MODEL 6500 DPG, ITEM # 165930 Diesel Portable Generator P ro v e n P e rf o rm a nc e M165930A OWNER’S MANUAL 00308 6500 DPG Shown with Optional Wheel Kit (Item # 165916) Any Questions, Comments, or Problems? Call Customer Service at 1-800-270-0810 Hours: Monday - Friday 7:00 AM to 5:30 PM CST Saturday 7:30 AM to 11:30 AM CST
THANK YOU Thank you for purchasing a NorthStar Diesel Series Generator. Your machine is designed for long life, dependability, and the top performance you demand. Please take time now to read through this manual so you can better understand the machine’s operation, maintenance and safety precautions. Everyone who operates this generator must read and understand this manual. The time you take now will prolong your generator’s life and prepare you for its safe operation.
SPECIFICATIONS Item Number Maximum Output Continuous Output Voltage Phase Frequency Power Factor Engine Engine Speed Fuel Type Fuel Capacity Oil Capacity Starting Method 120V Receptacle 120/240V Receptacle Circuit Breakers Grounding Screw Dimensions Length Width Height Dry Weight Gross Weight 165930 6500 Watts (W) 6120 Watts (W) 120 / 240 Volt (V) Single phase (4-wire) 58.0-63.0 Hertz (Hz) 1.0 p.f. 10 HP Yanmar L100AE-DEG 3480-3720 RPM Diesel 6.5 gallons (24.6 L) 1.76 US quarts (1.
MACHINE COMPONENT IDENTIFICATION Figure 1 (Ref. 1-11) Ref. 1 2 3 4 5 6 7 8 Description Ref. Gas Cap with Gauge 6.5 Gallon Fuel Tank Operation Instructions Control Panel Oil Filter Access Cover Oil Drain Plug Oil Fill and Dip Stick Recoil Handle 9 10 11 12 13 14 15 16 00309 Description Air Cleaner Housing Muffler Decompression Lever Warning Decals Ignition Fuse Isolation Mounts Battery Box and Battery Generator Figure 2 (Ref.
machine to “walk” which is common in most engine powered equipment. If the mounts appear damaged, replace with factory approved parts. Reference 15 -Battery Box and Battery. The battery is located inside the battery box and is intended for starting the engine. Reference 16 - Generator. Your NorthStar product is equipped with a high quality brushless generator. The generator is maintenance free and will provide years of dependable service. GENERATOR FEATURES Reference 1 - Gas Cap w ith Gauge.
The reset button must be pushed to reset the receptacle. Reference 20 - 120 Volt-30 Amp Tw istlock Receptacle. The control panel is equipped with one NEMA L5-30R receptacle. This receptacle accepts only NEMA L5-30P plugs, one of which is shipped with the generator. Reference 21 120/240 Volt-30 Amp Tw istlock Receptacle. The control panel is equipped with one NEMA L14-30R receptacle. This receptacle accepts only NEMA L14-30P plugs, one of which is shipped with the generator.
WARNING This generator is equipped WARNING Check fuel system on a with a grounding screw located on the rear of the generator for your protection. Always complete the grounding path from the generator to a copper pipe/rod that is driven into moist earth, to prevent electrical shock. regular basis. Look for signs of leaks, deterioration, chafed or spongy fuel hose, loose or missing fuel hose clamps, damaged fuel tank or a defective fuel shut-off valve. Correct any defects before operation.
contaminants. Over time the effectiveness of the insulation is eliminated and a dead short can result. Always compare the generator nameplate data with that of the equipment to be used to ensure that watts, volts, amperage, and frequency requirements are suitable for operating equipment. The wattage listed on the equipment nameplate is its rated output.
40 50 9600 12000 30’ 15’ 15’ 10’ * * * * *Not recommended CAUTION: Equipment damage can result from the low voltage caused by using an extension cord with a small wire size. Submersible Pump (1/2 HP) 1500 (a) Sump Pump 600 (a) Table Saw (10”) 2000 (a) Television 500 Toaster 1000 Vacuum cleaner 250 VCR 70 Water Heater 3000 Weed Trimmer 500 (a) Hard-starting motors require 3 to 5 times the rated running watts.
so could result in damage to equipment plugged into the unit and possible injury to the individual. All engines have a tendency to slow down when a load is applied. When the electrical load is connected to the generator, the engine is more heavily loaded, and as a result the speed drops slightly. This slight decrease in speed, together with the voltage drop within the generator itself, results in a slightly lower voltage when the generator is loaded to its full capacity than when it is running with no load.
generator base. Use a deflector (piece of cardboard or paper) to direct the oil down the hole. 6: Allow fuel to drip from the fuel line into a small container. 7. Reattach the fuel line to the fuel injector. GENERATOR CARE The generator is a two pole, 3600 RPM, 60 Hz, brushless, revolving field and synchronous type with one sealed radial roller bearing.
TROUBLESHOOTING Problem Possible Causes Possible Remedies Engine will not start. a) Low oil level. b) Air in the line. Circuit breaker trips. a) Defective load connected to generator. b) Defective receptacle. c) Generator overloaded. a) Fill crankcase to proper oil level. b) Bleed the air from the fuel line. (see page 9) c) Fill fuel tank. d) Charge or replace battery. e) Replace fuel filter. f) Turn the valve to the ON position. a) Bring generator to a qualified technician for adjustment.
