OPERATING INSTRUCTIONS AND OWNER’S MANUAL MR. HEATER (with thermostat) TS170FAV HEATSTAR MODEL MODEL MH170FAVT PA170FAVT READ INSTRUCTIONS CAREFULLY: Read and follow all instructions. Place instructions in a safe place for future reference. Do not allow anyone who has not read these instructions to assemble, light, adjust or operate the heater. HS170FAVT (without thermostat) For model serial numbers, see page E10.
WARNING: YOUR SAFETY IS IMPORTANT TO WARNING: NOT FOR HOME OR RECREATIONAL YOU AND TO OTHERS, SO PLEASE READ THESE INSTRUCTIONS BEFORE YOU OPERATE THIS HEATER. VEHICLE USE WARNING: GENERAL HAZARD WARNING: FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN, ASPHYXIATION, CARBON MONOXIDE POISONING, AND/OR ELECTRICAL SHOCK.
OPERATING PRECAUTIONS SAFETY PRECAUTIONS 1. This is a propane, direct-fired, forced air heater. It’s intended use is primarily temporary heating of buildings under construction, alteration or repair. 2. 3. 4. Propane is heavier than air. If propane leaks from a connection or fitting, it sinks to the floor, collecting there with the surrounding air, forming a potentially explosive mixture. Obviously, propane leaks should be avoided, so set up the propane supply with utmost care.
ODOR FADE WARNING WARNING Asphyxiation Hazard • Do not use this heater for heating human living quarters. • Do not use in unventilated areas. • The flow of combustion and ventilation air must not be obstructed. • Proper ventilation air must be provided to support the combustion air requirements of the heater being used. • Refer to the specification section of the heater’s manual, heater dataplate, or contact the Factory to determine combustion air ventilation requirements of the heater.
OPERATING INSTRUCTIONS MAINTENANCE AND STORAGE 1. PREPARING FOR OPERATION 1. 2. 3. 4. 5. 6. 7. 8. Check the heater for possible shipping damage. If any is found, immediately notify the factory. Follow all of the “Precautions”. Connect the POL fitting of hose and regulator assembly to the propane cylinder by rotating the POL nut counterclockwise into the propane cylinder’s valve outlet and securely tighten with a wrench. Connect the hose to the heater by rotating the hose fitting clockwise.
SIZE AND CAPACITY OF PROPANE CYLINDERS WARNING: When using a thermostat controlled heater, its exit area should be protected from personnel and warnings posted of sudden startup. The charts below show the approximate size of the cylinder required for these heaters. To use the chart: 1. 2. 3. Select the lowest air temperature expected (at the bottom of the chart). Move straight up to time of operation desired (left side of the chart). Read the cylinder size required.
Model #170FAVT (WITH THERMOSTAT) PARTS LIST 36 35 Item Part No. 1 21732 1 21737 2 22249 3 22250 4 21146 5 26168 6 23038 7 27095 8 27094 9 26010 10 26074 11 22251 12 22252 13 26152 * 26152-20 14 26257 15 26433 16 26122 17 26101 18 28775 19 28777 20 28776 21 22253 22 28774 23 23037 Description Qty.
Model #170FAV (WITHOUT THERMOSTAT) WIRING DIAGRAM WIRING DIAGRAMS CONNECTION DIAGRAM SCHEMATIC DIAGRAM B HIGH LIMIT SWITCH X 2 VAC INPUT MOTOR TEMP MOTOR THERMOCOUPLE B HV TRANS Y Y TO WIRE B MOTOR VAC INPUT HV TRANS G LINE CORD GND SCREW B 115V 60HZ SPARK PLUG O** GND SCREW HIGH LIMIT SWITCH X2 MOTOR TO WIRE TEMP W SPARK PLUG IGNITION CONTROL TO WIRE IGNITION CONTROL TO JUNCTION TEMP MOTOR G VAC INPUT W COLOR CODE B BLACK W WHITE G GREEN LEGEND R RED Y YEL O ORG NOTE: FEMAL
Model #170FAV (WITHOUT THERMOSTAT) PARTS LIST REF.
OPERATING INSTRUCTIONS AND OWNER’S MANUAL MR. HEATER (with thermostat) TS170FAV (without thermostat) Model MH170FAVT HS170FAVT PA170FAVT Starting Serial Number LN-2701700001001 LN-1701700001001 LN-2220630001001 HEATSTAR MODEL MODEL MH170FAVT READ INSTRUCTIONS CAREFULLY: Read and follow all instructions. Place instructions in a safe place for future reference. Do not allow anyone who has not read these instructions to assemble, light, adjust or operate the heater.
GUIDE D’UTILISATION ET INSTRUCTIONS DE FONCTIONNEMENT MR. HEATER (avec le thermostat) TS170FAV HEATSTAR MODÈLE MODÈLE MH170FAVT PA170FAVT LISEZ SOIGNEUSEMENT LES INSTRUCTIONS : Lisez et observez toutes les instructions. Conservez les instructions en sécurité pour vous y référer ultérieurement. Interdisez à quiconque n’ayant pas lu les présentes instructions d’assembler, d’allumer, de régler ou de faire fonctionner cet appareil de chauffage.
AVERTISSEMENT :NON CONÇU POUR UNE AVERTISSEMENT :VOTRE SÉCURITÉ PERSON- UTILISATION DANS LA MAISON OU UN VÉHICULE RÉCRÉATIF NELLE ÉTANT IMPORTANTE POUR TOUS, VEUILLEZ LIRE LES INSTRUCTIONS AVANT D’UTILISER CET APPAREIL DE CHAUFFAGE. AVERTISSEMENT : DANGER D’INCENDIE, D’EXPLOSION ET D’INHALATION CONSERVEZ LES MATÉRIAUX COMBUSTIBLES TELS QUE LES MATÉRIAUX DE CONSTRUCTION, LE PAPIER ET LE CARTON À UNE DISTANCE SÉCURITAIRE DE L’APPAREIL DE CHAUFFAGE COMME LE RECOMMANDENT LES INSTRUCTIONS.
PRÉCAUTIONS LIÉES AU FONCTIONNEMENT PRÉCAUTIONS LIÉES À LA SÉCURITÉ Cet appareil de chauffage à air pulsé et à feu direct fonctionne au gaz propane. Il est destiné principalement à chauffer temporairement des édifices en construction, en rénovation ou en réparation. 1. Vérifiez attentivement si l’appareil de chauffage a subi des dommages. NE FAITES PAS fonctionner un appareil endommagé. 2. NE MODIFIEZ PAS l’appareil de chauffage et ne le faites pas fonctionner s’il n’est plus dans son état original. 3.
AVERTISSEMENT RELATIF AUX SUBSTANCES ODORANTES AVERTISSEMENT Risque d’asphyxie • Cet appareil ne doit pas être utilisé pour le chauffage de locaux où demeurent des gens. • Ne l’utilisez pas dans des endroits non aérés. • Le débit de chaleur et d’air de ventilation ne doit pas être obstrué. • Le processus de combustion de cet appareil exige un apport adéquat en air de ventilation.
INSTRUCTIONS DE FONCTIONNEMENT REDÉMARRAGE APRÈS UN ARRÊT D’URGENCE AVANT LE FONCTIONNEMENT 1. Vérifiez soigneusement tout dommage qu’aurait pu subir l’appareil de chauffage pendant l’expédition. Si vous en découvrez, avertissez immédiatement le fabricant. 2. Respectez toutes les « Précautions ». 3. Branchez le raccord POL (filet à gauche) du tuyau et du régulateur en tournant l’écrou POL en sens anti-horaire dans la sortie du robinet de la bonbonne de gaz propane, puis serrez-le avec une clé. 4.
DIMENSIONS ET CONTENANCES DES BONBONNES DE GAZ PROPANE AVERTISSEMENT : Lors de l’utilisation d’un appareil de chauffage contrôlé par thermostat, sa zone d’échappement doit être protégée et des avertissements de démarrage soudain doivent être affichés à l’intention du personnel. Les tableaux ci-dessous présentent la dimension approximative de la bonbonne requise pour ces appareils de chauffage. Pour utiliser le tableau : 1. 2. 3.
Modèle nº 170FAVT (avec la thermostat) LISTE DES PIÈCES 36 35 Article N° ART.
SCHÉMA DE CÂBLAGE (sans thermostat) Modèle nº 170 FAV WIRING DIAGRAMS CONNECTION DIAGRAM SCHEMATIC DIAGRAM B HIGH LIMIT SWITCH X 2 VAC INPUT MOTOR TEMP MOTOR THERMOCOUPLE B HV TRANS Y Y TO WIRE B MOTOR VAC INPUT HV TRANS G LINE CORD GND SCREW B 115V 60HZ SPARK PLUG O** GND SCREW HIGH LIMIT SWITCH X2 MOTOR TO WIRE TEMP W SPARK PLUG IGNITION CONTROL TO WIRE IGNITION CONTROL TO JUNCTION TEMP MOTOR G VAC INPUT W COLOR CODE B BLACK W WHITE G GREEN R RED Y YEL O ORG LEGEND NOTE: F
Modèle nº 170FAV (sans thermostat) LISTE DES PIÈCES RÉF. Nº 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 20 21 22 23 24 25 26 27 28 29 N° ART.
GUIDE D’UTILISATION ET INSTRUCTIONS DE FONCTIONNEMENT MR. HEATER (avec le thermostat) TS170FAV (sans thermostat) HEATSTAR MODÈLE MODÈLE MH170FAVT LISEZ SOIGNEUSEMENT LES INSTRUCTIONS : Lisez et observez toutes les instructions. Conservez les instructions en sécurité pour vous y référer ultérieurement. Interdisez à quiconque n’ayant pas lu les présentes instructions d’assembler, d’allumer, de régler ou de faire fonctionner cet appareil de chauffage.