Product Manual
Page 8 of 25
Specific Operation Warnings
To avoid fatal accident
Stop the engine before refueling and be careful not to spill fuel. Spilled fuel may ignite.
Do not refuel the engine near flammable objects to avoid fire.
Do not run the engine in enclosed areas to prevent carbon monoxide poisoning.
To protect the operator
When fatigued from operation, stop the machine and take break.
Hearing protection is required as this machine creates a noise emission level of about
104 dB while 1 m (3 feet) away from the equipment.
To avoid injury or damage
The compactors are only operated by authorized persons who:
- are at least 18 years of age.
- are physically and mentally able to operate the plate compactor.
- are properly trained in the operation and the maintenance of the plate compactor by
the owner or its authorized representative.
- are assessed to be able to carry out their duties reliably.
Do not operate the compactor when any condition endangers the safety of the operator.
Correct the condition before operating the compactor.
Do not operate the compactor while under the influence of medication or alcohol.
The operator must monitor the immediate area all the times. Do not operate the
compactor if a person is in the immediate area because cracked and bounced rock may
cause injury. Also monitor other objects within 20m in case of lighting.
The compactor can only be operated under adequately stable conditions.
The operator must turn off the compactor completely as described in this manual before
leaving the operating position. Also, the compactor must be secured against
unauthorized use.
The engine must be turned off and secured against re-starting by pulling out the spark
plug before maintenance and servicing.
The compactor has to be inspected by an authorized service technician on a regular
basis (at least once a year). The compactor generates mechanical heat so do not touch
the engine, muffler or other parts during the operation, which may cause a burn. Please
wait until the compactor cools down before inspecting components.
The operator must be fully equipped with safety equipment including a helmet, safety
gloves, safety shoes, safety glasses, a mask, and hearing protection before operating
the compactor.
Do not insert a hand or finger between the pulley cover and engine during operation as it
will break the hand or finger.
Sprinkle the water on the working area to avoid dust before operating but NEVER
operate the compactor if the working area is too wet because it may damage the life
cycle of the product.
Lift the plate compactor by the curve in the top center of the frame using a proper lifting
crane. Lifting the compactor by hand may cause personal injury due to its heavy weight.
Securely fasten the compactor for transportation. Insecure fastening of the compactor