Kit All H-Series BF fireplaces may be equipped with optional fan kits for circulating heat into the living space. Installations in Canada which employ the fans must be electrically grounded in accordance with CSA C22.1 Canadian Electrical Code Part 1 and/or Local Codes.
PAGE 8
H-Series BF Gas Fireplace Installation H34BF Installing the Log Set Installing the LogLogs: 'D' The H-Series BF is supplied with four ceramic fibre logs and a ceramic fibre logset base. Unpack the logs and handle them very carefully. 3. Place the bottom left and right logs as shown below in figure 14d. Place the top left and right logs as shown in figure 14e. 4. Base Log Bottom Right Log Bottom Left Log Figure14d. Bottom left and right log placement.
PAGE 9
H-Series BF Gas Fireplace H38BF Installation H42BF Installing the Log Set Installing the Logs: The H-Series BF is supplied with three ceramic fibre logs and a ceramic fibre logset base. Unpack the logs and handle them very carefully. Bottom Log Air Inlet Ports Top Right Log Top Left Log Ember Chips Figure 15d. Ember Chip placement. Base Log 5. Place the top left log as shown in figure 15e. 6. Place the top right log as shown below in figure 15f. 7. Start the fireplace.
PAGE 10
H-Series BF Gas Fireplace Operation - Model H-Series BF H-Series BF with Continuous Pilot For Your Safety - READ BEFORE LIGHTING: WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly. ■ If you cannot reach your gas supplier, call the Fire Department. B.
PAGE 11
H-Series BF Gas Fireplace Operation - Model H-Series BF-I H-Series BF-I with Honeywell Electronic Ignition For Your Safety - READ BEFORE LIGHTING: WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with an ignition system that lights the pilot burner automatically. Do not attempt to light the pilot by hand. B. BEFORE LIGHTING smell all around the appliance area for gas.
PAGE 12
H-Series BF Gas Fireplace B-Series BF-A Operation - Model B-Series BF-A with American Flame Electronic Ignition For Your Safety - READ BEFORE LIGHTING: WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with an ignition system that allows for both continuous pilot operation as well as an electronic ignition that lights the pilot burner automatically.
PAGE 13
H-Series BF Gas Fireplace Operation Maintenance Lighting Instructions General ■ Have the fireplace and installation inspected yearly. The inspection must include, but is not limited to, the following: See pages 19 and 20. Burner Adjustment • The H-Series BF is equipped with an adjustable burner, allowing you Pilot Assembly • to raise or lower the flames. To adjust the flames, locate the black knob marked 'Hi-Lo', in the centre of the gas control valve (See Figure 16).
PAGE 14
H-Series BF Gas Fireplace Maintenance Gas Control Valve Troubleshooting Power Generator HONEYWELL SV 9500 /SV9600 Troubleshooting Sequence Pilot Adjustment Screw Wall Switch NOTE: Before Troubleshooting, Familiarize Yourself With START The Startup And Checkout Procedure. INSET · TurnGasSupplyoff · Setthermostatto call forheat Inlet Pressure SV9500/SV9600 ispowered (24VACnominal) Manifold Pressure Test Connection NO Figure 17. Sit Nova 820 gas valve. Pilot Burner Adjustment YES 1.
PAGE 15
H-Series BF Gas Fireplace Warranty The Warranty The Companies warrants the Montigo Gas Appliance to be free from defects in materials and workmanship at the time of manufacture. On the Montigo, there is a ten-year warranty on the firebox and its components, a five-year warranty on the main burner and pilot burner, and a one-year warranty on the gas control valve and fibre logs. Glass, plated/painted finishes, and refractory lining are exempt.
PAGE 16
H-Series BF Gas Fireplace Maintenance Notes Spare Parts - H-Series BF H34BF H38BF H42BF NG Gas Valve SIT RGC1006 RGC1006 RGC1006 LP Gas Valve SIT RGC1005 RGC1005 RGC1005 NG & LP Gas Valve AF RGC3016 RGC3016 RGC3016 NG Gas Valve HIS RGC1004 RGC1004 RGC1004 LP Gas Valve HIS RGC1003 RGC1003 RGC1003 NG Pilot SIT RPA020 RPA020 RPA020 LP Pilot SIT RPA021 RPA021 RPA021 NG Pilot SIT for AF RPA030 RPA030 RPA030 LP Pilot SIT for AF RPA031 RPA031 RPA031 NG Pilot PSE for AF RP
PAGE 17
H-Series BF Gas Fireplace Notes Part No.
PAGE 18
XG0150 Canadian Heating Products Inc. Montigo Del Ray Corp.