OPERATION AND PARTS MANUAL MODEL AR13D RIDE-ON TANDEM DRUM ROLLER SERIES DRIVE SYSTEM (DIESEL ENGINE) Revision #2 (09/15/11) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
AR13D RIDE-ON ROLLER — PROPOSITION 65 WARNING Diesel engine exhaust and some of PAGE 2 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
NOTE PAGE AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — TABLE OF CONTENTS MULTIQUIP AR13D RIDE-ON TANDEM DRUM ROLLER Proposition 65 Warning ............................................. 2 Table Of Contents ..................................................... 4 Parts Ordering Procedures ....................................... 5 Safety Message Alert Symbols .............................. 6-7 Rules For Safe Operation .................................... 8-10 Operation and Safety Decals .............................
www.multiquip.com PARTS ORDERING PROCEDURES Ordering parts has never been easier! Choose from three easy options: Effective: January 1st, 2006 Best Deal! Order via Internet (Dealers Only): If you have an MQ Account, to obtain a Username and Password, E-mail us at: parts@multiquip.com. Order parts on-line using Multiquip’s SmartEquip website! ■ View Parts Diagrams ■ Order Parts ■ Print Specification Information To obtain an MQ Account, contact your District Sales Manager for more information.
AR13D RIDE-ON ROLLER — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others. This Owner's Manual has been developed to provide complete instructions for the safe and efficient operation of the Multiquip Model AR13D Ride-on Tandem Drum Roller.
AR13D RIDE-ON ROLLER — SAFETY MESSAGE ALERT SYMBOLS WARNING - ROTATING PARTS NEVER operate equipment with covers, or guards removed. Keep fingers, hands, hair and clothing away from all moving parts to prevent injury. CAUTION - ACCIDENTAL STARTING ALWAYS place the Engine ON/OFF switch in the OFF position and remove the ignition key when the pump is not in use. CAUTION - OVER-SPEED CONDITIONS NEVER tamper with the factory settings of the engine governor or settings.
AR13D RIDE-ON ROLLER — RULES FOR SAFE OPERATION DANGER - Read This Manual! Failure to follow instructions in this manual may lead to serious injury or even DEATH! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only. The following safety guidelines should always be used when operating the AR13D Ride-on Tandem Drum Roller: GENERAL SAFETY ■ DO NOT operate or service this equipment before reading this entire manual.
AR13D RIDE-ON ROLLER — RULES FOR SAFE OPERATION ■ NEVER Run engine without air cleaner. Severe engine damage may occur. ■ ALWAYS read, understand, and follow procedures in Operator’s Manual before attempting to operate equipment. ■ ALWAYS be sure the operator is familiar with proper safety precautions and operations techniques before using roller. ■ ALWAYS store equipment properly when it is not being used. Equipment should be stored in a clean, dry location out of the reach of children.
AR13D RIDE-ON ROLLER — RULES FOR SAFE OPERATION LOADING AND TRANSPORTING SAFETY DANGER - Loading & Unloading the Roller DANGER! ALWAYS load and unload the roller on Level, Hard Ground, or Pavement. Serious injury or death can result from improper loading, lifting or unloading. Use extreme caution! ■ The roller has an operating weight of approximately 3,088 lbs. (1,400 Kg). Use lifting equipment capable of lifting this weight. ■ ALWAYS check the roller's lifting hooks.
AR13D RIDE-ON ROLLER — OPERATION AND SAFETY DECALS Machine Safety Decals The AR13D Ride-on Tandem Drum Roller is equipped with a number of safety decals. These decals are provided for operator safety and maintenance information. The illustration below and on the next page shows these decals as they appear on the machine. Should any of these decals become unreadable, replacements can be obtained from your dealer. AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — OPERATION AND SAFETY DECALS PAGE 12 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — SPECIFICATIONS (ROLLER) Table 1. AR-13D Roller Specifications Shipping Weight 2,700 lbs. (1,225 Kg.) Dry Weight 2,556 lbs. (1,160 Kg.) Operating Weight 3,360 lbs. (1,524 Kg.) Operating Weight w/ Drum Ballast 3,437 lbs. (1,559 Kg.) Overall Length 90.5 in. (2,286 mm.) Overall Width 38.25 in. (972 mm.) Overall Height-ROPS (up) 87.0 in. (2,210 mm.) Maximum Rolling Width 35.7 in. (907 cm.) Turning Radius-Inside 109 in. (2,768 mm.) Ground Clearance 11.5 in. (292 mm.
AR13D RIDE-ON ROLLER — SPECIFICATIONS (ENGINE) Table 2. Engine Specifications Model Briggs & Stratton DM 850D Type Diesel Engine Number of Cylinders 3 [Bore x Stroke] 2.67 in. x 307 in. (68 mm x 78 mm) Displacement 51.8 cu. in. (850 cc) Horsepower HP@ 3600RPM 23.6 gross 21.1 (net intermittent) 18.3 ( net continuous) Max. Torque Ft./lbs. @ 2400 RPM 40.0/2400 gross 35.0/2400 Dry Weight 185.0 lbs. (84.0 kg.) Engine Oil without Filter 3.17 qts. (3.0 liters) Engine Oil with Filter 3.5 qts.
AR13D RIDE-ON ROLLER — DIMENSIONS (Side View) (Rear View) Figure 1. AR13D Roller Dimensions Table 3. AR-13D Dimensions Wheelbase A 45.0 in. (1,143 mm.) Drum Diameter B 22.6 in. (574 mm.) Curb Clearance C 7.75 in. Left, 19.0 in. Right ( 197 mm., 483 mm.) Drum Width D 35.7 in. (907 mm.) Overall Height (with ROPS) E 87 in. (2,210 mm.) Ground Clearance F 11.5 in. (292 mm.) Overall Length G 90.5 in. (2,147 mm.) Wall Clearance H 1.75 in. Left, 1.25 in. Right ( 45 mm., 32 mm.
AR13D RIDE-ON ROLLER — GENERAL INFORMATION The AR13D roller has been designed for asphalt application and compaction of granular soils used in site preparation. Use the machine only for the purpose intended and by experienced personnel who understand this operating manual and all safety decals. Typical applications for this roller are driveways, patch work and road repairs.
AR13D RIDE-ON ROLLER — GENERAL INFORMATION DANGER - Transporting Safety DO NOT allow personnel to stand under or near any suspended machine. Serious injury or death may result. Tipping (Rollovers) NEVER! operate the roller on side slopes (Figure 3). The possibility exist that the roller could tip over (roll over), thus causing bodily harm even death and serious damage to the equipment.
AR13D RIDE-ON ROLLER — ROLLER COMPONENTS Figure 4. Roller Components 1 PAGE 18 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — ROLLER COMPONENTS Figure 4 shows the location of the components and basic components for the AR13D compaction roller. The function of each component or control is described below: 1. Battery – Provides +12VDC to the electrical system, and is located underneath foot plate. Replace only with recommended type battery, see specification Table 1. 2. Articulating Locking Bar – Always make sure that the articulating locking bar is engaged during lifting, transport and maintenance. 3.
AR13D RIDE-ON ROLLER — ROLLER COMPONENTS Figure 5. Roller Components 2 Figure 5 shows the location of additional components for the AR13D compaction roller. The function of each component or control is described below: 26. Front Sprinkler System – A gravity feed spray bar is provided for the wetting the roll for asphalt pavement. 27. Hydraulic Manifold – Aluminum block that controls the flow of hydraulic pressure to the various hydraulic motors and other components required to control the roller. 34.
AR13D RIDE-ON ROLLER — ENGINE COMPONENTS Figure 6. B&S 850D Diesel Engine Controls and Components INITIAL SERVICING The engine (Figure 6) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual for instructions & details of operation and servicing. 1. Thermostat – Regulates the temperature of the engine coolant. 2. Oil Filler Cap – Remove to add engine oil. 3.
AR13D RIDE-ON ROLLER — INSPECTION 3. Check the oil level shown on the dipstick (Figure 8). Before Starting 1. Read safety instructions at begining of manual. 2. Clean the ROLLER, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required. 4. Check carburetor for external dirt and dust. Clean with dry compressed air. 5.
AR13D RIDE-ON ROLLER — INSPECTION Fuel Check DANGER - EXPLOSIVE FUEL NEVER fill the fuel tank while the engine is running or in the dark. Fuel spillage on a hot engine can cause a fire or explosion. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. 4. If the fuel level is low, remove the fuel fillercap/guage and fill with #2 diesel fuel. Wipe up any spilled fuel immediately. 5. Pay attention to the fuel tank capacity when replenishing fuel (Figure 12).
AR13D RIDE-ON ROLLER — INSPECTION Battery Check A 12-volt DC battery (Figure 16) is shipped dry, and will require a proper electrolyte level for operation. ALWAYS be sure that the battery cables are properly connected to the battery terminals as shown below. Generally the RED cable will be connected to the positive terminal of the battery, and the BLACK cable will be connected to the negative terminal of the battery. Figure 14. Hydraulic Oil Reservoir Filler Port Figure 16. Battery Water Tank Check 1.
AR13D RIDE-ON ROLLER — INITIAL START-UP Initial Start-up Instructions PUSH-IN, THEN PULL TO SET THROTTLE (RPM’s) Starting CAUTION - General Operation Safety DO NOT attempt to operate the roller until the Safety, General Information and Inspection sections have been read and understood. 1. Place your foot into the roller's foot step, grab hold of the hand rail located on the steering console, and lift yourself onto the platform. 2.
AR13D RIDE-ON ROLLER — OPERATION OPERATION 3. Try manuvering the roller a few times to get familar with the handling. Also place the travel lever in the oposite direction to get acquainted with driving in reverse. Parking Brake 1. To release the parking brake, press and hold the release button (Figure 21) pull up slightlyon the parking lever, then push the parking brake lever all the way down. 4.
AR13D RIDE-ON ROLLER — MAINTENANCE Maintenance Perform roller maintenance as indicated by Figure 25 and Table 5. Figure 25. Roller Maintenance Schedule Table 5.
AR13D RIDE-ON ROLLER — MAINTENANCE Hydraulic Oil System The hydraulic system consists of a two pump stack directly coupled to the engine. A hydraulic valve block (manifold)is provided for quick and easy testing and troubleshooting. Hydraulic oil is filtered by a screen filter located in the tank filler neck, a 40 micron suction filter located in the tank, and a 10 micron return filter, with cold oil bypass valve located in the return circuit.
AR13D RIDE-ON ROLLER — MAINTENANCE CAUTION - Freewheel Engagement Valve The freewheel engagement valve (towing) is only for emergency use. DO NOT move roller over 2 MPH or long distances as hydraulic system component failure could result. ALLEN WRENCH OPEN CLOSED FREEWHEEL ENGAGEMENT VALVE Figure 27.
AR13D RIDE-ON ROLLER — MAINTENANCE Forward/Reverse Hydraulic Pressure Test 1. Park the machine on a solid flat surface and stop the engine. Set the parking brake and block the front drum securely. On the manifold block install a 5,000 psi pressure gauge to quick disconnect test port 1. 2. Start the engine and run at full throttle. 1. Check hydraulic oil level by viewing the hydraulic oil sight glass. The hydraulic oil level must be below the top and above the bottom of the sight glass.
AR13D RIDE-ON ROLLER — MAINTENANCE Forward/Reverse Relief Valves Drive Adjustment Steering Relief Valve Pressure Adjustment The forward and reverse relief valves (Figure 35) are shim type cartridge type and are located in the hydrostatic pump (not on the manifold block) under plugs 1 and 2 . Plug 2 is located in the same location as plug 1, except it is on the bottom side of the pump. Relief valve 1 is reverse and 2 is forward.
AR13D RIDE-ON ROLLER — MAINTENANCE Removing and Replacing Hydrostatic Pump Drums and Main Frame 1. Set the parking brake. 2. Disconnect the battery. 3. Clean the pump and all connections. 4. Mark and disconnect all hoses and lines from the pump. The front drum is designed to apply vibration and compaction force to the operating surface for compaction. This vibration and compaction force is produced when the vibrator shaft is rotated.
AR13D RIDE-ON ROLLER — MAINTENANCE Figure 37. Front-Right Drum Removal AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — MAINTENANCE STEP 1 STEP 4 M N STEP 2 STEP 3 1. JACK FRAME UP SLIGHTLY AT ARTICULATION JOINT. 3. MARK AND DISCONNECT HOSES FROM MOTOR. 2. REMOVE THE EIGHT ALLEN HEAD SCREWS HOLDING THE SIDE COVER OF THE DRUM SUPPORT PLATE. 4. REMOVE FOUR ALLEN HEAD SCREWS FROM DRUM SUPPORT PLATE. (SCREWS MAY NEED TO BE HEATED TO REMOVE) 5. PULL DRUM SUPPORT PLATE OFF DRIVE PLATE ASSEMBLY. 6. REMOVE FOUR ALLEN HEAD SCREWS SECURING MOTOR TO DRUM SUPPORT PLATE AND SET ASIDE. 7.
AR13D RIDE-ON ROLLER — MAINTENANCE STEP 6 STEP 4 STEP 2 STEP 3 I STEP 5 J STEP 1 STEP 4 4. REMOVE ALLEN HEAD SCREWS HOLDING THE SIDE COVER OF THE DRUM SUPPORT PLATE. 1. JACK FRAME UP SLIGHTLY AT ARTICULATION JOINT. 2. REMOVE THE FOUR ALLEN HEAD SCREWS SECURING THE DRUM SUPPORT PLATE TO THE FRAME. 5. MARK AND DISCONNECT HOSES FROM MOTOR. 6. REMOVE FOUR ALLEN HEAD SCREWS FROM DRUM SUPPORT PLATES. 3. REMOVE NUTS SECURING BEARING FLANGE TO BASE OF DRUM SUPPORT PLATE. 7.
AR13D RIDE-ON ROLLER — MAINTENANCE Alternator/Regulator The AR13D is equipped with a 40 amp charging system. This system uses three charge coils connected in parallel. The windings of each coil are wound with heave-duty insulated wire and are further protected by insulating material for long life. A voltage regulator is provided to control the amount of charge voltage being delivered to the 12 volt electrical system. For servicing this charging system, contact your engine dealer.
AR13D RIDE-ON ROLLER — PREPARATION FOR LONG-TERM STORAGE Roller Storage For storage of the roller for over 30 days, the following is recommended: Drain the fuel tank completely, or add STA-BIL to the fuel. Run the engine until the fuel in the injection system is completely consumed. Completely drain used oil from the engine crankcase and fill with fresh clean oil, then follow the procedures described in the engine manual for engine storage.
AR13D RIDE-ON ROLLER — MANIFOLD TEST PORTS Figure 29. Manifold Test Ports PAGE 38 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HYDRAULIC SYSTEM DIAGRAM Figure 30. Hydraulic System Diagram AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D ROLLER — ELECTRIC WIRING DIAGRAM Wiring diagram not available at this time. PAGE 40 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
NOTE PAGE AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HYDRAULIC HOSE CONNECTIONS MANIFOLD FROM OPERATOR’S POSITION FRONT RIGHT SIDE H C G F B G A E D B A F C FRONT LEFT SIDE E D HYDRAULIC DRIVE PUMP FROM OPERATOR’S POSITION NOTES HOSES SHADED FOR VISUAL CLARITY. Figure 32. Hydraulic Hose Connections 1 PAGE 42 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HYDRAULIC HOSE CONNECTIONS FRONT RIGHT MOTOR Q STEERING COLUMN O Q O P K MANIFOLD L P K L N M I J FROM OPERATOR’S POSITION REAR LEFT MOTOR J I M N FRONT LEFT MOTOR NOTES HOSES SHADED FOR VISUAL CLARITY. Figure 33. Hydraulic Hose Connections 2 AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — TROUBLESHOOTING (ROLLER) TABLE 6. ROLLER TROUBLESHOOTING SYMPTOM POSSIBLE PROBLEM SOLUTION Low engine RPM? Check and adjust engine speed. Low hydraulic pressure? Check and adjust hydraulic pressure. No voltage to 12 volt solenoid? Check vibration switch, check coil for continuity. No oil pressurel? Check for proper oil pressure or defective relief valve. Broken motor coupler? Replace coupler. Low hydraulic pressure? Check pressure.
AR13D RIDE-ON ROLLER — TROUBLESHOOTING (ENGINE) TABLE 7. ENGINE TROUBLESHOOTING SYMPTON Engine will not star t or star t is delayed, although engine can be turned over. POSSIBLE PROBLEM No Fuel reaching injection pump? Add fuel. Check entire fuel system. Defective fuel pump? Replace fuel pump. Fuel filter clogged? Replace fuel filter and clean tank. Faulty fuel supply line? Replace or repair fuel line. Compression too low? Check piston, cylinder and valves.
AR13D RIDE-ON ROLLER — TROUBLESHOOTING (ENGINE) TABLE 7. ENGINE TROUBLESHOOTING (CONTINUED) SYMPTON Low engine power, output and speed. Low engine power output and low speed, black exhaust smoke. Air-cooled diesel engine runs very "HOT". Cylinder head overheats. POSSIBLE PROBLEM SOLUTION Fuel tank empty? Replace fuel filter. Fuel filter clogged? Replace fuel filter. Fuel tank venting is inadequate? Ensure that tank is adequately vented.
NOTE PAGE AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
EXPLANATION OF CODE IN REMARKS COLUMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are any questions. NOTICE The contents and part numbers listed in the parts section are subject to change without notice. Multiquip does not guarantee the availability of the parts listed. SAMPLE PARTS LIST NO. 1 2% 2% 3 4 PART NO. PART NAME QTY. REMARKS 12345 BOLT......................1 .....
AR13D RIDE-ON ROLLER — SUGGESTED SPARE PARTS AR13D Ride-on Tandem Drum Roller w/Briggs and Stratton Diesel Engine 1 to 3 Units Qty. P/N Description 1 .......... 513324 ................... Forward Reverse Travel Cable ............ 509350SW ............. Neutral Safety Switch 2 .......... 510229 ................... Throttle Cable 6 .......... 508667 ................... Hydraulic Oil Filter 1 .......... 507278 ................... Hydraulic Tank Cap 6 .......... 820311 ................... Fuel Filter 1 ........
AR13D RIDE-ON ROLLER — NAME PLATE AND DECALS NAME PLATE AND DECALS 1 8 9 7 2 14 15 6 4 26 3 10 13 REAR ROLLER 5 11 23 17 24 16 18 12 12 18 25 19 20 21 12 21 20 22 18 PAGE 50 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — NAME PLATE AND DECALS NAME PLATE AND DECALS NO. 1 2 3 4 5 6 7 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 PART NO. 513457 13118 511726 511736 511740 34536 513580 513698 515436 511737 513393 511735 513707 513467 515818 511738 513393 513469 511718 513688 513740 515815 511739 511724 511733 PART NAME QTY.
AR13D RIDE-ON ROLLER — FRONT DRUM ASSY. FRONT DRUM ASSY. PAGE 52 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — FRONT DRUM ASSY. FRONT DRUM ASSY. NO. 2 4 6 8 10 12 14 16 18 20 22 26 28 30 32 34 36 40 41 43 45 47 78 80 82 84 86 88 90 92 94 95 96 98 100 124 126 128 130 PART NO. 513280 506145 506147 506136 508665 506142 011208025 EM923023 492264 506141 508340 020108060 514522 6109210 513283 513314 506220 492362 EM923343 513337 513343 513342 EM963610 3019092 505985 021110120 505977 505984 EM503803 515637 EM924006 511159 515396 505990 515639 505951 513332 515641 513344 PART NAME QTY.
AR13D RIDE-ON ROLLER — EXCITER ASSY. EXCITER ASSY. 58 46 64 74 66 76 52 70 70 1 60 54 62 64 74 FR T N O U R D M 48 46 44 NOTES: INNER BEARINGS ARE INCLUDED 1 WITH ITEM 64. PAGE 54 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — EXCITER ASSY. EXCITER ASSY. NO. 44 46 48 52 54 58 60 62 64 66 70 74 76 PART NO. EM963610 3019092 513285 EM927040 492467 EM963610 506144 490964 506131 513418 506135 513286 513287 PART NAME QTY. REMARKS CAPSCREW, 3/8”N X 1-1/4”G5 6 WASHER, 3/8" ............................................... 12 ............... REPLACES 508346 HOUSING, BEARING RIGHT 1 KEY, WOODRUFF 606 ..................................... 1 ............... REPLACES 506250 SCREW, ALLEN 5/16” 4 CAPSCREW, 3/8” ..........
AR13D RIDE-ON ROLLER — REAR DRUM & CHASSIS ASSY. REAR DRUM & CHASSIS ASSY. PAGE 56 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — REAR DRUM & CHASSIS ASSY. REAR DRUM & CHASSIS ASSY. NO. 2 4 6 8 10 11 12 14 16 18 20 22 24 26 28 30 32 34 35 36 38 40 66 70 72 * 74 * 100 126 128 130 132 PART NO. 513291 505988 492584 503735 514523 513283 509165 6109210 EM963610 3019092 505977 3019092 EM963610 505984 EM503803 515637 515639 513314 511159 EM924006 515396 505990 505951 513349 513266 505976 506185 492367 EM923343 PART NAME QTY. REMARKS REAR DRUM 1 ALLEN PLUG 1 NUT, LOCK 1/2 IN. 2 BEARING, FLANGE ........................
AR13D RIDE-ON ROLLER — COVERS AND FRAME ARTICULATION LOCK ASSY. PAGE 58 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — COVERS AND FRAME ARTICULATION LOCK ASSY. COVERS AND FRAME ARTICULATION LOCK ASSY. NO. 4 6 20 21 22 23 24 27 29 30 32 33 34 136 138 140 142 159 161 162 163 164 166 167 168 170 238 240 242 243 PART NO. 513315 509177 515416 515415 509177 512881 511474 508679 509074 514243 492363 EM923023 EM923343 507888 EM923023 2105164 510875 513314 513471 513328 2101402 492410 506167 EM923023 EM969023 745 29057 492356 EM923057 492581 PART NAME QTY. REMARKS REAR WATER TANK COVER 1 BOLT 5/16 IN.
AR13D RIDE-ON ROLLER — HOOD AND REAR PANEL ASSY. HOOD AND REAR PANEL ASSY. PAGE 60 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HOOD AND REAR PANEL ASSY. HOOD AND REAR PANEL ASSY. NO. 2 4 6 8 10 12 13 15 17 18 22 24 30 32 33 34 90 92 94 96 98 100 102 104 148 150 155 PART NO. 515703 513305 0202 EM923023 2105164 491010 512881 508679 508679 514438 492356 492581 515645 513308 13212 506158 490181 516294 0202 2105164 EM923023 011208025 EM923343 506205 510925 513314 EM506085 PART NAME QTY. REMARKS HOOD 1 HINGE, SLOTTED 2 SCREW, HHC 5/16 X 18 X 1 IN. ...................... 4 ...............
AR13D — STEERING COLUMN AND HYDRAULIC ARTICULATION ASSY. STEERING COLUMN AND HYDRAULIC ARTICULATION ASSY. PAGE 62 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D — STEERING COLUMN AND HYDRAULIC ARTICULATION ASSY. STEERING COLUMN AND HYDRAULIC ARTICULATION ASSY. NO. 16 18 19 22 24 26 28 30 32 34 36 38 40 42 44 46 48 50 52 54 56 58 172 174 176 178 181 182 184 186 188 190 192 194 195 198 200 202 390 391 PART NO.
AR13D RIDE-ON ROLLER — ARTICULATION ARM ASSY. ARTICULATION ARM PAGE 64 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — ARTICULATION ARM ASSY. ARTICULATION ARM NO. 2 4 6 8 10 62 PART NO. 513294 514347 EM505069 513295 513296 514433 PART NAME ROD END BOLT 3/4 IN. x 2-1/2 IN. NUT 3/4 IN. NUT 3/4 IN. ROD, DIRECTION STABILIZER FLAT WASHER 3/4. QTY. 2 2 2 2 1 4 REMARKS AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HYDRAULIC DRIVE PUMP ASSY. HYDRAULIC DRIVE PUMP ASSY. PAGE 66 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — HYDRAULIC DRIVE PUMP ASSY. HYDRAULIC DRIVE PUMP ASSY. NO. 36 54 56 58 60 62 64 66 68 70 72 74 87 190 191 192 196 199 200 201 202 203 204 206 208 209 388 390 391# PART NO. 515803 507845 EM508346 EM175 507860 506187 513310 509144 2105162 2105164 503119 513489 515727 506217 515723 506207 506203 515725 508427C 515726 508343 513339 508428C 506219 506195 515724 EM923343 515811 515811H PART NAME QTY. REMARKS ENGINE, BRIGGS AND STRATTON 850D 1 PUMP, STEERING 1 WASHER 3/8 IN. ...............
AR13D RIDE-ON ROLLER — MANIFOLD AND HYDRAULIC OIL FILTER ASSY. MANIFOLD AND HYDRAULIC OIL FILTER ASSY. PAGE 68 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — MANIFOLD AND HYDRAULIC OIL FILTER ASSY. MANIFOLD AND HYDRAULIC OIL FILTER ASSY. NO. 30 83 87 91 106 108 110 112 114 116 118 120 121 122 124 126 128 130 132 134 136 138 140 144 156 157 158 160 162 164 166 168 170 172 174 176 178 182 186 PART NO.
AR13D RIDE-ON ROLLER — FUEL TANK & OIL DRAIN HOSE ASSY. FUEL TANK & OIL DRAIN HOSE ASSY. PAGE 70 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — FUEL TANK & OIL DRAIN HOSE ASSY. FUEL TANK & OIL DRAIN HOSE ASSY. NO. 124 204 205 206 207 208 210 212 213 214 216 218 220 221 248 252 256 268 270 284 285 290 292 294 342 344 346 362 364 398 400 401 402 403 404 405 PART NO.
AR13D RIDE-ON ROLLER — WATER TANK ASSY. WATER TANK ASSEMBLY ASSY. PAGE 72 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — WATER TANK ASSY. WATER TANK ASSEMBLY ASSY. NO. 8 14 16 17 18 19 84 86 88 90 92 93 94 96 98 100 101 102 103 104 116 118 119 120 122 123 125 128 130 132 266 268 270 PART NO. 513316 509249 514541 491028 506071 506288 513321 EM506085 EM492358 492581 513322 513351 513379 402010060 506086 3019092 EM20426 508435 EM20415 503015 402010060 402010060 402010060 402010060 402010060 508301 508251 506084 EM923023 EM492299 506072 506074 508610 PART NAME QTY.
AR13D RIDE-ON ROLLER — ENGINE MOUNTING ASSY. ENGINE MOUNTING ASSY. PAGE 74 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — ENGINE MOUNTING ASSY. ENGINE MOUNTING ASSY. NO. 36 316 318 319 320 322 324 326 328 330 332 334 336 338 340 450#@ 451#@ 452# PART NO. 515803 515800 492599 492625 515659 EM963057 3019092 EM969013 515650 EM963610 3019092 EM969013 2105162 EM923023 2105164 835034 PART NAME QTY. REMARKS DIESEL ENGINE, BRIGGS AND STRATTON 850D ...... 1 ..........INCLUDES ITEMS W/# BOLT 7/16"NC X 1" G5 2 WASHER 7/16" 2 WASHER 7/16" 2 MOUNT, ENGINE 1 CAPSCREW 3/8"X1-1/2" .....................................
AR13D RIDE-ON ROLLER — MUFFLER ASSY. MUFFLER ASSY. PAGE 76 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — MUFFLER ASSY. MUFFLER ASSY. NO. 212 348 350 352 354 356 358 360 396 412 414 416 418 424 426 428 430 450 PART NO. 506257 515667 515663 493108 0202 EM923023 EM923343 2105164 835029 516291 0202 EM923343 2105164 517127 517328 506886 EM923343 821001 PART NAME QTY. REMARKS U-BOLT 1 MOUNT PLATE, MUFFLER 1 MUFFLER BASE EXTENSION 1 CLAMP 2 SCREW, HHC 5/16-18 X 1 ............................ 1 .................. REPLACES 492364 WASHER FLAT 5/16 ..................................... 1 ........
AR13D RIDE-ON ROLLER — AIR CLEANER ASSY. AIR CLEANER ASSY. PAGE 78 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — AIR CLEANER ASSY. AIR CLEANER ASSY. NO. 376 378 402 452 454 458 PART NO. 515801 515696 835007 515802 M113621 PART NAME QTY. REMARKS AIR INTAKE HOSE 1 HOSE AIR INLET 1 AIR CLEANER .............................................. 1 .................. INCLUDED WITH ENGINE CLAMP 3 MOUNT, AIR CLEANER ............................... 1 .................. INCLUDED WITH ITEM 402 ELEMENT, AIR FILTER 1 AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — RADIATOR ASSY. RADIATOR ASSY. PAGE 80 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — RADIATOR ASSY. RADIATOR ASSY. NO. 45 47 366 368 370 372 374 472 PART NO. 516422 516421 515660 EM506599 2101402 492356 492581 835085 PART NAME QTY. REMARKS TRIM EDGE1" X 1" 2.62' TRIM EDGE 3/4" X 3/4" 2.62' MOUNT RADIATOR OVERFLOW 1 BOLT HEX 6MM X 15 ................................... 2 .................. REPLACES 506599 WASHER SPRING 1/4" ................................ 2 ..................
AR13D RIDE-ON ROLLER — THROTTLE ASSY. THROTTLE ASSY. PAGE 82 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — THROTTLE ASSY. THROTTLE ASSY. NO. 106 108 110 112 114 134 135 136 137 330 PART NO. 513323 513324 516487 508451 513325 510229 G201 DA1252 516116 EM968435 PART NAME TRAVEL LEVER (FWD/REV) CABLE, FORWARD/REVERSE JOINT BALL LOCK NUT 1/4" - 28 NF ADVANCE CABLE SUPPORT CABLE THROTTLE ASSEMBLY KNOB HANDLE LEVER HANDLE NUT 1/4-20 HEX NUT QTY. 1 1 1 1 1 1 1 1 1 1 REMARKS AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — BRAKE CONTROL ASSY. BRAKE CONTROL ASSY. 38 44 36 42 66 52 48 56 60 46 40 50 54 58 62 64 68 70 82 76 78 72 265 74 266 268 267 269 PAGE 84 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — BRAKE CONTROL ASSY. BRAKE CONTROL ASSY. NO. 36 38 40 42 44 46 48 50 52 54 56 58 60 62 64 66 68 70 72 74 76 78 82 265# 266# 267# 268# 269 PART NO. 506046 506158 492303 EM923023 2105164 506057 505999 EM963097 EM969013 506000 508674 506042 506044 508450 506043 2219 4702 EM923348 508449 503116 3019092 EM969013 506001 513320 505997 508566 508386 513193 PART NAME QTY. REMARKS LEVER, BRAKE 1 BOLT 5/16" NC x 3/4" G5 4 BOLT 5/16" NC x 1/1/4" G5 ............................. 1 ...............
AR13D RIDE-ON ROLLER — BATTERY ASSY. BATTERY ASSY. 150 144 146 158 160 154 152 148 156 NOTES: REMOVE ITEMS 20 AND 29 ON PAGE 58 FOR BATTERY ACCESS PAGE 86 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — BATTERY ASSY. BATTERY ASSY. NO. 144 146 148 150 152 154 156 158 160 PART NO. 514391 515119 515115 505624 506266 506153 514387 492359 2101402 PART NAME QTY. REMARKS BATTERY 12V 1 CABLE (-) BATTERY 1 CABLE (+) BATTERY 1 BATTERY TERMINAL COVER ......................... 1 ............... BLACK BATTERY TERMINAL COVER ......................... 1 ............... RED WRAP 1 CLAMP, BATTERY 1 HEX HEAD SCREW 3/8"X2" NC G5 1 WASHER, LOCK 1/4” ...................................... 1 ...........
AR13D RIDE-ON ROLLER — SCRAPER ASSY. SCRAPER ASSY. PAGE 88 — AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
AR13D RIDE-ON ROLLER — SCRAPER ASSY. SCRAPER ASSY. NO. 106 108 110 112 114 116 118 120 122 PART NO. 513290 508433 508434 EM963057 3019092 EM969013 EM963692 492584 621 PART NAME QTY. REMARKS SCRAPER, SUPPORT 4 SCRAPER, RUBBER 4 PLATE BACKING 4 BOLT 3/8” ..................................................... 12 ................ REPLACES 492313 WASHER, FLAT3/8” ...................................... 12 ................ REPLACES 492598 NUT, LOCK 3/8” ............................................ 12 ............
TERMS AND CONDITIONS OF SALE PAYMENT TERMS 5. Parts must be in new and resalable condition, in the original Multiquip package (if any), and with Multiquip part numbers clearly marked. 6. The following items are not returnable: Multiquip reserves the right to quote and sell direct to Government agencies, and to Original Equipment Manufacturer accounts who use our products as integral parts of their own products. a. SPECIAL EXPEDITING SERVICE Terms of payment for parts are net 30 days.
NOTE PAGE AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV.
OPERATION AND PARTS MANUAL HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING UNITED STATES Multiquip Corporate Office 18910 Wilmington Ave. Carson, CA 90746 Contact: mq@multiquip.com MQ Parts Department Tel.