Product Manual

Page 8 of 17
Operating Instructions
The operator is responsible for the safe operation of this aerator. The operator must be properly
trained. Operators should be familiar with the equipment, the tractor, and all safety practices before
starting operation. Read the safety rules and the safety decals.
Recommended tractor ground speed is from 2 to 5 mph.
WARNING
 Power unit must be equipped with ROPS or ROPS cab and seat belt. Keep seat belt securely
fastened. Falling off power unit can result in death from being run over or crushed. Keep foldable
ROPS system in “locked up” position at all times.
 Never allow children or untrained persons to operate this equipment.
 Keep bystanders away from this equipment.
 NEVER GO UNDERNEATH EQUIPMENT. Never place any part of the body underneath
equipment or between moveable parts, even when the engine has been turned off. Hydraulic
system leak-down, hydraulic system failures, mechanical failures, or movement of control levers
can cause equipment to drop or rotate unexpectedly and cause severe injury or death.
- Service work does not require going underneath implement.
 Keep hands, feet, hair, and clothing away from equipment while the engine is running. Stay clear
of all moving parts.
Pre-Operation Check List (Owner’s Responsibility)
 Review and follow all safety rules and safety decal instructions.
 Check that equipment is properly and securely attached to the tractor.
 Check that all safety decals are installed and in good condition. Replace if damaged.
 Do not allow riders.
 Check that all hardware is properly installed and secured.
 Check all lubrication points and grease as instructed in Lubrication Information section (page
16).
 Make sure tractor ROPS or ROPS CAB and the seat belt are in good condition. Keep the seat
belt securely fastened during operation.
Core Aerator Operation
The Core Aerator is designed to reduce the soil compaction of an established turf area. The hardened
spoons attached to the reels penetrate and remove a 3/4 x 4-1/2” plug from the soil. Up to 1000 lb of
additional weight can be added to the frame to ensure the proper penetration by the spoons.
The power for operating the aerator is developed through the weight of the equipment and the contact
between the spoons and the turf. The operator should know how to stop the tractor and aerator
quickly in an emergency. Survey the area to be worked and remove any obstructions that may affect
the performance of the equipment.
Tractor Stability
A minimum of 20% tractor and equipment weight must be on the tractor front wheels when
attachments are in transport position. Without this weight, front tractor wheels could raise up resulting
in loss of steering. The weight may be attained with front wheel weights, ballast in tires or front tractor