Manual

ManualsBrandsOutdoor Great Room ManualsGrillsCNG-Traveler Gas Grill

CAUTION: DO NOT DISCARD THIS MANUAL

Cook Number Grill

™

NOTICE TO INSTALLER AND CONSUMER

• Theseinstructionsmustbeleftwiththe

consumerandtheconsumershould

retainthemforfuturereference.

• Read,understandandfollow

theseinstructionsforsafe

installationandoperation.

WARNING

If the information in these instructions

is not followed exactly, a re or explo-

sion may result causing property dam-

age, personal injury or death.

Read the following instructions care-

fully and be sure your grill is properly in-

stalled, assembled and maintained.

Failure to follow these instructions may

result in serious bodily injury and/or

property damage. If you have questions

concerning assembly or operation, con-

sult your dealer, gas appliance service

person or your LP gas company.

WARNING

1. Do not store or use gasoline or other

ammable liquids or vapors in the vi-

cinity of this or any other appliance.

2. An LP cylinder not connected for

use shall not be stored in the vicin-

ity of this or any other appliance.

DANGER

If you smell gas:

Shut off gas to the appliance. 1.

Extinguish any open ame. 2.

Open lid. 3.

If odor continues keep away from the 4.

appliance and immediately call your gas

supplier or your re department.

This outdoor cooking gas appliance is

not intended to be installed in or on recre-

ational vehicles and/or boats.

Installation and service must be performed

by a qualied installer, service agency, or

the gas supplier. In the Commonwealth of

Massachusetts installation must be per-

formed by a licensed plumber or gas tter.

DO NOT

DISCARD

GAS-FIRED

LISTED

TheOutdoorGreatRoomCompany•CookNumberGrillCNG-TRAVELERGasGrill•Rev.A

780-920A5/08

OWNER’S MANUAL

Assembly•

Operation•

Maintenance•

CNG-TRAVELER Gas GRill

Summary of content (16 pages)

PAGE 1
Cook Number Grill ™ CNG-TRAVELER Gas GRill OWNER’S MANUAL • Assembly • Operation • Maintenance GAS-FIRED LISTED CAUTION: DO NOT DISCARD THIS MANUAL NOTICE TO INSTALLER AND CONSUMER • Read, understand and follow these instructions for safe installation and operation. WARNING If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. WARNING 1.
PAGE 2
TABLE OF CONTENTS WARRANTY ................................................................................... 3 SAFETY INSTRUCTIONS ............................................................. 4 SERVICE PARTS LIST................................................................... 6 ASSEMBLY INSTRUCTIONS......................................................... 8 LIGHTING INSTRUCTIONS..........................................................11 COOKING INSTRUCTIONS ..........................................
PAGE 3
WARRANTY Cook Number Grill CNG-TRAVELER Gas Grill Limited Lifetime Warranty The Outdoor GreatRoom Company extends the following warranty for Cook Number Grill - CNG-TRAVELER Gas Grill used in the United States of America or Canada. Dealers and employees of The Outdoor GreatRoom Company have no authority to make any warranty or authorize any remedies in addition to or inconsistent with the terms of this warranty. This warranty gives you specific legal rights.
PAGE 4
Read These Safety Instructions WARNING Fire Risk Explosion Risk Failure to comply with these instructions could result in a fire or explosion which could cause property damage, serious bodily injury or death. WARNING Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. Grill Installation Codes This grill has been tested in accordance with ANSI Z21.582005/CSA 1.6-2005 and ANSI Z21.
PAGE 5
• Never light the gas grill with the lid closed or before checking to insure the burner tubes are fully seated over the gas valve orifices. • Never allow children to operate the grill. Do not allow children to play near the grill. • Never obstruct the flow of combustion and ventilation air to the grill. WARNING Fire Risk Explosion Risk A strong gas smell, or the hissing sound of gas indicates a serious problem with the gas grill or the LPG cylinder. • Get away from the LPG cylinder.
PAGE 6
How to Order Replacement Parts CNG-TRAVELER Service Parts List IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts.
PAGE 7
Assembly Instructions Unpacking and Initial Prep Cleaning 2. Carefully unpack your Cook Number Grill™ and remove all shipping elements used to protect your grill in transit. Before you begin, we first recommend removing the Grilling Grate and the Searing Plate and washing them both with warm soapy water. (See Figure 1). The gas manifold is factory installed as part of the control panel assembly attached to the front of the grill cabinet. 3.
PAGE 8
Step 3. Check Grease Drawer 1. Parts/Items Needed: None 2. Pull the grease drawer out of the grill at the left front corner. Check that the aluminum tray is secured in the brackets underneath the drawer and slide the drawer back into the grill. (See Figure 4). LPG Cylinder NUT Grease Drawer Figure 5 5. Checking For LP Gas Leaks Never test for leaks with a flame. Check for gas leaks prior to first use, at the beginning of each season, or every time the LPG cylinder is changed.
PAGE 9
Step 5. Install Searing Plate and Grilling Grate 1. Parts/Items Needed: Searing plate and grilling grate. 2. 4. Slide the grilling grate into the grill compartment. The back edge will rest on the fixed cross member and the front edge on the front ledge in the compartment. (See Figure 7). Open the grill hood and remove and discard any other debris found in the burner compartment. 3. Hold the searing plate with the two feet on the bottom away from you and set it into the back of the grill compartment.
PAGE 10
Lighting Instructions Basic Lighting Procedures 1. Familiarize yourself with the safety guidelines at the front of this manual. Do not smoke while lighting grill or checking gas supply connections. 2. Be sure the LPG cylinder is filled. 3. Make sure all gas connections are securely tightened. 4. Ensure that 2 - “D” size batteries have been installed. 5. Open the grill lid.
PAGE 11
If the grill fails to light properly: 1. Turn ignitor control knob to OFF. Wait at least five minutes for gas to clear, then retry. • Correction: Inspect the Ignitor junction box found beneath the Control Panel. Connect loose Ignitor wires to the junction box and try to light the grill. 2. Check gas supply and connections. 3. Repeat lighting procedure.
PAGE 12
Cooking Instructions Important: Before cooking on the grill for the first time, wash the grilling grate and sear plate with warm, soapy water. Rinse and dry thoroughly. A Few Tips: • Be sure to wash your hands thoroughly before AND after handling any meat or fish - especially chicken. Burn-off • For tempting grill marks on both sides, flip 3 or 4 minuets before the signal. • For medium and well-done steaks to finish grilling at the same time, sear well-done steaks an extra 30 to 45 seconds.
PAGE 13
Cook number system™ Cook Number System Grill by the numbers and suddenly, you’re an expert. Filets Stuffed Medium Cooked Rare R/MedR MedR Med Well M/MedW MedW Burgers Med MedW Well Brats Med MedW Well Breast Thigh Well WWell Dark The Outdoor GreatRoom Company • Cook Number Grill CNG-TRAVELER Gas Grill • Rev.
PAGE 14
Cleaning and Maintenance Instructions correctly placed inside the end of the burner tube. Also check the position of the spark electrode. (See Figure 11). As with all appliances, proper care and maintenance will keep this grill in top operating condition and prolong its life. By following these cleaning procedures on a timely basis, the grill will stay clean and work properly with minimum effort.
PAGE 15
CAUTION: Be sure the grill is OFF and cool before cleaning. WARNING Annual Cleaning of The Grill Interior Burning-off the grill after every cookout will keep it ready for instant use. However, once a year you should give the entire grill a thorough cleaning to keep it in top operating condition. Follow these steps: 1. Turn all control knobs and OFF/ON switch to the full OFF position.
PAGE 16
Contact Information Please contact your The Outdoor GreatRoom Company dealer with any questions or concerns. For the number of your nearest dealer, please call 952-358-7410. 12400 Portland Ave. So. Burnsville, Mn 55337 www.OutdoorGreatrooms.com Model No.:_________________________________ Serial No.