Instruction manual

Section 4-1-3: Installation of the Vertical External
Roof Mounted Power Vent Module
Refer to AppendixA-PowerVentlocations, to ensure the planned
Vertical Power vent location is acceptable.
See PowerVentmanual for installation instructions.
Section 4-1-2: Venting Components
The following venting components and associated Montigo part
numbers are available for the appliance:
Connection and installation of the vent components should
adheretothefollowingguidelines:
■ Connect all vent sections using a minimum of three sheet
metal screws on the outer pipe ue.
■ Ensure the pipe ends male to female slide in a minimum
of 1 1/2“ of overlap.
■ Ensure all horizontal runs are supported with a minimum
of 3 supports per 10’ of venting.
■ When hanging/ supporting venting, ensure that 1” clearance
is maintained on all sides to any combustible material.
■ Ensure when cutting sections of rigid pipe to maintain
integrity of internal supports.
■ Place the springs, supplied with the pipe kit, between the
outer and inner pipes to keep the pipes separate and avoid
any possible hot spots.
■ Montigo recommends the use of a ex section for the nal
pipe connected directly to the replace offering greater
exibility of installation and absorption of movement.
■ All exterior joints in venting should be sealed with high heat
silicone RV230.
A - Termination PV VEX510-300
B - Rough-in Frame Supplied with PVVEX510-300
C - Flex Sections RLF-1 (12" Section)
RLF-2 (24" Section)
RFL-3 (36" Section)
RFL 4 (48" Section)
D - Rigid Sections REXT-1 (12" m/f Section)
RXT-20 (20" Section)
REXT-2 (24" m/f Section)
REXT-3 (36" m/f Section)
REXT-4 (48" m/f Section)
E - Elbows REL-90MM (m/m 90º Elbow
REL-90FF (f/f 90º Elbow
REL-90FM (f/m 90º Elbow)
REL-45FM (f/m 90º Elbow)
F - Power Cord
Harnesses
EPVH10-10 foot power cord & harness
EPVH20-20 foot power cord & harness
EPVH30-30 foot power cord & harness
EPVH40-40 foot power cord & harness
EPVH50-50 foot power cord & harness
EPVH60-60 foot power cord & harness
EPVH70-70 foot power cord & harness
EPVH80-80 foot power cord & harness
EPVH70-70 foot power cord & harness
EPVH70-70 foot power cord & harness
EPVH80-80 foot power cord & harness
EPVH90-90 foot power cord & harness
EPVH100-100 foot power cord & harness
R520-ST & R620-ST Power Vent Indoor Gas Fireplace
Page 13
XG0773 - 150127
Installation