Installation Guide

Parts List
Mounting the Solar Panel
Page 4 of 12
Mounting the solar panels that is free from shade and located in an area that receives maximum sunlight
daily. In the Northern Hemisphere, The best direction to face solar panels is south. However, using your
judgment in figuring out which location gets the most sun, would be helpful. For maximum solar power
absorption through out the day, a tilt-mounting is recommended.
The solar panels can be permanently installed level using the Z-brackets.
Measure the distance between the mounting site and the battery location. The charge controller should
be mounted in close proximity to the battery bank (within 5 feet). Refer to the DC electrical wire guide to
choose an appropriate gauge wire for the length of the wire.
If you choose to mount your Solar Panel on your RV, be sure you solidly mount your panels to the roof. If
you have a rubber roof over thin plywood you may want to use molly fasteners to get a better grip. If you
have a fiberglass roof, drill some pilot holes through the fiberglass to reach plywood below. This will
prevent cracking or damaging the fiberglass. If your RV is equipped with a metal roof you must mount the
solar panel to the joists supporting the roof.
Specification
Property
Solar Cells
Maximum Power(Pmax)
Current at Pmax(Imp)
Voltage at Pmax(Vmp)
Short Circuit Current(Isc)
90W
Crystalline
Indonesia Vietnam
90 W
5.12 A
17.64 V
5.49 A
100W
100 W
5.65 A
18.0 V
5.74 A
110W
110 W
5.81 A
18.90 V
6.27 A
165W
165 W
8.72 A
18.94 V
9.41 A
200W
200 W
9.85 A
20.31 V
10.33 A
215W200W
200 W
9.62 A
20.75 V
9.96 A
180W
180 W
9.51 A
18.94 V
10.34 A
Voltage at open circuit(Voc) 22.12 A 21.6 V 22.31 V 22.31 V 24.35 V 24.75 V
215 W
9.85 A
21.8V
10.24 A
25.33 V22.31 A
Solar panel
SAE to bare end cable 1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
SAE to battery clamp cable*
* This cable can be “Battery clamp to Bare end” in some model.
Z bracket / set
90W
-
1
1
-
1
100W 110W 165W 180W 200W
1
1
1
1
1
215W
Parts Description
Item
Quantity
OptionalPower Inverter
OptionalCharge controller
Manual