Operating Guide

OperatingInstructionsandOwner’sManualMr. Heater | Portable Radiant Golf Cart Heater

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

TROUBLESHOOTING

SYMPTOM

• Spark electrode does not produce spark.

CAUSE

REMEDY

1. Spark electrode broken. 1. Replace ODS (Oxygen Depletion Sensor).

2. Igniter wire may not be attached to spark electrode. 2. Attach igniter wire.

3. Igniter wire damaged. 3. Replace igniter wire.

4. Piezo igniter is defective. 4. Replace gas valve assembly.

REMEDY

SYMPTOM

• Heater keeps shutting “OFF” during normal operation.

CAUSE

1. Pilot is blocked. 1. Clean pilot. See MAINTENANCE section.

3. Tip over switch activated from bumping heater. 3. Re-light.

REMEDY

SYMPTOM

• Spark electrode produces spark but pilot does not light.

CAUSE

1. No gas to heater. 1. Connect hose to heater and turn on valve at remote

cylinder.

2. Pilot is blocked with foreign debris. 2. Clean pilot. See MAINTENANCE section.

REMEDY

SYMPTOM

• Pilot ame does not stay lit when knob is released.

CAUSE

1. Improper pilot lighting. 1. Make sure that the control knob is completely depressed

inthe“PILOT”positionandheldlongenoughtopurge

air from lines and to heat up thermocouple once the pilot

flame appears.

2. Pilot flame not surrounding thermocouple. 2. Clean pilot, see MAINTENANCE.

3. Pilot Assembly is defective. 3. Replace Pilot Assembly.

4. Tip switch wires are disconnected. 4. Connect tip switch wires. (check off switch and off switch

wiring).

SYMPTOM

• Main burner does not ignite.

CAUSE

REMEDY

1. Main burner orfice is blocked. 1. Clean burner - see Maintenance.