Product Manual

Storage
16
Prepare the water pump for end-of-season storage by running clean water through the system. This will
flush out any contaminants and clean the water pump internals. After the water pump has been flushed
with clean water, completely drain the water pump of all water to protect from freezing.
WARNING
Gasoline vapors can ignite and cause a fire. Select a well-ventilated storage area away
from sources of heat, flame, or sparks.
CAUTION
The water pump will be damaged if it freezes.
Protect the water pump from freezing during storage by following the instructions below.
Preparing for storage:
1. Flush the
pump
Flush the pump with clean water after each use is advised. Some liquids being
pumped may leave a solid or sticky residue. This may shorten the life of your pump.
2. Drain the
water pump
Using the water pump drain plug, drain the water pump completely of water to
prevent freezing.
3. Engine
storage
Refer to the engine manual for proper engine storage instructions.
- Always disable the engine for storage by unplugging the spark plug wire.
CAUTION: Gasoline will oxidize and deteriorate in storage. Old gasoline in the
engine will cause hard starting and leave gum deposits that can clog the fuel
system. Deterioration problems may occur within a few months, or even less if
gasoline was not fresh when you filled the fuel tank.
Short-Term Storage:
Consider adding a fuel stabilizer to extend fuel storage life.
Long Term Storage: (between infrequent uses and at end of season)
Drain the fuel tank and carburetor as instructed in the engine owner’s manual.
Important Safety Instructions:
• Always drain fuel from tank in outdoor, well-ventilated area.
• Stay away from sources of heat, flame, or sparks while handling fuel.
• Clean up fuel spills/splashes immediately.
4. Water pump
storage
location
Store the water pump in a location away from corrosive material, sources of
heat, open flames, sparks or pilot lights.
WARNING: Never store water pump inside where there is a source of heat or
an open flame, spark, or pilot light as on water heaters, space heaters, furnaces,
clothes dryers, or other gas appliances EVEN IF the water pump’s gas tank is
empty.
5. Gasoline
storage
Store gasoline in a cool, dry place in a UL approved, tightly sealed container.
WARNING: Gasoline vapors can ignite if they collect inside an enclosure and
an explosion can result.