PARTS AND OPERATION MANUAL OPERATION AND PARTS MANUAL WHISPERWATTTM SERIES MODEL DCA-15SPX4 60 Hz GENERATOR Revision #0(02/17/09) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
PROPOSITION 65 WARNING Diesel engine exhaust and some of PAGE 2 — DCA-15SPX4— OPERATION MANUAL — REV.
NOTE PAGE 1 DCA-15SPX4— OPERATION MANUAL — REV.
TABLE OF CONTENTS MQ POWER DCA-15SPX4 WHISPER WATTTM GENERATOR WHISPERW California Proposition 65 Warning ..................................... 2 Table Of Contents ............................................................. 4 Parts Ordering Procedures ............................................... 5 Specifications ................................................................... 6 Dimensions (Top, Side, Front) .......................................... 7 Safety Message Alert Symbols ...................
www.mqpower.com PARTS ORDERING PROCEDURES Ordering parts has never been easier! Choose from three easy options: Effective: Order via Internet (Dealers Only): If you have an MQ Account, to obtain a Username and Password, E-mail us at: parts@multiquip.com. Order parts on-line using Multiquip’s SmartEquip website! ■ View Parts Diagrams ■ Order Parts To obtain an MQ Account, contact your Use the internet and qualify for a 5% Discount on Standard orders for all orders which include Goto www.multiquip.
DCA-15SPX4 — SPECIFICATIONS Table 1. Generator Specifications Model DCA-15SPX4 Type Revolving field, self ventilated, open protected type synchronous generator P ha s e Single Phase 3-Wire Standby Output 1 6 .5 K W Prime Output 15 KW Voltage 240V/120 Frequency 60 Hz Speed 1800 r pm Power Factor 1.0 Aux. AC Power (GFCI) 2.4 KW @120 VAC Single Phase, 60 Hz Aux. AC Power (L5-30R) 3.6 KW@120 VAC Single Phase, 60 Hz Aux. AC Power (L6-30R ) 7.2 KW@240 VAC Single Phase, 60 Hz Aux.
DCA-15SPX4 — DIMENSIONS (TOP, SIDE AND FRONT) A TOP VIEW B C Figure 1. Dimensions 15 MQPOWER WHISPERWATT SIDE VIEW D FRONT VIEW TABLE 3. DIMENSIONS E U N V Denyo F Reference Letter Dimension ft. (mm.) A 21.65 in. (550 mm.) B 19.29 in. (490 mm.) C 24.21 in. (615 mm.) D 55.70 in. (1,415 mm.) E 35.51 in. 902 mm.) F 25.60 in. (650 mm.) 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others. NOTE This Owner's Manual has been developed to provide complete instructions for the safe and efficient operation of the MQ Power Model DCA-15SPX4 Whisperwatt™ Generator.
DCA-15SPX4 — SAFETY MESSAGE ALERT SYMBOLS WARNING - ROTATING PARTS NEVER operate equipment with covers, or guards removed. Keep fingers, hands, hair and clothing away from all moving parts to prevent injury. CAUTION - ACCIDENTAL STARTING ALWAYS place the engine ON/OFF switch (MPEC) in the OFF/RESET position when the generator is not in use. CAUTION - OVER-SPEED CONDITIONS NEVER tamper with the factory settings of the engine governor or settings.
DCA-15SPX4 — RULES FOR SAFE OPERATION DANGER - READ THIS MANUAL! Failure to follow instructions in this manual may lead to serious injury or even DEATH! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only. The following safety guidelines should always be used when operating the DCA-15SPX4 Whisperwatt™ AC Generator. ■ NEVER use accessories or attachments, which are not recommended by Multiquip for this equipment.
DCA-15SPX4 — RULES FOR SAFE OPERATION ■ ALWAYS be sure the operator is familiar with proper safety precautions and operation techniques before using generators. ■ NEVER leave the generator unattended, turn off engine when unattended. ■ Unauthorized equipment modifications will void all warranties. ■ ALWAYS ensure generator is on level ground before use. ■ DO NOT place hands or fingers inside generators engine compartment when engine is running.
DCA-15SPX4 — RULES FOR SAFE OPERATION WARNING - BURN HAZARDS To prevent burns, DO NOT touch or open any of the below mentioned components while the engine is running or immediately after operations. Always allow sufficient time for the engine and generator to cool before performing maintenance.
DCA-15SPX4 — RULES FOR SAFE OPERATION Using a generator indoors CAN KILL YOU IN MINUTES. Generator exhaust contains carbon monoxide. This is a posion you cannot see or smell 20A 2900 120 V OFF GA-2.9R 120V 20A 2900 120V ON OFF AC CIRCUIT BREAKER 20A 2900 120 V GA-2.9R 22A NEVER grab or touch a live power cord with wet hands, the possibility exist of electrical shock, electrocution, and even death! DANGER 120 V ON GA-2.
DCA-15SPX4 — RULES FOR SAFE OPERATION If your generator is trailer mounted, please read the towing and safety requirements listed below. Towing and Transporting Safety To reduce the possibility of an accident while transporting the generator on public roads, always make sure the trailer that supports the generator and the towing vehicle are in good operating condition and both units are mechanically sound.
NOTE PAGE 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — INSTALLATION Figure 2. Typical Generator Grounding Application PAGE 16 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — INSTALLATION Outdoor Installation Generator Grounding Install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around. Also install the generator in a manner so that the exhaust will not be discharged in the direction of nearby homes. To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground.
DCA-15SPX4 — GENERAL INFORMATION DCA-15SPX4 Whisperwatt™ Series Familiarization Generator The MQ Power Model DCA-15SPX4 is a 15 kW generator (Figure 3) that is designed as a high quality portable (requires a trailer for transport) power source for telecom sites, lighting facilities, power tools, submersible pumps and other industrial and construction machinery.
DCA-15SPX4 — MAJOR COMPONENTS Table 4. Generator Major Components ITEM NO. Figure 3. Major Components DESCRIPTION 1 Air Filter Assembly 2 Muffler Assembly 3 Engine and Radiator Assembly 4 Generator Assembly 5 Battery Assembly 6 Fuel Tank Assembly 7 Generator Control Panel Assembly 8 Output Receptacle Assembly 9 Output Terminal Assembly DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — GENERATOR CONTROL PANEL 4 1 2 3 WATER TEMP. HZ 19 18 17 16 A OIL PRESS. BATT. LOW LEVEL PREHEAT LAMP V INCREASE DECREASE 5 6 7 8 U N 9 V 15 14 13 12 11 10 Figure 4. Generator Control Panel PAGE 20 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — GENERATOR CONTROL PANEL The definitions below describe the controls and functions of the Generator Control Panel (Figure 4). 1. Frequency Meter – Indicates the output frequency in hertz (Hz). Normally 60 Hz. 2. AC Ammeter – Indicates the amount of current the load is drawing from the generator per leg selected by the ammeter phase-selector switch. 8. AC Voltmeter – Indicates the output voltage present at the U,O, and V Output Terminal Lugs. 9. 3. 4.
DCA-15SPX4 — OUTPUT TERMINAL PANEL FAMILIARIZATION Output Terminal Panel Output Terminal Familiarization The Output Terminal Panel (Figure 5) shown below is located The “Output Terminal Panel ” (Figure 5) is provided with the on the right-hand side (left from control panel) of the generator. following: Lift up on the cover to gain access to receptacles and terminal ■ CS6369 receptacle 125/240V@ 50 amps lugs.
DCA-15SPX4 — OUTPUT TERMINAL PANEL FAMILIARIZATION L5-30R Twist Lock 120 VAC Receptacle 120 VAC GFCI Receptacle This120 VAC, 20 amp GFCI (Duplex Nema 5-20R) receptacle There is one L5-30R, 120 VAC 30 amp auxilliary twist-lock can be used anytime the generator is in operation. Remember receptacle (Figure 8) provided on the output terminal panel. the load output (current) of the GFCI receptacle is dependent on the load requirements of the U, N, and V output terminal lugs.
DCA-15SPX4 — OUTPUT TERMINAL PANEL FAMILIARIZATION Connecting Loads Loads can be connected to the generator by the Ouput Terminal Lugs or the convenience receptacles (Figure 11). Make sure to read the operation manual before attempting to connect a load to the generator. To protect the output terminals from overload, a 3-pole, 70A main circuit breaker is provided. Make sure to switch ALL circuit breakers to the OFF position prior to starting the engine. Figure 11.
DCA-15SPX4 — LOAD APPLICATION/MAXIMUM AMPERAGE Single Phase Load Always be sure to check the nameplate on the generator and equipment to insure the wattage, amperage, frequency, and voltage requirements are satisfactorily supplied by the generator for operating the equipment. Generally, the wattage listed on the nameplate of the equipment is its rated output.
DCA-15SPX4 — GAUGE READING/ TERMINAL PANEL CONNECTIONS UNV Terminal Output Voltages 240/120V output voltages can be obtained using the Output Terminal Lugs. Use the voltage regulator (VR) to either increase or decrease the selected voltage. Ammeter Gauge. The ammeter gauge (Figure 15) on the generator control panel has been provided to help observe how much current (amps) is being supplied to the load from the output terminal lugs, GFCI receptacle or any auxulliary receptacles if installed.
DCA-15SPX4 — SETUP Fuel Check Circuit Breakers To protect the generator from an overload, a 3-pole, 70 amp, main circuit breaker is provided to protect the U,N,and V OUTPUT TERMINALs from overload.. In addition a two-pole, 50 amp CS6369 circuit breaker is provided to protect the CS6369 receptacle from overload. Make sure to switch ALL circuit breakers to the OFF position prior to starting the engine. DANGER - EXPLOSION/FIRE HAZARDS Fuel spillage on a hot engine can cause a fire or explosion.
DCA-15SPX4 — SETUP Refueling Procedure: NOTE WARNING - RESPIRATORY HAZARDS Diesel fuel and its vapors are dangerous to your health and the surrounding environment. Avoid skin contact and/or inhaling fumes. 1. Level Tanks – Make sure fuel cells are level with the ground. Failure to do so will cause fuel to spill from the tank before reaching full capacity (Figure 19). 3. If generator is equipped with an environmental fuel tank, reference Figures 21 and 22.
DCA-15SPX4 — SETUP Coolant (Antifreeze/Summer Coolant/Water) KUBOTA recommends antifreeze/summer coolant for use in their engines, which can be purchased in concentrate (and mixed with 50% demineralized water) or pre-diluted. See the KUBOTA Engine Owner's Manual for further details. Cleaning the Radiator The engine may overheat if the radiator fins become overloaded with dust or debris. Periodically clean the radiator fins with compressed air.
DCA-15SPX4 — SETUP When connecting battery do the following: Battery This unit is of negative ground DO NOT connect in reverse. 1. NEVER connect the battery cables to the battery terminals when the ignition switch is in the ON position Always maintain battery fluid level between the specified marks. Battery life will be shortened, if the fluid level are not 2. Place a small amount of battery terminal treatment properly maintained. Add only distilled water when compound around both battery terminals.
DCA-15SPX4 — GENERATOR START-UP PROCEDURE Before Starting CAUTION - LETHAL EXHAUST HAZARD The engine's exhaust contains harmful emissions. ALWAYS have adequate ventilation when operating. Direct exhaust away from nearby personnel. Start-up Procedure 1. Set the Speed Control Switch to the START/IDLE position (Figure 27). WARNING - STARTING THE GENERATOR NEVER! manually start the engine with the main, GFCI or auxiliary circuit breakers in the ON (closed) position. Figure 27.
DCA-15SPX4 — GENERATOR START-UP PROCEDURE 5. Set the Speed Control Switch to the RUN position (Figure 30). 8. Place the main, GFCI, and aux. circuit breakers in the ON position (Figure 34). Figure 30. Speed Control Switch (RUN) 6. The ammeter (Figure 31) will indicate zero amps with no load applied. When a load is applied, the ammeter will indicate the amount of current that the load is drawing from the generator. Figure 34. Main, GFCI, and Aux. Circuit Breakers (ON) 9.
DCA-15SPX4 — GENERATOR SHUT-DOWN PROCEDURES WARNING - SHUTTING DOWN THE GENERATOR NEVER stop the engine suddenly except in an emergency. Normal Shutdown Procedure To shutdown the generator use the following procedure: Emergency Shutdown Procedure 1. Turn the ignition key counter-clockwise to the STOP position. When the engine has stopped, remove key. Place key in a safe place where it will not be lost. 2. Place both the main, GFCI, and aux. circuit breakers as shown in Figure 25 to the OFF position. 1.
DCA-15SPX4 — MAINTENANCE 10 Hrs DAILY TABLE 11.
DCA-15SPX4 — MAINTENANCE Flushing Out Radiator and Replacing Coolant Air Removal If air enters the fuel injection system of a diesel engine, Open both cocks located at the crankcase side and at the lower part of the radiator and drain coolant. Open the starting becomes impossible. After running out of fuel, or radiator cap while draining. Remove the overflow tank after disassembling the fuel system, bleed the system and drain. according to the following procedure.
DCA-15SPX4 — MAINTENANCE Jacket Water Heater and Internal Battery Charger 120 VAC Input Receptacles (OPTIONAL) This generator can be optionally equipped with two 120 VAC, 20 amp input receptacles located on the output terminal panel. The purpose of these receptacles is to provide power via commercial power to the jacket water heater and internal battery charger. These receptacles will ONLY function when commercial power has been supplied to them (Figure 36).
DCA-15SPX4 — TRAILER MAINTENANCE Brakes Trailer brakes should be inspected the first 200 miles of operation. This will allow the brake shoes and drums to seat properly. After the first 200 mile interval, inspect the brakes every 3,000 miles. If driving over rough terrain, inspect the brakes more frequently. Figure 37 displays the major hydraulic surge brake components that will require inspection and maintenance.
DCA-15SPX4 — TRAILER MAINTENANCE Tires/Wheels/Lug Nuts Tires and wheels are a very important and critical components of the trailer. When specifying or replacing the trailer wheels it is important the wheels, tires, and axle are properly matched. CAUTION - EYESIGHT HAZARD Suspension The leaf suspension springs and associated components (Figure 38) should be visually inspected every 6,000 miles for signs of excessive wear, elongation of bolt holes, and loosening of fasteners.
DCA-15SPX4 — TRAILER MAINTENANCE Lug Nut Torque Requirements It is extremely important to apply and maintain proper wheel mounting torque on the trailer. Be sure to use only the fasteners matched to the cone angle of the wheel. Proper procedure for attachment of the wheels is as follows: 1. Start all wheel lug nuts by hand. 2. Torque all lug nuts in sequence (see Figure 39). DO NOT torque the wheel lug nuts all the way down. Tighten each lug nut in 3 separate passes as defined by Table 15. 3.
DCA-15SPX4 — GENERATOR WIRING DIAGRAM Figure 40. Generator Wiring Diagram PAGE 40 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — ENGINE WIRING DIAGRAM Figure 41. Engine Wiring Diagram 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — TROUBLESHOOTING (ENGINE) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, use Table 16 shown below for diagnosis of the engine. If the problem cannot be remedied, consult our company's business office or service plant. TABLE 16. ENGINE TROUBLESHOOTING SYMPTOM Engine does not star t. POSSIBLE PROBLEM SOLUTION No fuel? Replenish fuel. Air in the fuel system? Bleed system.
DCA-15SPX4 — TROUBLESHOOTING (ENGINE) TABLE 16. ENGINE TROUBLESHOOTING (CONTINUED) SYMPTOM POSSIBLE PROBLEM Engine revolution is not smooth. Either white or blue exhaust gas is observed. Either black or dark gray exhaust gas is observed. Deficient output. SOLUTION Fuel filter clogged or dir ty? Clean or change. Air cleaner clogged? Clean or change. Fuel leak due to loose injection pipe retaining nut? Tighten nut. Injection pump malfunctioning? Repair or replace.
DCA-15SPX4 — TROUBLESHOOTING (GENERATOR) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, use Table 17 shown below for diagnosis of the generator. If the problem cannot be remedied, consult our company's business office or service plant. TABLE 17.
DCA-10SPX4 — TROUBLESHOOTING (PRE-HEAT LAMP CODES) When the Emergency/Malfunction Diagnosis Function has been activated, it stops the engine and flashes the pre-heat lamp to indicate the cause of the malfunction with its flashing patterns. The flashing patterns and countermeasures are shown below. The patterns consist of combinations of one or more long flashes and one or more short flashes. TABLE 18.
DCA-15SPX4 — EXPLANATION OF CODE IN REMARKS COLUMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are any questions. The contents and part numbers listed in the parts section are subject to change without notice. Multiquip does not guarantee the availibility of the parts listed. PART NO. PART NAME QTY. 12345 BOLT ....................... 1 .... WASHER, 1/4 IN. ...........
DCA-15SPX4 — SUGGESTED SPARE PARTS DCA-15SPX4 WHISPER WATTGENERATOR W/KUBOTA V2203-M DIESEL ENGINE 1 TO 3 UNITS Qty. P/N Description 1 ......... B0311500603 ..... HOSE, RADIATOR UPPER 1 ......... B0311500703 ..... HOSE, RADIATOR LOWER 1 ......... 0602011079 ....... RADIATOR CAP 1 ......... 0810105800 ....... FUEL CAP 1 ......... 1584139010 ....... SWITCH, OIL 1 ......... 1949883040 ....... SWITCH, THEROMETER 1 ......... 0810105900 ....... FILTER, FUEL 6 ......... 1522143172 .......
DCA-15SPX4 — GENERATOR ASSY. PAGE 48 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — GENERATOR ASSY. GENERATOR ASSY. NO. 1 *1-21-1 * 1-3 * 1-4 * 1-5 * 1-6 * 1-7 * 1-8 * 1-9 * 1-10 * 1-11 * 2 3 5 5-1 6 7 8 9 10 11 12 13 14 16 17 18 19 20 21 PART NO.
DCA-15SPX4 — CONTROL PANEL ASSY. CONTROL PANEL ASSY. PAGE 50 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — CONTROL PANEL ASSY. CONTROL PANEL ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 11-1 12 13 13A 14 14A 15 15-1 15-1A 16 17 18 19 20 21 22 23 24 25 PART NO. B0224005103 0601800455 0601805746 0601800281 0601840073 0601840121 0601808803 0601808807 0601808808 0601808804 B0262600804 0222100115 0021806015 1628663602 3741055150 0601810523 0601810830 0601800682 0027403010 0207003000 0605010060 0027103008 0021806030 0601808806 0021005080 0601801122 0027105015 0601842304 0027104010 0601820038 PART NAME QTY.
DCA-15SPX4 — CONTROL PANEL ASSY. CONTROL PANEL ASSY. PAGE 52 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — CONTROL PANEL ASSY. CONTROL PANEL ASSY. NO. 26 27 28 29 30 31 32 32A 32B 33 33A 33B 33C 34 35 36 37 38 39 40 41 42 43 PART NO. 0027104020 0601820663 0027105015 0601815759 0027104020 1G38560601 0021005050 0040005000 0041205000 B0214600404 0601806642 0601806645 B0551002104 0027105015 RP42153731 6888153542 0027105015 0601806640 0601830771 B0214002903 0017108020 0601820891 0027104015 PART NAME QTY.
DCA-15SPX4 — OUTPUT TERMINAL ASSY. OUTPUT TERMINAL ASSY. PAGE 54 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — OUTPUT TERMINAL ASSY. OUTPUT TERMINAL ASSY. NO. 1 2 3 4 5 5A 6 7 8 9 10 11 11-1 12 13 14 15 16 17 18 19 20 21 21A PART NO. B0231700004 7811861004 0801830604 0040008000 0041208000 0041408000 0039508000 0039508000 7831860104 0016906020 0601815109 7671865403 7671865804 0016906020 0821800014 0805088004 0207006000 0016906015 0601812598 0601811035 0601811033 0601812565 0027104012 0207004000 PART NAME QTY.
DCA-15SPX4 — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY. PAGE 56 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY. NO. 1 1A 1-1 2 3 3A 4 5 6 6-1 7 8 9 10 11 12 13 14 15 16 17 18 18A 19 20 21 22 23 24 25 PART NO.
DCA-15SPX4 — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY. PAGE 58 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY. NO. 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 47 48 49 50 50A PART NO.
DCA-15SPX4 — BATTERY ASSY. BATTERY ASSY. PAGE 60 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — BATTERY ASSY. BATTERY ASSY. NO. 1 2 3 4 5 6 7 8 8-1 8-1A 9 PART NO. 0165308026 B1345200114 0805002904 0037808000 0040008000 0041208000 0845040414 B1344200203 B0491700004 0314200350 0017108020 PART NAME QTY. REMARKS BATTERY .................................................. 1 ......... 80D26R BATTERY BAND 1 BATTERY BOLT 2 WING NUT 2 WASHER, LOCK 2 WASHER, FLAT 2 TERMINAL CAP 1 BATTERY FRAME 1 LINING 1 RUBBER SEAL 1 HEX HEAD BOLT 3 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 —MUFFLER ASSY. MUFFLER ASSY. PAGE 62 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 —MUFFLER ASSY. MUFFLER ASSY. NO. 1 2 3 4 5 6 7 7A 7B PART NO. B1331101113 0016908020 B1334000703 1732612231 0207008000 0602325008 0341510040 0042410000 0207110000 PART NAME QTY. REMARKS MUFFLER 1 HEX HEAD BOLT 5 EXHAUST PIPE 1 GASKET ................................................... 1 ......... REPLACES P/N 0602320153 HEX NUT 4 PIPE BAND 4 HEX HEAD BOLT 2 WASHER, FLAT 2 HEX NUT 2 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — FUEL TANK ASSY. FUEL TANK ASSY. PAGE 64 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — FUEL TANK ASSY. FUEL TANK ASSY. NO. 1 1-1 * 1-2 * 2 3 4 5 6 7 8 9 10 11 12 13 14 15 15A 17 19 20 21 22 23 24 25 26 27 PART NO. B0364000703 0810105800 0810105900 B0364300503 0017108020 0222100300 8435523024 6365300504 0017108020 0037908000 7812014003 0802011104 0150000018 0016906015 0199901400 0605515094 1522143016 1522143172 0017108035 0603325013 0602022219 0199900220 0199900340 0199700250 0605515094 0605515192 B9312400004 B9311400104 PART NAME QTY. REMARKS FUEL TANK .........................
DCA-15SPX4 — ENCLOSURE ASSY. ENCLOSURE ASSY. PAGE 66 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — ENCLOSURE ASSY. ENCLOSURE ASSY. NO. 1 3 4 5 5A 5B 5C 6 7 8 8A 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 23A 24 25 25A PART NO.
DCA-15SPX4 — ENCLOSURE ASSY. ENCLOSURE ASSY. PAGE 68 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — ENCLOSURE ASSY. ENCLOSURE ASSY. NO. 26 27 28 29 29A 30 31 31A 32 33 33A 34 34A 35 36 37 38 39A 40 41 42 44 45 46 47 48 48A 49 50 51 52 53 PART NO.
DCA-15SPX4 —RUBBER SEAL ASSY. RUBBER SEALS ASSY. PAGE 70 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 —RUBBER SEAL ASSY. RUBBER SEALS ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 PART NO. 0229200650 0221700620 0221701035 0229400675 0229401040 0229200590 0229200255 0229400250 0229400545 0227500380 0227500080 0229400640 PART NAME RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBERSEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL RUBBER SEAL QTY. 1 2 2 2 2 2 2 2 1 2 2 1 REMARKS 1 DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — NAMEPLATE AND DECALS ASSY. NAMEPLATE AND DECALS ASSY. PAGE 72 — DCA-15SPX4— OPERATION MANUAL — REV.
DCA-15SPX4 — NAME PLATE AND DECALS ASSY. NAMEPLATE AND DECALS ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 PART NO.
TERMS AND CONDITIONS OF SALE — PARTS Effective: October 1, 2002 PAYMENT TERMS 5. Parts must be in new and resalable condition, in the original Multiquip package (if any), and with Multiquip part numbers clearly marked. 6. The following items are not returnable: Terms of payment for parts are net 10 days. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments are F.O.B. point of origin.
NOTE PAGE 1 DCA-15SPX4— OPERATION MANUAL — REV.
PARTS AND OPERATION MANUAL OPERATION AND PARTS MANUAL HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MQ Power 1800 Water Ridge Rd. Tel. (800) 883-2551 Suite 500/600 Fax (972) 315-1847 Lewisville, TX 75057 Contact: mqpower@multiquip.com Web: www.mqpower.com MQ Parts Department 800-427-1244 Fax: 800-672-7877 310-537-3700 Fax: 310-637-3284 Service/Tech Support/Warranty 800-835-2551 Fax: 310-638-8046 © COPYRIGHT 2009, MULTIQUIP INC.
