V1.1-M 1May2019 Monocrystalline Solar Panel User Manual !90/100 Watt 165/180 Watt 330Watt Kit WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions may result in serious personal injury.
Important Safety Information Thank you for choosing a Nature Power Product. Save the receipt and these instructions. It is important that you read the entire manual to become familiar with this product before you begin using it. This product is designed for certain applications only. the distributor cannot be responsible for issues arising from modification. We strongly recommend this product not be modified and/or used for any application other than that for which it was designed.
Cautions • Never touch the end of output cables with your bare hands when the modules are irradiated. Handle wires with rubber-gloved hands to avoid electric shock • Do not wear metallic jewelry when working on electrical equipment • Product should be installed and maintained by qualified personnel • Do not drop tools or other items on the glass of the solar module • Do not scratch the back film of the solar panel • Avoid exposing solar panels to partial sunlight or shadows.
Parts List Reference Part Description Quantity 1 Solar panel with SAE connector wiring 1 2 SAE-Battery clamp cable 1 3 Mounting Z bracket set 4 Technical Specifications Rated electrical characteristics are within +10 percent of the indicated values of lsc, Voe, Pmax under Standard Test Conditions (irradiance of 100 mW/cm 2, AM 1.5 spectrurn, and a cell temperature of 25℃ {77°F}). The electrical characteristics are based on the results of outgoing test.
Easy Electrical Installation Please confirm that you have all parts to your system before starting instaIlation. Figure 1 shows how to connect the solar panel to the 12 Volt batteries FIGURE!1! Step 1 Connect the charge controller to the solar panel Step 2 Connect the battery clamps to the charge controller Step 3 Connect the battery clamps to the battery in parallel.
Solar Panel Mounting Mounting the Solar panels Choose a site for mounting the solar panels that is free from shade and located in an area that receives maximum sunlight daily. For maximum solar power absorption throughout the day, a tilt-mounting kit is recommended. The solar panels can be permanently installed level using the Z-brackets. Measure the distance between the mounting site and the battery location. The charge controller should be mounted in close proximity to the battery bank (within 5 feet).
Operating Instruction Additional Solar Panels 1. To connect 2 Solar Panels together simply remove the SAE connector at the end of each Solar Panel to reveal at least 2 inches of bare wiring. 2. Once the two wires are exposed they can be connected together by either twisting the wires together or by using solder. When connecting the wires always ensure the correct polarity is observed, Negative (- Black) to Negative and Positive(+ Red) to positive. 3.
Selecting the Correct Charge Controller Charge Controllers may be sold separately and are required for installations of solar systems arrays that are rated 12 Watts and higher. Charge Controllers help to protect the battery(s) and solar panel(s) from harmful reverse currents, battery over charging and high wattage surges, addition protections are found on larger charge controllers.
Run Times Please refer to the run times chart to choose how much solar power your desired system requires. Note that all run times and ratings are approximate and may vary depending on your location and time of day and are based on 7 Hours of full sunlight a day. Rated Hourly 90 Watt 100 Watt 165 Watt 180 Watt 330 Watt (Maximum output) 5.14 Amp 5.71 Amp 9.43 Amp 10.28 Amp 18.86 Amp Weekly Output 4410 Watts/ 251.86 Amps 4900 Watts/ 8085 Watts/ 8820 Watts/ 501 Amps 279.
Limited Warranty Nature Power warrants our products to the original purchaser that this product is free from defects in materials and workmanship for the period of 1 year from date of purchase, 25 year warranted to generate up to 80% of rated power from date of purchase. In the case of product defect, contact Nature Power customer service to receive troubleshooting.
