Installation Guide

ManualsBrandsMonument Grills ManualsGas Grills4-Burner Propane Gas Grill in Stainless with LED Controls, Side Burner and Rotisserie Kit

Liquid Propane Gas Grill

Note to Consumer

Leave this Owner’s Manual in a convenient

place for future reference.

Customer Service Helpline:

For parts ordering, call:

1-888-980-4933

MFG No.: K104BLD2S

UPC No.:8640448000303

Please make sure the cylinder valve

connection device shall properly and safely

mate with the connection device attached to

the inlet of the pressure regulator.

WARNING:

Read this Owner’s manual carefully and be

sure your gas grill is properly assembled,

installed and maintained. Failure to follow

these instructions could result in serious injury

and/or property damage. This gas grill is

intended for outdoor use only and is not

intended to be installed in or on recreational

vehicles or boats.

Note to Installer

Leave this Owner’s Manual with the customer

after delivery and/or installation.

•  Parts

•  Assembly

•  Safety Rules

•  Use and Care

•  Troubleshooting

ASSEMBLY & OPERATING INSTRUCTIONS

C041861

Summary of content (23 pages)

PAGE 1
ASSEMBLY & OPERATING INSTRUCTIONS Liquid Propane Gas Grill • Parts • Assembly • Safety Rules • Use and Care • Troubleshooting ! WARNING: Read this Owner’s manual carefully and be sure your gas grill is properly assembled, installed and maintained. Failure to follow these instructions could result in serious injury and/or property damage. This gas grill is intended for outdoor use only and is not intended to be installed in or on recreational vehicles or boats.
PAGE 2
Grill Warranty Safety Precautions One-Year Full Warranty on Grill If this grill fails due to a defecting material or workmanship within one year from the date of purchase, call 1-888-980-4933 to arrange for free repair (or replacement if repair proves impossible). Combustion by products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.
PAGE 3
Safety Precautions A tank of approximately 12 inches in diameter by 18-1/2 inches high is the maximum size LP gas tank to use. You must use an OPD gas tank which offers an Overfill Prevention Device. This safety feature prevents the tank from being overfilled which can cause malfunction of the LP gas tank, regulator and/or grill. • Have your LP gas tank filled by a reputable propane gas dealer and visually inspected and re-qualified at each filling.
PAGE 4
WARNING A strong gas !smell, or the hissing sound of gas indicates a serious problem with your gas grill or the LP gas tank. Failure to immediately follow the steps listed below could result in a fire or explosion that could cause serious bodily injury, death, or property damage. • Shut off gas supply to the gas grill. • Turn the control knobs to OFF position. • Put out any flame with a proper fire extinguisher. • Open Grill Lid. • Get away from the LP gas tank. • Do not try to fix the problem yourself.
PAGE 5
Contents for Hardware Pack The following table illustrates a breakdown of the hardware pack. It highlights what components are used in the various stages of assembly.
PAGE 6
Model K104BLD2S Parts Diagram 6
PAGE 7
Model K104BLD2S Parts List seq. NO.
PAGE 8
Assembly Instructions Figure 1 Figure 2 8
PAGE 9
4x B Figure 3 Figure 4 9
PAGE 10
4x B Figure 5 Figure 6 10
PAGE 11
4x B Figure 7.1 Figure 7.2 2x B 2x D Figure 8.1 Figure 8.
PAGE 12
Figure 9 2x B 2x D Figure 10.1 Figure 10.2 12 Figure 10.
PAGE 13
1x A Figure 11.1 Figure 11.2 4x A C Figure 12.1 C Figure 12.2 13 Figure 12.
PAGE 14
2x A Figure 13.1 Figure 13.
PAGE 15
Figure 15 Figure 16.1 Figure 16.
PAGE 16
Figure 17.1 Figure 17.2 Figure 18.2 Figure 18.
PAGE 17
Connecting LP Gas Tank to LP Grill 1. Place foot ring of 20 lb tank into the hole in bottom panel. Make sure the tank valve is in OFF position. (Fig.20). 2. Check the tank valve to ensure it has proper external mating threads to fit the hose and regulator assembly provided. 3. Make sure all burner valves are in OFF position. 4. Inspect the valve connection port and regulator assembly. Look for damage or debris. Remove any debris. Inspect hose for damage. Never use damaged or plugged equipment. 5.
PAGE 18
Checking for LP gas leaks Never test for leaks with a flame. Prior to first use, at the beginning of each season, or every time your LP gas tank is changed, you must check for gas leaks. 1. Make a 50/50 (soap/water) mild soap solution. 2. Turn the control knobs to full OFF position; then turn gas ON at supply tank. 3. Apply the soap solution with a clean brush to all gas connections. See below. If growing bubbles appear in the solution the connections are not properly sealed.
PAGE 19
! WARNING Never lean over the grill cooking area while lighting your gas grill. Keep your face and body a safe distance (at least 18 inches) from the cooking grid surface when lighting your grill by match. Manually Lighting Your Grill by Match 1. Take the manual lighting stick 2. Insert a match into the lighting stick. 3. Follow steps 1 through 5 of the Basic Lighting Procedure. 4. Light the match and extend the lighting stick to cooking grid surface. 5.
PAGE 20
Cleaning and Maintenance Cleaning Exterior Stainless Steel Surfaces To ensure a proper working unit the following proper care and maintenance is suggested. Cleaning Cooking Grids We suggest you wash your cooking grids in a mild soap and warm water solution. You can use a wash cloth or soft brush to clean your cooking grids. Cleaning Heat diffusers Periodically you should wash the heat diffusers in a soap and warm water solution. Use a soft brush to remove stubborn burnt-on cooking residue.
PAGE 21
Regardless of which burner cleaning procedure you use, we recommend you also complete the following steps to help prolong burner life. 1. Use a fiber pad or nylon brush to clean the entire outer surface of each burner until free of food residue and dirt. 3. Inspect each burner for damage (cracks or holes) and if such damage is found, order and install a new burner. After installation check to ensure that gas valve orifices are correctly placed inside the ends of the burner tubes.
PAGE 22
Cooking Instructions ! WARNING Do not leave the grill unattended. Your grill will get very hot. Never lean over the cooking area while using your grill. Do not touch cooking surfaces, grill housing. Grill Lid or any other grill parts while the grill is in operation, or until the grill has cooled down after use. Failure to comply with these instructions may result in serious bodily injury.
PAGE 23
Grill Cooking Chart FOOD Weight or thickness Temperature Vegetables NA Medium Slice or chop vegetables and dot with butter or 8 to 20 minutes margarine. Wrap tightly in heavy duty foil. Grill turning occassionally. Potatoes Whole Medium 40 to 60 minutes Meat/Steaks 1/2 to 3/4 inches High-Medium Time Special instructions and tips Wrap individually in heavy duty foil. Cook rotating occassionally. Pre heat grill for 15-20 minutes then sear steaks on each side for two minutes.