User Guide

Neutra-Safe

Vertical/Horizontal Condensate Neutralizer

CN2-220V

Installation, Operation and Maintenance Manual

Neutrasafe Corporation

neutrasafe.com

421 Page Street, Suite 1

Stoughton, MA 02072

WARNING

• Neutra-Safecondensateneutralizersshouldonlybeinstalledbyaqualiedprofessional.

• Readallinstructionsbeforeinstalling.Performstepsintheordergiven.Failuretocomplycouldresultinsubstantialpropertydamage,

severepersonalinjury,ordeath.

• Donotallowuegasestoventthroughcondensateneutralizer.Allcondensatedrainlinesmusthaveagastrapbeforeenteringthe

neutralizationunit.Failuretocomplycouldresultinsubstantialpropertydamage,severepersonalinjuryordeath.

• Neutra-Safeneutralizersshouldonlybeconnectedtoacondensateoutletthatisinstalledpertheappliancemanufacturer’sinstructions.

Failuretocomplycouldresultinsubstantialpropertydamage,severepersonalinjuryordeath.

IMPORTANT

• Allpipingshouldbeinaccordancewithrelevantbuildingandmechanicalcodes,aswellasanylocal,stateorfederalregulations.

• Donotconnectmorethanoneappliancetoeachneutralizer.

• Neutralizershouldbeinstalledbelowalltrapsandcondensateoutlets.

• Donotusepipedopeonthreadedttings—useonlyTeontape.Neutra-SafeModelCN2-220Vmaybeinstalledintheverticalor

horizontalposition.Refer to page 2 for installation diagrams.

• Itisrecommendedthattheneutralizerbeinstalledbeforethecondensatepump.

• Allcondensatetrapsshouldbeprimedbeforecommencingoperationoftheappliance.

• Neutra-SafecondensateneutralizermediashouldbereplacedatleastannuallyorwhenpHfallsbelowlocalregulations.

MOUNTING OPTIONS

• ItisrecommendedthatNeutra-Safecondensateneutralizersbeinstalledascloseaspossibletotheoutletofthegastrap.

Refer to page 2 for installation diagrams.

• Usebracketsprovidedformountingneutralizer.

CN2-220V 220,000 Btu/h

Inlet

/8˝

/2˝

/4˝

Outlet 1

/8˝

/2˝

All dimensions ±

/8”

LIMITED WARRANTY

• AllNeutra-SafeproductsarewarrantedagainstdefectsinmaterialsandworkmanshipforONE YEAR.

ThewarrantydoesNOTcoverissuesthatresultfrommisuse,improperinstallation,and/orfailuretoreplacethemedia.

PAGE 1
Neutrasafe Corporation neutrasafe.com 421 Page Street, Suite 1 Stoughton, MA 02072 Neutra-Safe® Vertical/Horizontal Condensate Neutralizer CN2-220V Installation, Operation and Maintenance Manual /2˝ /2˝ 1 1 3/8˝ Inlet 1 CN2-220V 2 3/8˝ 220,000 Btu/h 2 3/4˝ Outlet 1 3/8˝ 14 3/4˝ All dimensions ±1/8” WARNING • Neutra-Safe condensate neutralizers should only be installed by a qualified professional. • Do not allow flue gases to vent through condensate neutralizer.
PAGE 2
INSTALLATION 1. Neutra-Safe condensate neutralizers include built-in unions with 1/2" NPT tappings at either end. 2. Apply TEFLON TAPE ONLY to the threads of provided PVC socket adaptors and attach to neutralizer. *DO NOT OVER TIGHTEN* Over tightening can crack the end cap and create a leak. If over tightening should occur, replacement end caps and lock rings are available for purchase. Over tightening is not covered under warranty. 3. Identify suitable location for assembled condensate neutralizer.