OWNER'S MANUAL E N G I N E E R E D W I T H T H I N P L AT E P U R E L E A D ( T P P L ) T E C H N O L O G Y EXTREME POWER AND ENDURANCE
INTRODUCTION The ODYSSEY® battery ingeniously uses Absorbed Glass Mat (AGM) technology to offer, in one box, the characteristics of two separate batteries. It can deep cycle as well as provide enormous cranking power – it is almost as if a champion long distance runner and a world class sprinter are one and the same person. These batteries are capable of providing engine cranking pulses in excess of 2250A for five seconds as well as 400 charge/discharge cycles to 80% Depth of Discharge (DOD).
READY OUT OF THE BOX ODYSSEY® batteries are shipped fully charged. If the ODYSSEY battery's voltage is 12.65V or greater, simply install the battery in your vehicle and you are ready to go! If below 12.65V, boost charge following the instructions in the ODYSSEY battery Owner’s Manual and/or Technical Manual. Putting a boost on the battery will not damage it, even if its voltage reads higher than 12.65V.
ODYSSEY® EXTREME SERIES™ BATTERIES M6 FEMALE THREAD PC535 ALL OTHER MODELS PC370 PC950 3/8-16 FEMALE THREAD DIN TERMINAL SAE TERMINALS A 0.732” (18.6mm) B B NEGATIVE 75/86-PC1230 34-PC1500 65-PC1750 0.039” (1.0 mm) A 0.669” (17.0 mm) POSITIVE DIM A DIM B 0.677” POSITIVE (17.2 mm) 0.614” NEGATIVE (15.6 mm) 0.85” (21.6 mm) 1.12” (28.5 mm) 75-PC1230 75/86-PC1230 78-PC1500 34/78-PC1500 DIN TERMINALS A A TERMINAL 3/8-16 THREAD 0.
INSTALLATION 1. Prior to installation note the date code and serial number needed for warranty registeration. 2. Using proper procedures as recommended by the vehicle manufacturer, carefully disconnect the cables from your old battery and remove it from the vehicle. Return the spent battery to the battery dealer for proper recycling. 3. Inspect existing battery cables for corrosion, acid damage or insulation deterioration. Replace if deterioration is present. 4.
ODYSSEY® BATTERY STORAGE AND DEEP DISCHARGE RECOVERY Figure 1 shows the relationship between Open Circuit Voltage (OCV) and State of Charge (SOC) for the ODYSSEY® battery. (A) How do I know the state of charge of the battery? 13.0 12.84V or higher indicates 100% SOC Open circuit voltage (OCV), V 12.8 12.6 12.4 12.2 12.0 (B) How long can the battery be stored? ODYSSEY batteries should be fully charged prior to storage. Fully charged ODYSSEY batteries can be stored for up to 24 months at 77ºF (25ºC).
ODYSSEY® EXTREME SERIES™ BATTERIES PHCA** CCA* HCA MCA (5 sec) Nominal Capacity Short Internal Torque Specs Resistance Circuit in-lbs Current (mΩ) (Nm-max) Reserve Length Capacity inches (20 Hr (10 Hr Minutes (mm) Rate-Ah) Rate-AH Width inches (mm) Height inches (mm) Weight lbs (kg) Terminal 9 5.43 (138.0) 3.39 (86.0) 3.90 (99.0) 5.9 (2.7) M4 Receptacle 8.9 (1.0) 27.1 455A 14 25 7.9 (200.0) 3.0 (77.0) 5.5 (140.0) 12.5 (5.7) M6 Stud 35 (3.9) 13.5 891A 13 21 6.70 (170.2) 3.
ODYSSEY® PERFORMANCE SERIES™ BATTERIES PHCA** CCA* HCA MCA (5 sec) Nominal Capacity Reserve Length Width Height Weight Capacity inches inches inches lbs (10 Hr Minutes (mm) (20 Hr (kg) (mm) (mm) Rate-Ah) Rate-Ah) Internal Short Torque Specs in-lbs Resistance Circuit Current (Nm max) (mΩ) Model Voltage 75/86-705 12 1100 708 875 760 49 45 89 9.46 7.01 7.98 43.4 (240.3) (178.1) (202.7) (19.7) SAE, Side 3/8-16" Receptacle 60 (6.8) side only 2.
To get long life from the ODYSSEY® battery, it is important that the battery is kept near full charge, approximately 12.8V. If there are electrical loads during storage, then the negative battery cable should be disconnected or an independent float charger used. Low power 2.0 amp chargers for storage charge will keep a fully charged battery fully charged but cannot recharge if the ODYSSEY battery becomes discharged.
24V BATTERY CONNECTION To power a 24V trolling motor, you will need to connect two ODYSSEY® batteries in series. As shown in the top illustration, the negative of Battery 1 is wired to the positive of Battery 2. Hook up the positive terminal of Battery 1 to the positive terminal of your trolling motor and the negative terminal of Battery 2 to the negative terminal of the trolling motor.
WINTER STORAGE The ODYSSEY® battery does not lose its charged energy during cold storage temperatures, so there is no need to trickle or float charge during winter months. To store off-season, measure the battery voltage to make sure it is fully charged, 12.84 volts or greater; recharge if necessary. Disconnect the negative battery cable to prevent any applied electrical load during storage. The ODYSSEY battery cannot freeze down to -40°F (-40°C), so it can be left in the vehicle.
WHAT IS COVERED BY THIS WARRANTY? EnerSys Energy Products Inc. (“Manufacturer”) warrants its ODYSSEY® batteries (hereafter referred to as “Battery”) to be free of defects in material and workmanship for the following Applicable Warranty Periods: Extreme Series™ Batteries: • 2 years for Auxiliary Power Unit (APU) and other non-engine start cycling applications. • 2 years for power sports applications. • 3 years for commercial, industrial, marine and automotive applications in non-BCI sizes.
