Manual

TheOutdoorGreatRoomCompany•CookNumberGrillCNG-TRAVELERGasGrill•Rev.A
11
If the grill fails to light properly:
1. TurnignitorcontrolknobtoOFF.Waitatleastvemin-
utesforgastoclear,thenretry.
2. Checkgassupplyandconnections.
3. Repeat lighting procedure. If the grill still fails to op-
erate properly, turn ignitor control knob and OFF/ON
rockerswitchtoOFF,thencheckthefollowing:
• Problem: Pluggedorice
 Correction:RemovetheLPGcylinderconnectiontube,
grateandgreasedrawerfromthegrill.Openthehood
androtatethegrill90ºuntilthecontrolpanelfacesup.
Removethefour5/16inchhexnutsandspacersfrom
theundersideofthecontrolpanel.Usea3/4openend
wrenchtodisconnectthe1/2inchgas extubefrom
thebackoftheorice.Liftthecontrolpaneloffitsfour
studsandset itasidewithout removingtheelectrical
ignitorwire.Insertathin2-3inch needlethroughthe
back of the orice to gently clear any obstructions.
Reinstallthecontrolpanel,andreconnectthegasex
tubeandreinstallallcookingcomponents.
 Ifanobstructionissuspectedinthegasvalve,please
callthegasgrilldealerorgasapplianceserviceperson
forassistance.
• Problem:Misalignmentofignitoronburner
 Correction:Checkforproperpositionoftheelectrode
tip. The tip of the electrode should be pointing over
burnerportsatthetopoftheburner.Thegapbetween
thesparkelectrodeandtheburnershouldbe1/8inch.
Adjustifnecessary.Pressandturnignitorcontrolknob
counterclockwise and check for presence of spark.
(SeeFigure10).
• Problem:DisconnectedIgnitionWires
 Correction:InspecttheIgnitorjunctionboxfoundbe-
neaththeControlPanel.ConnectlooseIgnitorwiresto
thejunctionboxandtrytolightthegrill.
• Problem:Weakbatteries
 Correction: Replace“D”sizebatteriesinignitormod-
uleunderneathgrillcontrolpanel.
4. If all checks or corrections have been made and the
grillstillfailstooperateproperly,removetheLPGcyl-
inderfromthegrillandcallthegasgrilldealerorgas
applianceserviceperson.
WARNING
  ExplosionRisk
  FireRisk
If a “FLASH-BACK” re occurs in or around the
burnertubes:
• Turn the control knob and OFF/ON switch to
OFFposition.
DisconnecttheLPGcylinderfromthegrill.•
• Oncethegrillhascooleddown,cleantheburn-
ertubesandburnersaccordingtothecleaning
instructionsinthismanual.
Failure to comply with these instructions could re-
sultinareorexplosionwhichcouldcauseserious
propertydamage,bodilyinjuryordeath.
Figure 10
SparkElectrode
Burner