Installation guide

Page 2
H-Series BF Gas Fireplace
Part No. XG0145
Table Of Contents Introduction
Thank You for choosing a Montigo Gas Fireplace.
About this Fireplace:
The H-Series BF is a replace with a pan-style burner and glowing
embers. This replace is available in two models.
The H34BF is rated for Natural Gas at 18,000 BTU/H (5.28 Kilowatts)
Input or Propane at 18,000 BTU/H (5.28 Kilowatts) Input.
H34BF; Top Vent, Millivolt Pilot.
H34BF-I; Top Vent, Intermittent Pilot (HSI).
H34BF-A; Top Vent, Electronic Ignition (American Flame).
The H38BF is rated for Natural Gas at 26,000 BTU/H (7.62 Kilowatts)
Input or Propane at 26,000 BTU/H (7.62 Kilowatts) Input.
H38BF; Top Vent, Millivolt Pilot.
H38BF-I; Top Vent, Intermittent Pilot (HSI).
H38BF-A; Top Vent, Electronic Ignition (American Flame).
The H42BF is rated for Natural Gas at 34,000 BTU/H (9.97 Kilowatts)
Input or Propane at 28,000 BTU/H (9.97 Kilowatts) Input.
H42BF; Top Vent, Millivolt Pilot.
H42BF-I; Top Vent, Intermittent Pilot (HSI).
H42BF-A; Top Vent, Electronic Ignition (American Flame).
How to use this manual:
This manual covers installation, operation and maintenance. Lighting,
operation and care of this replace can be easily performed by the
homeowner. However, all installation and service work should be
performed by a qualied or licensed installer, plumber, or gastter who
is qualied or licensed by the state, province, region, or governing body
in which the appliance is being installed.
This manual covers all models and unless otherwise specied, the
designation H-Series BF refers to all models. Sections which are
specic to a particular model are marked with a symbol, plus
the appropriate model number.
Warranty and Installation Information:
The Montigo warranty will be voided by, and Montigo disclaims any
responsibility for, the following actions:
Modication of the replace and/or components including Direct-Vent
assembly or glass doors.
Use of any component part not manufactured or approved by Montigo in
combination with this Montigo replace system.
Installation other than as instructed in this manual.
Consult your local Gas Inspection Branch on installation requirements
for factory-built gas replaces. Installation & repairs should be done by
a qualied contractor.
Installations in Canada must conform to the current CAN/CGA B-
149.1 and .2 Gas Installation Code and local regulations. If the optional
air-circulating fan kit is installed, it must be electrically grounded in
accordance with CSA C22.1 Canadian Electrical Code Part 1 and/or
Local Codes.
Installations in the USA must conform to local codes, or in the absence
of local codes to the National Fuel Gas Code, ANSI Z223.1-1988. If the
optional air-circulating fan is installed, it must be grounded in accordance
with local codes or, in the absence of local codes, with the National
Electrical Code, ANSI/NFPA 70-1987.
■
■
■
■
■
■
■
■
■
■
■
■
Introduction .............................................................................. 2
Installation
Installing and Framing the Fireplace .............................. 3
Installing the Gasline ...................................................... 4
The Remote Switch ........................................................
4
Direct Vent Installation ................................................... 4
General Venting Requirements ......................... 4
Terminations ......................................................
5
Converting to Top or Rear Vent model .............. 5
Venting for Top Vent models ..............................
6
Venting for Rear Vent models ............................ 9
Construction around the replace
Facing .............................................................. 11
Mantels and Surrounds ................................... 11
Wiring ......................................................................... 11
Installing Optional Fans................................................ 11
Removing and Installing the Door ................................ 12
Installing the Logset ..................................................... 13
Installing the Horizontal Trim ........................................ 13
Operation .........................................................................14 - 16
Maintenance ....................................................................16 - 17
Warranty ................................................................................. 18
Appendix
A. Termination Locations .............................................. 19
CAUTIONS
Due to its high operating temperatures, the appliance
should be located out of trafc & away from furniture
and draperies.
Children and adults should be alerted to the hazards
of the high surface temperature, which could cause
burns or clothing ignition.
Young children should be carefully supervised when
they are in the same room as the appliance.
Clothing or other ammable materials should not
be placed on or near the appliance.
■
■
■