After Sales Technical Documentation COMPACT HANDSFREE UNIT PHF–2 Original, 11/94 NMP Part No.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation AMENDMENT RECORD SHEET Amendment Number Page 2 Date Inserted By Comments Original, 11/94
After Sales Compact Handsfree Unit PHF–2 Technical Documentation COMPACT HANDSFREE UNIT PHF–2 CONTENTS Page No Introduction 5 Technical Summary 5 List of Modules 5 Technical Specifications 6 Modes of Operation 6 Maximum Ratings 7 DC Characteristics 7 Control Signals 8 AC Characteristics 8 External Signals and Connections 9 Mechanical Characteristics 9 Functional Description 10 Circuit Description 10 Input Circuit 10 Power Control Logic 12 Switched Mode Power Supply 12 Audi
Compact Handsfree Unit PHF–2 After Sales Technical Documentation [This page intentionally left blank] Page 4 Original, 11/94
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Introduction The PHF–2 Compact Handsfree Unit forms a major part of the Compact Handsfree Car Kit; the kit provides a simple–to–install, low cost handsfree facility for in–car use. The BABT approved version of PHF–2 is known as PHF–2X. Since both units are technically identical, all references to PHF–2 equally apply to PHF–2X. Technical Summary PHF–2 allows both handsfree (hf) and normal handset (hs) use of the phone.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Technical Specifications Modes of Operation Power Off : The DH3–module does not receive a supply voltage at the DC–connector (X100), hence no voltages are present on the module. Standby : The module receives a supply voltage at the DC– connector but the M2BUS–line (X400) is low (logic ”0” state) because the phone is off and the battery is fully charged. The switching regulator is off and there is no supply voltage for the audio.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Maximum Ratings PIN/ CONNECTOR LINE SYMBOL MAXIMUM UNIT/NOTES X100/1 VB 32 Vdc (without damage) X100/1 VB 1.3 Adc PIN/ CONNECTOR LINE SYMBOL MAXIMUM UNIT/NOTES X300/1 HFSP 3.5 Vrms X300/1 HFSP 3.0 W PIN/ CONNECTOR LINE SYMBOL MAXIMUM UNIT/NOTES X400/1 VC 13 Vdc X400/1 VC 870 mAdc X400/1 VC 150 mVp–p ripple 100...500kHz DC Characteristics Table 3.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Control Signals Table 5. Control Signals (DC–values) PIN/ CONNECTOR LINE SYMBOL MINIMUM TYPICAL/ NOMINAL MAXIMUM UNIT/NOTES X400/2 M2BUS 0 5 Vdc X400/3 PHFS 3.6 0 5.2 0.7 Vdc (speaker on) Vdc (speaker off) X400/4 GND (logic) 0 Vdc X400/5 AGND (audio) 0 Vdc X400/6 XEAR/HFJPWR 1 X400/7 XMIC/JCONN 0 X400/8 AGND (audio) 2.5 4 Vdc 10 Audio–Vdc 0 Vdc AC Characteristics Table 6.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation External Signals and Connections Table 9. DC Supply Connector, Uin 13.2VDC PIN LINE SYMBOL PARAMETER 1 VB Input Current 1 VB Input Current 1 VB Input Current 2 GND Logic Ground MIN TYPICAL/ NOMINAL 50 MAX UNIT/NOTES 0.8 1 mA Power Off 70 90 mA Power On, No Charging 0.6 0.8 A Power On, Charging On Table 10. DC HF–microphone Connector PIN LINE/ SYMBOL PARAMETER MIN TYPICAL/ NOMINAL MAX 5.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Functional Description Figure 1: Block Diagram AUDIO REGULATOR THERMAL PROTECTION POWER SUPPLY HANDSFREE MICROPHONE AMPLIFIER SWITCHED MODE POWER SUPPLY HANDSFREE LOUDSPEAKER AMPLIFIER Circuit Description Input Circuit The input circuit contains the following components: – C1 – EMI capacitor – F1 – foil fuse – L1 / L2 – EMI suppressor chokes – V1 – voltage suppressor diode (zener type) Page 10 Original, 11/94
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Figure 2: Component Layout Diagram Original, 11/94 Page 11
Compact Handsfree Unit PHF–2 After Sales Technical Documentation Power Control Logic Power is applied to the audio devices via P–FET V410 and 10V regulator N100 (VBSW) when the M2BUS signal goes high. The XEAR signal can also switch the power on for 5 seconds as the XEAR signal goes low. The same 5 second power–on also occurs when power is applied and the MBUS and XEAR signals are low. C11 acts as a timing capacitor to generate this second period.
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Figure 3: Cable Interconnection Diagram Mini UHF Connector Mini RF Connector W001 X001 PHF–2 CONNECTOR (TO X400) PHONE CONNECTOR E1 X002_1 VC X1–1 VC WHITE E2 X002_3 XEXAUD /PHFS X1–2 XEXAUD /PHFS GREEN E3 X002_8 AGND S1 BLUE X1–3 HOOK E4 X002_6 XEAR X1–4 XEAR YELLOW E8 X1–5 DGND X002_4 DGND BROWN E5 X002_2 MBUS C1 68n X1–6 VC X1–7 MBUS RED E6 X002_5 AGND X1–8 AGND BLACK E7 X002_7 XMIC X1–9 XMIC ORANGE X1–1
Compact Handsfree Unit PHF–2 After Sales Technical Documentation Assembly Figure 4: Exploded View Page 14 Original, 11/94
After Sales Compact Handsfree Unit PHF–2 Technical Documentation Assembly Parts ITEM QTY CODE DESCRIPTION VALUE 1 1 9450368 Front Cover D6472 2 1 9450255 Cover B 1D22197 3 1 9450369 Cover C D6473 4 1 9380154 Type Label 4D22419 5 2 6293012 Pt–Screw KB22X8 WN1442 6 1 5140098 Loudspeaker 4C23574 7 1 0200376 DC7 Connector Module 8 1 9510211 Holder 4D24728 9 1 9309555 Loudspeaker Cloth A4D40368 10 1 5469800 Accessory Plug Casing MQ138–NKK 11 4 6292240 P
After Sales Compact Handsfree Unit PHF–2 Technical Documentation R222 R223 R224 R225 R226 R227 R231 R232 R233 R234 R235 R236 R301 R302 R303 R304 R305 R308 R309 R401 R402 R403 R404 R405 R407 R408 R409 R410 R411 R412 R413 R414 R415 C001 C011 C012 C111 C201 C202 C210 C211 C212 Page 16 1412335 1412430 1412430 1412430 1414283 1414283 1414283 1414283 1414283 1414283 1414109 1412430 1413829 1413829 1412261 1412416 1412261 1414109 1412430 1415784 1413635 1411669 1412423 1414420 1413635 1415600 1415600 1411123
After Sales Compact Handsfree Unit PHF–2 Technical Documentation C213 C214 C215 C216 C217 C218 C219 C220 C231 C232 C233 C235 C236 C250 C251 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C312 C401 C402 C403 C404 C405 C406 C408 C409 C410 C411 L001 L002 L400 L401 V001 V010 2604209 2310336 2604209 2604209 2310449 2604209 2604209 2310336 2310720 2310784 2310336 2310784 2310784 2310784 2310336 2502736 2310336 2310784 2604431 2310784 2310784 2604431 2310784 2310784 2310336 2310336 2309517 2501605 2309517 2
Compact Handsfree Unit PHF–2 After Sales Technical Documentation V011 V012 V014 V020 V030 V040 V041 V202 V203 V400 V401 V402 V403 V404 V405 V406 V407 V408 V409 V410 V411 V412 N100 N200 N300 N401 N402 X100 X200 X300 X400 Page 18 4107040 4108639 4108639 4210106 4210106 4200610 4107026 4210106 4100285 4215954 4210106 4210108 4108639 4108639 4110074 4107160 4107027 4108639 4108639 4200917 4107160 4107027 4340108 4301182 4303440 4305236 4301062 5414943 5407016 5416640 5416638 9460035 9853924 Zener diode BZX