Specifications

ManualsBrandsMULTIQUIP ManualsAutomotiveMAYCO C30HDZ

MAYCO C30HDZ PUMP — OPERATION AND PARTS MANUAL — REV. #12 (04/03/12) — PAGE 25

ENGINE COMPONENTS

Figure 9. Deutz Model F2L01011F Basic Engine Components

Operating the engine without an air

filter, with a damaged air filter, or a

filter in need of replacement will allow

dirt to enter the engine, causing rapid

engine wear.

NOTE

7. Cooling Fan Blades – Make sure that the blades of the

cooling fan are not

bent or broken

. A damaged fan blade

can cause the engine to run hot and overheat.

8. Crankcase Drain Plug – Remove this plug to drain engine

oil from the crankcase. Replace with recommended engine

oil as specified in the maintenance section of this manual.

9. Fuel Pump/Fuel Filter – Replace or clean the fuel pump

or fuel filter as specified in the maintenance section of this

manual.

10. Muffler/Guard – DO NOT

touch the muffler when engine

is running. The muffler can become extremely hot, causing

severe burns. NEVER run the pump with the muffler guard

removed.

11. Dipstick – Remove this dipstick to determine if engine oil

is low. Maintain oil level at the "H "marking on the dipstick.

NEVER

run engine with low oil.

12. Oil Filler Port Cap – Remove this cap to add engine oil to

the crankcase. Fill with recommended type oil as specified

in the maintenance section of this manual.

REAR VIEW

FRONT VIEW

Figure 9 illustrates the location of the basic components

for the Deutz Model F2L01011F Engine. The function of

each component is described below:

1. Oil Filter – Replace this filter as recommended in the

maintenance section of this manual

2. Oil Pressure Switch – In the event of low oil level, this

switch will shutdown the engine.

3. Starter Motor/Solenoid – NEVER

allow concrete or any

foreign debris to come in contact with the starter motor/

solenoid.

4. Fan V-Belt – ALWAYS make sure that V-belt is properly

tensioned. A loose or defective V-belt can adversely affect

the performance of the pump.

5. Alternator – (not shown) Provides power to the electrical

system. Replace with only manufactures recommended

type alternator.

6. Air Cleaner – Prevents dirt and other debris from entering

the fuel system. Remove wing-nut on top of air filter

cannister to gain access to filter element. Replace with

only manufactures recommended type air cleaner.