User's Manual

CAUTION: FAILURE TO WIRE THIS SWITCH CORRECTLY WILL RESULT IN A
DANGEROUS SITUATION ON THE VEHICLE.
G. If your vehicle has a pressure type brake switch, you may use a relay as shown in Figure 6.3. The
relay must be a SPDT Relay and wired correctly or it could result in a dangerous situation with
the vehicle. The torque converter may not unlock.
The wire labeled FUEL TEST is a test point for the fuel pump. After the vehicle has been wired
and tested OK, tape off this wire and store it in the harness.
H. The wires labeled VATS (lt.green, red and black) are to be connected to the matching wires on the
VATS module supplied in the kit.
Note: The 60508-9 harnesses have a blue VATS signal wire instead of the lt. green.
I. Fan #1 relay wire (green) and fan #2 relay wire (blue) are relay ground wires activated by the
computer.
Note: Fan #1 will come ON at 226°f and go OFF at 217°f.
Fan #2 will come ON at 235°f and go OFF at 226°f.
J. The wire labeled TACH (white) is the signal wire for a tachometer if used.
K. The VSS output wire (green/white) sends out a signal to operate the electronic cruise control or
speedometer if so equipped.
L. The wire labeled SKIP SHIFT LIGHT (white/black) is only used with the T56 manual
transmission. The computer grounds this wire to turn on the skip shift light if used.
6.2.2 Dash Section Connections
WIRE COLOR # OF POSITIONS LABELED CONNECT TO:
IN CONNECTOR
Brown, Red, Orange (2)
1
4 Air Pump Relay Relay
Purple, Pink/Black, Orange (2)
1
4 Air Solenoid Relay Relay
Pink, Green/White
1
2 Canister Purge Canister Purge Solenoid
Pink, White
1
2 Canister Vent Canister Vent Solenoid
Black, Pink/Black
1
2 Air Bleed Air Bleed Solenoid
Black, Red, Pink/Black
1
3 Air Pump Air Pump
Gray, Green/White, Black, Orange 4 Fuel Relay Fuel Pump Relay
Green/White VSS Output Speedometer
White Tach Tachometer
Orange/Black, Black/White Gear Indicator Switch Gear Indicator Switch
Pink, Purple Brake Switch Brake Switch
Pink Fuse Block Ignition Ignition Power
Lt.Green, Red, Black
2
VATS VATS Module
Green Fan #1 Relay Coolant Fan #1 Relay
Blue Fan #2 Relay Coolant Fan #2 Relay
White/Black Skip Shift Light Skip Shift Light
(T56 Trans. Only)
NOTES: 1. Not included in the 60508-9 harnesses.
2.
Lt. Green wire is Blue in the 60508-9 harnesses.
9
TABLE 6.1 Dash Section Connections